IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v14y2021i23p8018-d692500.html
   My bibliography  Save this article

Progress in the Production of Biogas from Maize Silage after Acid-Heat Pretreatment

Author

Listed:
  • Anna Nowicka

    (Department of Environmental Engineering, Faculty of Geoengineering, University of Warmia and Mazury, 10-720 Olsztyn, Poland)

  • Marcin Zieliński

    (Department of Environmental Engineering, Faculty of Geoengineering, University of Warmia and Mazury, 10-720 Olsztyn, Poland)

  • Marcin Dębowski

    (Department of Environmental Engineering, Faculty of Geoengineering, University of Warmia and Mazury, 10-720 Olsztyn, Poland)

  • Magda Dudek

    (Department of Environmental Engineering, Faculty of Geoengineering, University of Warmia and Mazury, 10-720 Olsztyn, Poland)

Abstract

One of the most effective technologies involving the use of lignocellulosic biomass is the production of biofuels, including methane-rich biogas. In order to increase the amount of gas produced, it is necessary to optimize the fermentation process, for example, by substrate pretreatment. The present study aimed to analyze the coupled effects of microwave radiation and the following acids: phosphoric(V) acid (H 3 PO 4 ), hydrochloric acid (HCl), and sulfuric(VI) acid (H 2 SO 4 ), on the destruction of a lignocellulosic complex of maize silage biomass and its susceptibility to anaerobic degradation in the methane fermentation process. The study compared the effects of plant biomass (maize silage) disintegration using microwave and conventional heating; the criterion differentiating experimental variants was the dose of acid used, i.e., 10% H 3 PO 4 , 10% HCl, and 10% H 2 SO 4 in doses of 0.02, 0.05, 0.10, 0.20, and 0.40 g/g TS . Microwave heating caused a higher biogas production in the case of all acids tested (HCl, H 2 SO 4 , H 3 PO 4 ). The highest biogas volume, exceeding 1800 L/kg VS , was produced in the variant with HCl used at a dose of 0.4 g/g TS .

Suggested Citation

  • Anna Nowicka & Marcin Zieliński & Marcin Dębowski & Magda Dudek, 2021. "Progress in the Production of Biogas from Maize Silage after Acid-Heat Pretreatment," Energies, MDPI, vol. 14(23), pages 1-16, December.
    • Handle: RePEc:gam:jeners:v:14:y:2021:i:23:p:8018-:d:692500
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/14/23/8018/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/14/23/8018/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Solarte-Toro, Juan Camilo & Romero-García, Juan Miguel & Martínez-Patiño, Juan Carlos & Ruiz-Ramos, Encarnación & Castro-Galiano, Eulogio & Cardona-Alzate, Carlos Ariel, 2019. "Acid pretreatment of lignocellulosic biomass for energy vectors production: A review focused on operational conditions and techno-economic assessment for bioethanol production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 107(C), pages 587-601.
    2. Monlau, Florian & Latrille, Eric & Da Costa, Aline Carvalho & Steyer, Jean-Philippe & Carrère, Hélène, 2013. "Enhancement of methane production from sunflower oil cakes by dilute acid pretreatment," Applied Energy, Elsevier, vol. 102(C), pages 1105-1113.
    3. Marcin Dębowski & Marta Kisielewska & Joanna Kazimierowicz & Aleksandra Rudnicka & Magda Dudek & Zdzisława Romanowska-Duda & Marcin Zieliński, 2020. "The effects of Microalgae Biomass Co-Substrate on Biogas Production from the Common Agricultural Biogas Plants Feedstock," Energies, MDPI, vol. 13(9), pages 1-13, May.
    4. Binod, Parameswaran & Satyanagalakshmi, Karri & Sindhu, Raveendran & Janu, Kanakambaran Usha & Sukumaran, Rajeev K. & Pandey, Ashok, 2012. "Short duration microwave assisted pretreatment enhances the enzymatic saccharification and fermentable sugar yield from sugarcane bagasse," Renewable Energy, Elsevier, vol. 37(1), pages 109-116.
    5. Kaur, Karamjeet & Phutela, Urmila Gupta, 2016. "Enhancement of paddy straw digestibility and biogas production by sodium hydroxide-microwave pretreatment," Renewable Energy, Elsevier, vol. 92(C), pages 178-184.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Ma, Shuaishuai & Li, Yuling & Li, Jingxue & Yu, Xiaona & Cui, Zongjun & Yuan, Xufeng & Zhu, Wanbin & Wang, Hongliang, 2022. "Features of single and combined technologies for lignocellulose pretreatment to enhance biomethane production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 165(C).
    2. Małgorzata Fugol & Hubert Prask & Józef Szlachta & Arkadiusz Dyjakon & Marta Pasławska & Szymon Szufa, 2023. "Improving the Energetic Efficiency of Biogas Plants Using Enzymatic Additives to Anaerobic Digestion," Energies, MDPI, vol. 16(4), pages 1-12, February.
    3. Dawid Szwarc & Anna Nowicka & Katarzyna Głowacka, 2022. "Cross-Comparison of the Impact of Grass Silage Pulsed Electric Field and Microwave-Induced Disintegration on Biogas Production Efficiency," Energies, MDPI, vol. 15(14), pages 1-10, July.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Panigrahi, Sagarika & Dubey, Brajesh K., 2019. "A critical review on operating parameters and strategies to improve the biogas yield from anaerobic digestion of organic fraction of municipal solid waste," Renewable Energy, Elsevier, vol. 143(C), pages 779-797.
    2. Bateni, Hamed & Karimi, Keikhosro & Zamani, Akram & Benakashani, Fatemeh, 2014. "Castor plant for biodiesel, biogas, and ethanol production with a biorefinery processing perspective," Applied Energy, Elsevier, vol. 136(C), pages 14-22.
    3. Gupta, Aditi & Kumar, Ashwani & Sharma, Satyawati & Vijay, V.K., 2013. "Comparative evaluation of raw and detoxified mahua seed cake for biogas production," Applied Energy, Elsevier, vol. 102(C), pages 1514-1521.
    4. Triolo, Jin M. & Ward, Alastair J. & Pedersen, Lene & Løkke, Mette M. & Qu, Haiyan & Sommer, Sven G., 2014. "Near Infrared Reflectance Spectroscopy (NIRS) for rapid determination of biochemical methane potential of plant biomass," Applied Energy, Elsevier, vol. 116(C), pages 52-57.
    5. Lai, Long Wee & Idris, Ani, 2016. "Comparison of steam-alkali-chemical and microwave-alkali pretreatment for enhancing the enzymatic saccharification of oil palm trunk," Renewable Energy, Elsevier, vol. 99(C), pages 738-746.
    6. Tuan Hoang, Anh & Viet Pham, Van, 2021. "2-Methylfuran (MF) as a potential biofuel: A thorough review on the production pathway from biomass, combustion progress, and application in engines," Renewable and Sustainable Energy Reviews, Elsevier, vol. 148(C).
    7. Alvydas Zagorskis & Regimantas Dauknys & Mantas Pranskevičius & Olha Khliestova, 2023. "Research on Biogas Yield from Macroalgae with Inoculants at Different Organic Loading Rates in a Three-Stage Bioreactor," IJERPH, MDPI, vol. 20(2), pages 1-17, January.
    8. Vasilakou, K. & Nimmegeers, P. & Billen, P. & Van Passel, S., 2023. "Geospatial environmental techno-economic assessment of pretreatment technologies for bioethanol production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 187(C).
    9. Zhang, Cunsheng & Kang, Xinxin & Wang, Fenghuan & Tian, Yufei & Liu, Tao & Su, Yanyan & Qian, Tingting & Zhang, Yifeng, 2020. "Valorization of food waste for cost-effective reducing sugar recovery in a two-stage enzymatic hydrolysis platform," Energy, Elsevier, vol. 208(C).
    10. Budzianowski, Wojciech M., 2016. "A review of potential innovations for production, conditioning and utilization of biogas with multiple-criteria assessment," Renewable and Sustainable Energy Reviews, Elsevier, vol. 54(C), pages 1148-1171.
    11. Simioni, Taysnara & Agustini, Caroline Borges & Dettmer, Aline & Gutterres, Mariliz, 2022. "Enhancement of biogas production by anaerobic co-digestion of leather waste with raw and pretreated wheat straw," Energy, Elsevier, vol. 253(C).
    12. Smichi, Neila & Messaoudi, Yosra & Ksouri, Riadh & Abdelly, Chedly & Gargouri, Mohamed, 2014. "Pretreatment and enzymatic saccharification of new phytoresource for bioethanol production from halophyte species," Renewable Energy, Elsevier, vol. 63(C), pages 544-549.
    13. Baramee, Sirilak & Siriatcharanon, Ake-kavitch & Ketbot, Prattana & Teeravivattanakit, Thitiporn & Waeonukul, Rattiya & Pason, Patthra & Tachaapaikoon, Chakrit & Ratanakhanokchai, Khanok & Phitsuwan, , 2020. "Biological pretreatment of rice straw with cellulase-free xylanolytic enzyme-producing Bacillus firmus K-1: Structural modification and biomass digestibility," Renewable Energy, Elsevier, vol. 160(C), pages 555-563.
    14. Abdullah Nsair & Senem Onen Cinar & Ayah Alassali & Hani Abu Qdais & Kerstin Kuchta, 2020. "Operational Parameters of Biogas Plants: A Review and Evaluation Study," Energies, MDPI, vol. 13(15), pages 1-27, July.
    15. Yiyang Liu & Jingluo Min & Xingyu Feng & Yue He & Jinze Liu & Yixiao Wang & Jun He & Hainam Do & Valérie Sage & Gang Yang & Yong Sun, 2020. "A Review of Biohydrogen Productions from Lignocellulosic Precursor via Dark Fermentation: Perspective on Hydrolysate Composition and Electron-Equivalent Balance," Energies, MDPI, vol. 13(10), pages 1-27, May.
    16. Zhang, Qi & Zhang, Pengfei & Pei, Z.J. & Wang, Donghai, 2013. "Relationships between cellulosic biomass particle size and enzymatic hydrolysis sugar yield: Analysis of inconsistent reports in the literature," Renewable Energy, Elsevier, vol. 60(C), pages 127-136.
    17. Yao, Fengpei & Shen, Fei & Wan, Xue & Hu, Changwei, 2020. "High yield and high concentration glucose production from corncob residues after tetrahydrofuran + H2O co-solvent pretreatment and followed by enzymatic hydrolysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 132(C).
    18. Ester Foppa Pedretti & Andrea Del Gatto & Sandro Pieri & Lorella Mangoni & Alessio Ilari & Manuela Mancini & Gabriele Feliciangeli & Elena Leoni & Giuseppe Toscano & Daniele Duca, 2019. "Experimental Study to Support Local Sunflower Oil Chains: Production of Cold Pressed Oil in Central Italy," Agriculture, MDPI, vol. 9(11), pages 1-12, October.
    19. Zou, Shuzhen & Wang, Hui & Wang, Xiaojiao & Zhou, Sha & Li, Xue & Feng, Yongzhong, 2016. "Application of experimental design techniques in the optimization of the ultrasonic pretreatment time and enhancement of methane production in anaerobic co-digestion," Applied Energy, Elsevier, vol. 179(C), pages 191-202.
    20. De Sanctis, M. & Chimienti, S. & Pastore, C. & Piergrossi, V. & Di Iaconi, C., 2019. "Energy efficiency improvement of thermal hydrolysis and anaerobic digestion of Posidonia oceanica residues," Applied Energy, Elsevier, vol. 252(C), pages 1-1.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:14:y:2021:i:23:p:8018-:d:692500. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.