IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v234y2021ics0360544221014778.html
   My bibliography  Save this article

Composition and properties of fly ash collected from a multifuel fluidized bed boiler co-firing refuse derived fuel (RDF) and hard coal

Author

Listed:
  • Mlonka-Mędrala, Agata
  • Dziok, Tadeusz
  • Magdziarz, Aneta
  • Nowak, Wojciech

Abstract

In Poland, Refuse Derived Fuel (RDF) potential is significant, but high heterogeneity and contamination of the fuel limit its direct use in power industry. In this work samples were collected from a real-scale multifuel unit co-firing RDF with hard coal. Fuel samples and fly ashes collected from secondary cyclone and from bag filter were analysed in details. The thermal behaviour of fly ashes was investigated using X-ray diffraction (XRD), simultaneous thermal analysis (STA) and high-temperature microscope. High content of calcium compounds in both ash samples was noted. To determine the influence of flue gas treatment installation on the ash morphology and composition, Scanning Electron Microscopy with Energy Dispersive Spectroscopy (SEM-EDS) was used. Fly ash after flue gas treatment (FGT) system was much finer and higher content of heavy metals was observed. The mass distribution of mercury and leachability of selected heavy metals from the fly ashes were performed for the analysed unit. The concentration of mercury was several times higher in case of first collected fly ash due to longer contact time of flue gases with ash. Fly ashes contained high amounts of copper, lead and vanadium, but leachability of analysed metals was lower in case of bag filter ash.

Suggested Citation

  • Mlonka-Mędrala, Agata & Dziok, Tadeusz & Magdziarz, Aneta & Nowak, Wojciech, 2021. "Composition and properties of fly ash collected from a multifuel fluidized bed boiler co-firing refuse derived fuel (RDF) and hard coal," Energy, Elsevier, vol. 234(C).
    • Handle: RePEc:eee:energy:v:234:y:2021:i:c:s0360544221014778
    DOI: 10.1016/j.energy.2021.121229
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544221014778
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2021.121229?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Pallarés, Javier & Herce, Carlos & Bartolomé, Carmen & Peña, Begoña, 2017. "Investigation on co-firing of coal mine waste residues in pulverized coal combustion systems," Energy, Elsevier, vol. 140(P1), pages 58-68.
    2. Lucia Rigamonti & Mario Grosso & Laura Biganzoli, 2012. "Environmental Assessment of Refuse‐Derived Fuel Co‐Combustion in a Coal‐Fired Power Plant," Journal of Industrial Ecology, Yale University, vol. 16(5), pages 748-760, October.
    3. Huang, Chao-Wei & Li, Yueh-Heng & Xiao, Kai-Lin & Lasek, Janusz, 2019. "Cofiring characteristics of coal blended with torrefied Miscanthus biochar optimized with three Taguchi indexes," Energy, Elsevier, vol. 172(C), pages 566-579.
    4. Lee, Jong-Min & Kim, Down-Won & Kim, Jae-Sung & Na, Jeong-Geol & Lee, See-Hoon, 2010. "Co-combustion of refuse derived fuel with Korean anthracite in a commercial circulating fluidized bed boiler," Energy, Elsevier, vol. 35(7), pages 2814-2818.
    5. Jagodzińska, Katarzyna & Mroczek, Kazimierz & Nowińska, Katarzyna & Gołombek, Klaudiusz & Kalisz, Sylwester, 2019. "The impact of additives on the retention of heavy metals in the bottom ash during RDF incineration," Energy, Elsevier, vol. 183(C), pages 854-868.
    6. Wang, Dechang & Zhang, Jipeng & Yang, Qirong & Li, Na & Sumathy, K., 2014. "Study of adsorption characteristics in silica gel–water adsorption refrigeration," Applied Energy, Elsevier, vol. 113(C), pages 734-741.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Santa Margarida Santos & Catarina Nobre & Paulo Brito & Margarida Gonçalves, 2023. "Brief Overview of Refuse-Derived Fuel Production and Energetic Valorization: Applied Technology and Main Challenges," Sustainability, MDPI, vol. 15(13), pages 1-22, June.
    2. Gałko, Grzegorz & Mazur, Izabela & Rejdak, Michał & Jagustyn, Barbara & Hrabak, Joanna & Ouadi, Miloud & Jahangiri, Hessam & Sajdak, Marcin, 2023. "Evaluation of alternative refuse-derived fuel use as a valuable resource in various valorised applications," Energy, Elsevier, vol. 263(PD).
    3. Kalisz, Sylwester & Wejkowski, Robert & Maj, Izabella & Garbacz, Przemysław, 2023. "A novel approach to the dry desulfurization process by means of sodium bicarbonate: A full-scale study on SO2 emission and geochemistry of fly ash," Energy, Elsevier, vol. 279(C).
    4. Shizhang Wang & Junjie Wang & Yu Zhang & Linhan Dong & Heming Dong & Qian Du & Jianmin Gao, 2023. "Effect of External Mineral Addition on PM Generated from Zhundong Coal Combustion," Energies, MDPI, vol. 16(2), pages 1-24, January.
    5. Marcelina Bury & Tadeusz Dziok & Karel Borovec & Piotr Burmistrz, 2023. "Influence of RDF Composition on Mercury Release during Thermal Pretreatment," Energies, MDPI, vol. 16(2), pages 1-13, January.
    6. Berkowicz-Płatek, Gabriela & Żukowski, Witold & Leski, Krystian, 2024. "Combustion of polyethylene and polypropylene in the fluidized bed with a variable vertical density profile," Energy, Elsevier, vol. 286(C).
    7. Botakoz Suleimenova & Berik Aimbetov & Daulet Zhakupov & Dhawal Shah & Yerbol Sarbassov, 2022. "Co-Firing of Refuse-Derived Fuel with Ekibastuz Coal in a Bubbling Fluidized Bed Reactor: Analysis of Emissions and Ash Characteristics," Energies, MDPI, vol. 15(16), pages 1-11, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Solmuş, İsmail & Yamalı, Cemil & Yıldırım, Cihan & Bilen, Kadir, 2015. "Transient behavior of a cylindrical adsorbent bed during the adsorption process," Applied Energy, Elsevier, vol. 142(C), pages 115-124.
    2. Zhao, Jingyu & Deng, Jun & Wang, Tao & Song, Jiajia & Zhang, Yanni & Shu, Chi-Min & Zeng, Qiang, 2019. "Assessing the effectiveness of a high-temperature-programmed experimental system for simulating the spontaneous combustion properties of bituminous coal through thermokinetic analysis of four oxidatio," Energy, Elsevier, vol. 169(C), pages 587-596.
    3. Wander, Paulo R. & Bianchi, Flávio M. & Caetano, Nattan R. & Klunk, Marcos A. & Indrusiak, Maria Luiza S., 2020. "Cofiring low-rank coal and biomass in a bubbling fluidized bed with varying excess air ratio and fluidization velocity," Energy, Elsevier, vol. 203(C).
    4. Bi, Haobo & Wang, Chengxin & Lin, Qizhao & Jiang, Xuedan & Jiang, Chunlong & Bao, Lin, 2020. "Combustion behavior, kinetics, gas emission characteristics and artificial neural network modeling of coal gangue and biomass via TG-FTIR," Energy, Elsevier, vol. 213(C).
    5. Najjaran, Ahmad & Freeman, James & Ramos, Alba & Markides, Christos N., 2019. "Experimental investigation of an ammonia-water-hydrogen diffusion absorption refrigerator," Applied Energy, Elsevier, vol. 256(C).
    6. Hassan, H.Z. & Mohamad, A.A. & Al-Ansary, H.A. & Alyousef, Y.M., 2014. "Dynamic analysis of the CTAR (constant temperature adsorption refrigeration) cycle," Energy, Elsevier, vol. 77(C), pages 852-858.
    7. Vershinina, K. Yu & Shlegel, N.E. & Strizhak, P.A., 2019. "Relative combustion efficiency of composite fuels based on of wood processing and oil production wastes," Energy, Elsevier, vol. 169(C), pages 18-28.
    8. Joanna Wnorowska & Szymon Ciukaj & Sylwester Kalisz, 2021. "Thermogravimetric Analysis of Solid Biofuels with Additive under Air Atmosphere," Energies, MDPI, vol. 14(8), pages 1-19, April.
    9. Chen, Wen-Lih & Sirisha, Vadlakonda & Yu, Chi-Yuan & Wang, Yan-Ru & Dai, Ming-Wei & Lasek, Janusz & Li, Yueh-Heng, 2024. "Design and optimization of a combined heat and power system with a fluidized-bed combustor and stirling engine," Energy, Elsevier, vol. 293(C).
    10. Niu, Yanqing & Lv, Yuan & Lei, Yu & Liu, Siqi & Liang, Yang & Wang, Denghui & Hui, Shi'en, 2019. "Biomass torrefaction: properties, applications, challenges, and economy," Renewable and Sustainable Energy Reviews, Elsevier, vol. 115(C).
    11. Kojok, Farah & Fardoun, Farouk & Younes, Rafic & Outbib, Rachid, 2016. "Hybrid cooling systems: A review and an optimized selection scheme," Renewable and Sustainable Energy Reviews, Elsevier, vol. 65(C), pages 57-80.
    12. Hassan Zohair Hassan, 2014. "Performance Evaluation of a Continuous Operation Adsorption Chiller Powered by Solar Energy Using Silica Gel and Water as the Working Pair," Energies, MDPI, vol. 7(10), pages 1-19, October.
    13. Yang, Yan & Wen, Chuang & Wang, Shuli & Feng, Yuqing, 2014. "Theoretical and numerical analysis on pressure recovery of supersonic separators for natural gas dehydration," Applied Energy, Elsevier, vol. 132(C), pages 248-253.
    14. Xiaolin Chen & Junlin Xie & Shuxia Mei & Feng He, 2018. "NOx and SO 2 Emissions during Co-Combustion of RDF and Anthracite in the Environment of Precalciner," Energies, MDPI, vol. 11(2), pages 1-13, February.
    15. Liang Song & Shanjun Liu & Wenwen Li, 2019. "Quantitative Inversion of Fixed Carbon Content in Coal Gangue by Thermal Infrared Spectral Data," Energies, MDPI, vol. 12(9), pages 1-17, May.
    16. Lee, Jong Min & Kim, Dong Won & Kim, Jae Sung, 2011. "Characteristics of co-combustion of anthracite with bituminous coal in a 200-MWe circulating fluidized bed boiler," Energy, Elsevier, vol. 36(9), pages 5703-5709.
    17. Masami Ashizawa & Maromu Otaka & Hiromi Yamamoto & Atsushi Akisawa, 2022. "CO 2 Emissions and Economy of Co-Firing Carbonized Wood Pellets at Coal-Fired Power Plants: The Case of Overseas Production of Pellets and Use in Japan," Energies, MDPI, vol. 15(5), pages 1-10, February.
    18. Riva, Lorenzo & Wang, Liang & Ravenni, Giulia & Bartocci, Pietro & Buø, Therese Videm & Skreiberg, Øyvind & Fantozzi, Francesco & Nielsen, Henrik Kofoed, 2021. "Considerations on factors affecting biochar densification behavior based on a multiparameter model," Energy, Elsevier, vol. 221(C).
    19. Du, Shenglei & Wang, Xianhua & Shao, Jingai & Yang, Haiping & Xu, Guangfu & Chen, Hanping, 2014. "Releasing behavior of chlorine and fluorine during agricultural waste pyrolysis," Energy, Elsevier, vol. 74(C), pages 295-300.
    20. Fakudze, Sandile & Wei, Yingyuan & Shang, Qianqian & Ma, Ru & Li, Yueh-Heng & Chen, Jianqiang & Zhou, Peiguo & Han, Jiangang & Liu, Chengguo, 2021. "Single-pot upgrading of run-of-mine coal and rice straw via Taguchi-optimized hydrothermal treatment: Fuel properties and synergistic effects," Energy, Elsevier, vol. 236(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:234:y:2021:i:c:s0360544221014778. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.