IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v217y2023ics0960148123010583.html
   My bibliography  Save this article

Bimetallic Zrx-Aly-KIT-6 modified with sulfate as acidic catalyst for biodiesel production from low-grade acidic oils

Author

Listed:
  • Zhang, Qiaofei
  • Xie, Wenlei
  • Li, Jiangbo
  • Guo, Lihong

Abstract

For the purpose of fabricating an efficient solid acid catalyst for biodiesel production from low-grade acidic oils, bimetallic silica mesoporous composites with different Zr/Al molar ratios were initially synthesized via a facile one-step hydrothermal method, and then sulfated with sulfuric acid at different concentrations to get a series of sulfated Zrx-Aly-KIT-6 catalysts (denoted as SZA-K, where x/y represents the molar ratio of Zr to Al). The sulfated bimetallic solid catalysts were fully characterized by using XRD, FT-IR, TEM, SEM, EDS, NH3-TPD, and nitrogen porosimetry measurements. Results showed that the remarkable amount of acidic sites in the catalysts was derived from the Zr and Al incorporation and further sulfation, and specifically, the Zr4+ and Al3+ could afford abundant weak acid sites while the inductive effect of SO42− species greatly influences the acidic strength of this solid catalyst. In combination with the enhancement in mass transfer resulting from the inherent interconnected mesoporous structure, the SZA-K catalyst could facilitate the transesterification reaction to take place efficiently. The sulfated Zr5–Al1-KIT-6 catalyst (Zr/Al molar ratio of 5/1, treated using 0.75 mol/L sulfuric acid for 12 h) exhibited enhanced acid strength with larger number of acidic sites (7.81 mmol/g), resulting in a high catalytic performance to the oil transesterification reaction. An oil conversion of 96.3% was attained for the transesterification reaction performed at 120 °C for 7 h by using a methanol/oil molar ratio of 20:1 and a catalyst dosage of 6 wt%. Further, this solid catalyst exhibited better acid and water-resistance capacity with above 80% of oil conversion even with 10% of free fatty acid (FFA) and 2% of moisture present in the low-grade acidic oils. Meanwhile, the good reusability was shown for this catalyst with 80.1% conversion even after reusing for three cycles. The good stability of the solid catalyst was resulted from the strong interactions between the acidic species and the bimetallic composite support.

Suggested Citation

  • Zhang, Qiaofei & Xie, Wenlei & Li, Jiangbo & Guo, Lihong, 2023. "Bimetallic Zrx-Aly-KIT-6 modified with sulfate as acidic catalyst for biodiesel production from low-grade acidic oils," Renewable Energy, Elsevier, vol. 217(C).
    • Handle: RePEc:eee:renene:v:217:y:2023:i:c:s0960148123010583
    DOI: 10.1016/j.renene.2023.119144
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148123010583
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2023.119144?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Shi, Guoliang & Yu, Feng & Wang, Yan & Pan, Dahai & Wang, Huigang & Li, Ruifeng, 2016. "A novel one-pot synthesis of tetragonal sulfated zirconia catalyst with high activity for biodiesel production from the transesterification of soybean oil," Renewable Energy, Elsevier, vol. 92(C), pages 22-29.
    2. Hongxia Cao & Wenyuan Wang & Tianlei Cui & Hongyan Wang & Guang Zhu & Xiangkun Ren, 2020. "Enhancing CO 2 Hydrogenation to Methane by Ni-Based Catalyst with V Species Using 3D-mesoporous KIT-6 as Support," Energies, MDPI, vol. 13(9), pages 1-14, May.
    3. Ambat, Indu & Srivastava, Varsha & Sillanpää, Mika, 2018. "Recent advancement in biodiesel production methodologies using various feedstock: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 90(C), pages 356-369.
    4. Xie, Wenlei & Han, Yuxiang & Wang, Hongyan, 2018. "Magnetic Fe3O4/MCM-41 composite-supported sodium silicate as heterogeneous catalysts for biodiesel production," Renewable Energy, Elsevier, vol. 125(C), pages 675-681.
    5. Xie, Wenlei & Li, Jiangbo, 2023. "Magnetic solid catalysts for sustainable and cleaner biodiesel production: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 171(C).
    6. Sahar, Juma & Farooq, Muhammad & Ramli, Anita & Naeem, Abdul & Khattak, Noor Saeed & Ghazi, Zahid Ali, 2022. "Highly efficient heteropoly acid decorated SnO2@Co-ZIF nanocatalyst for sustainable biodiesel production from Nannorrhops ritchiana seeds oil," Renewable Energy, Elsevier, vol. 198(C), pages 306-318.
    7. Binhayeeding, Narisa & Klomklao, Sappasith & Prasertsan, Poonsuk & Sangkharak, Kanokphorn, 2020. "Improvement of biodiesel production using waste cooking oil and applying single and mixed immobilised lipases on polyhydroxyalkanoate," Renewable Energy, Elsevier, vol. 162(C), pages 1819-1827.
    8. Sandouqa, Arwa & Al-Hamamre, Zayed & Asfar, Jamil, 2019. "Preparation and performance investigation of a lignin-based solid acid catalyst manufactured from olive cake for biodiesel production," Renewable Energy, Elsevier, vol. 132(C), pages 667-682.
    9. Li, Yan & Zhang, Xiao-Dong & Sun, Li & Xu, Min & Zhou, Wen-Guang & Liang, Xiao-Hui, 2010. "Solid superacid catalyzed fatty acid methyl esters production from acid oil," Applied Energy, Elsevier, vol. 87(7), pages 2369-2373, July.
    10. Zhang, Pingbo & Liu, Peng & Fan, Mingming & Jiang, Pingping & Haryono, Agus, 2021. "High-performance magnetite nanoparticles catalyst for biodiesel production: Immobilization of 12-tungstophosphoric acid on SBA-15 works effectively," Renewable Energy, Elsevier, vol. 175(C), pages 244-252.
    11. Laskar, Ikbal Bahar & Changmai, Bishwajit & Gupta, Rajat & Shi, Da & Jenkinson, Kellie J. & Wheatley, Andrew E.H. & Rokhum, Lalthazuala, 2021. "A mesoporous polysulfonic acid-formaldehyde polymeric catalyst for biodiesel production from Jatropha curcas oil," Renewable Energy, Elsevier, vol. 173(C), pages 415-421.
    12. Wang, Quan & Wenlei Xie, & Guo, Lihong, 2022. "Molybdenum and zirconium oxides supported on KIT-6 silica: A recyclable composite catalyst for one–pot biodiesel production from simulated low-quality oils," Renewable Energy, Elsevier, vol. 187(C), pages 907-922.
    13. Xie, Wenlei & Gao, Chunli & Li, Jiangbo, 2021. "Sustainable biodiesel production from low-quantity oils utilizing H6PV3MoW8O40 supported on magnetic Fe3O4/ZIF-8 composites," Renewable Energy, Elsevier, vol. 168(C), pages 927-937.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Xie, Wenlei & Wang, Xiangxiang & Guo, Lihong, 2024. "Utilization of Keplerate-type polyoxomolybdates {Mo132} supported on hierarchical porous SOM-ZIF-8 as reusable catalyst boosts biodiesel production from acidic soybean oils by simultaneous transesteri," Renewable Energy, Elsevier, vol. 225(C).
    2. Xie, Wenlei & Li, Jiangbo, 2023. "Magnetic solid catalysts for sustainable and cleaner biodiesel production: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 171(C).
    3. Zhang, Gaoqiang & Xie, Wenlei, 2024. "Hierarchical porous SAPO-34 decorated with Mo and W oxides for concurrent transesterification-esterifications for efficient biodiesel production from acidic soybean oil," Renewable Energy, Elsevier, vol. 222(C).
    4. Zhu, Jishen & Jiang, Weiqiang & Yuan, Zong & Lu, Jie & Ding, Jincheng, 2024. "Esterification of tall oil fatty acid catalyzed by Zr4+-CER in fixed bed membrane reactor," Renewable Energy, Elsevier, vol. 221(C).
    5. Mijangos, Gabriela E. & Cuautli, Cristina & Romero-Ibarra, Issis C. & Vazquez-Arenas, Jorge & Santolalla-Vargas, Carlos E. & Santes, Víctor & Castañeda-Galván, Adrián A. & Pfeiffer, Heriberto, 2022. "Experimental and theoretical analysis revealing the underlying chemistry accounting for the heterogeneous transesterification reaction in Na2SiO3 and Li2SiO3 catalysts," Renewable Energy, Elsevier, vol. 184(C), pages 845-856.
    6. Xie, Wenlei & Gao, Chunli & Li, Jiangbo, 2021. "Sustainable biodiesel production from low-quantity oils utilizing H6PV3MoW8O40 supported on magnetic Fe3O4/ZIF-8 composites," Renewable Energy, Elsevier, vol. 168(C), pages 927-937.
    7. Gao, Xiu & Chen, Chao & Zhang, Wenlu & Hong, Yanping & Wang, Chunrong & Wu, Guoqiang, 2022. "Sulfated TiO2 supported molybdenum-based catalysts for transesterification of Jatropha seed oil: Effect of molybdenum species and acidity properties," Renewable Energy, Elsevier, vol. 191(C), pages 357-369.
    8. Wang, Quan & Wenlei Xie, & Guo, Lihong, 2022. "Molybdenum and zirconium oxides supported on KIT-6 silica: A recyclable composite catalyst for one–pot biodiesel production from simulated low-quality oils," Renewable Energy, Elsevier, vol. 187(C), pages 907-922.
    9. Rokhum, Samuel Lalthazuala & Changmai, Bishwajit & Kress, Thomas & Wheatley, Andrew E.H., 2022. "A one-pot route to tunable sugar-derived sulfonated carbon catalysts for sustainable production of biodiesel by fatty acid esterification," Renewable Energy, Elsevier, vol. 184(C), pages 908-919.
    10. Safaripour, Maryam & Saidi, Majid & Nodeh, Hamid Rashidi, 2023. "Synthesis and application of barium tin oxide-reduced graphene oxide nanocomposite as a highly stable heterogeneous catalyst for the biodiesel production," Renewable Energy, Elsevier, vol. 217(C).
    11. Zailan, Zarifah & Tahir, Muhammad & Jusoh, Mazura & Zakaria, Zaki Yamani, 2021. "A review of sulfonic group bearing porous carbon catalyst for biodiesel production," Renewable Energy, Elsevier, vol. 175(C), pages 430-452.
    12. Wang, Yue & Liu, Huai & Zhang, Junhua & Cheng, Yuan & Lin, Wansi & Huang, Rulu & Peng, Lincai, 2022. "Direct epitaxial synthesis of magnetic biomass derived acid/base bifunctional zirconium-based hybrid for catalytic transfer hydrogenation of ethyl levulinate into γ-valerolactone," Renewable Energy, Elsevier, vol. 197(C), pages 911-921.
    13. Gualberto Zavarize, Danilo & Braun, Heder & Diniz de Oliveira, Jorge, 2021. "Methanolysis of low-FFA waste cooking oil with novel carbon-based heterogeneous acid catalyst derived from Amazon açaí berry seeds," Renewable Energy, Elsevier, vol. 171(C), pages 621-634.
    14. Elhambakhsh, Abbas & Van Duc Long, Nguyen & Lamichhane, Pradeep & Hessel, Volker, 2023. "Recent progress and future directions in plasma-assisted biomass conversion to hydrogen," Renewable Energy, Elsevier, vol. 218(C).
    15. Okoye, Patrick U. & Wang, Song & Khanday, Waheed Ahmad & Li, Sanxi & Tang, Tao & Zhang, Linnan, 2020. "Box-Behnken optimization of glycerol transesterification reaction to glycerol carbonate over calcined oil palm fuel ash derived catalyst," Renewable Energy, Elsevier, vol. 146(C), pages 2676-2687.
    16. Lau, Pak-Chung & Kwong, Tsz-Lung & Yung, Ka-Fu, 2022. "Manganese glycerolate catalyzed simultaneous esterification and transesterification: The kinetic and mechanistic study, and application in biodiesel and bio-lubricants synthesis," Renewable Energy, Elsevier, vol. 189(C), pages 549-558.
    17. Lani, Nurul Saadiah & Ngadi, Norzita & Haron, Saharudin & Mohammed Inuwa, Ibrahim & Anako Opotu, Lawal, 2024. "The catalytic effect of calcium oxide and magnetite loading on magnetically supported calcium oxide-zeolite catalyst for biodiesel production from used cooking oil," Renewable Energy, Elsevier, vol. 222(C).
    18. Verónica Ávila Vázquez & Miguel Mauricio Aguilera Flores & Luis Felipe Hernández Casas & Nahum Andrés Medellín Castillo & Alejandro Rocha Uribe & Hans Christian Correa Aguado, 2023. "Biodiesel Production Catalyzed by Lipase Extract Powder of Leonotis nepetifolia (Christmas Candlestick) Seed," Energies, MDPI, vol. 16(6), pages 1-13, March.
    19. Seffati, Kambiz & Esmaeili, Hossein & Honarvar, Bizhan & Esfandiari, Nadia, 2020. "AC/CuFe2O4@CaO as a novel nanocatalyst to produce biodiesel from chicken fat," Renewable Energy, Elsevier, vol. 147(P1), pages 25-34.
    20. Savvas L. Douvartzides & Nikolaos D. Charisiou & Kyriakos N. Papageridis & Maria A. Goula, 2019. "Green Diesel: Biomass Feedstocks, Production Technologies, Catalytic Research, Fuel Properties and Performance in Compression Ignition Internal Combustion Engines," Energies, MDPI, vol. 12(5), pages 1-41, February.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:217:y:2023:i:c:s0960148123010583. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.