IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v15y2022i17p6214-d898379.html
   My bibliography  Save this article

Optimal Design of Power-On Downshift Control of Series-Parallel Hybrid Transmission Based on Motor Active Speed Regulation

Author

Listed:
  • Xiangyang Xu

    (School of Transportation Science and Engineering, Beihang University, Beijing 100191, China
    Ningbo Institute of Technology, Beihang University, Ningbo 315832, China)

  • Kun Guo

    (School of Transportation Science and Engineering, Beihang University, Beijing 100191, China
    Ningbo Institute of Technology, Beihang University, Ningbo 315832, China)

  • Xuewu Liu

    (School of Transportation Science and Engineering, Beihang University, Beijing 100191, China
    GAC Automotive Research and Development Center, Guangzhou 511434, China)

  • Hongzhong Qi

    (GAC Automotive Research and Development Center, Guangzhou 511434, China)

  • Peng Dong

    (School of Transportation Science and Engineering, Beihang University, Beijing 100191, China
    Ningbo Institute of Technology, Beihang University, Ningbo 315832, China)

  • Shuhan Wang

    (School of Transportation Science and Engineering, Beihang University, Beijing 100191, China
    Ningbo Institute of Technology, Beihang University, Ningbo 315832, China)

  • Wei Guo

    (Ningbo Institute of Technology, Beihang University, Ningbo 315832, China)

Abstract

Multi-speed transmission is the main development direction of hybrid transmission, which has brought higher shift quality requirements than traditional fuel vehicle transmission. However, there is less research on the shifting control of hybrid transmission, especially for the shifting control of dedicated hybrid transmission (DHT), which uses the wet clutch as a shift element. This paper studies the power-on downshift process of a two-speed series-parallel hybrid transmission, proposes a shifting control strategy based on motor active speed regulation, and deeply analyzes the causes of maximum impact during the shifting process. The results show that the reverse torque produced in the process of eliminating the remaining slip is the root cause of the maximum impact. On this basis, two optimization strategies are proposed to reduce the shift impact and improve the shift quality. The simulation results show that the proposed optimization strategies can effectively suppress the shift impact. In the meanwhile, for any control pressure of the OG (off-going) clutch in the speed phase within the range of (2.44–2.53 bar), a high shift quality in which the maximum impact is controlled lower than 10 m/s 3 can be achieved, which has high engineering value and practical significance.

Suggested Citation

  • Xiangyang Xu & Kun Guo & Xuewu Liu & Hongzhong Qi & Peng Dong & Shuhan Wang & Wei Guo, 2022. "Optimal Design of Power-On Downshift Control of Series-Parallel Hybrid Transmission Based on Motor Active Speed Regulation," Energies, MDPI, vol. 15(17), pages 1-18, August.
    • Handle: RePEc:gam:jeners:v:15:y:2022:i:17:p:6214-:d:898379
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/15/17/6214/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/15/17/6214/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Waruna Maddumage & Malika Perera & Rahula Attalage & Patrick Kelly, 2021. "Power Management Strategy of a Parallel Hybrid Three-Wheeler for Fuel and Emission Reduction," Energies, MDPI, vol. 14(7), pages 1-30, March.
    2. Xie, Shaobo & Hu, Xiaosong & Xin, Zongke & Brighton, James, 2019. "Pontryagin’s Minimum Principle based model predictive control of energy management for a plug-in hybrid electric bus," Applied Energy, Elsevier, vol. 236(C), pages 893-905.
    3. Tang, Xiaolin & Zhang, Dejiu & Liu, Teng & Khajepour, Amir & Yu, Haisheng & Wang, Hong, 2019. "Research on the energy control of a dual-motor hybrid vehicle during engine start-stop process," Energy, Elsevier, vol. 166(C), pages 1181-1193.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Piotr Bera & Agata Drzewosz, 2024. "A Novel Formula for Calculating the Dynamic Torque of an Engine Based on Its Geometric Parameters and Static Measurements," Energies, MDPI, vol. 17(20), pages 1-15, October.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Du, Guodong & Zou, Yuan & Zhang, Xudong & Kong, Zehui & Wu, Jinlong & He, Dingbo, 2019. "Intelligent energy management for hybrid electric tracked vehicles using online reinforcement learning," Applied Energy, Elsevier, vol. 251(C), pages 1-1.
    2. Ritter, Andreas & Widmer, Fabio & Duhr, Pol & Onder, Christopher H., 2022. "Long-term stochastic model predictive control for the energy management of hybrid electric vehicles using Pontryagin’s minimum principle and scenario-based optimization," Applied Energy, Elsevier, vol. 322(C).
    3. Gao, Sichen & Zong, Yuhua & Ju, Fei & Wang, Qun & Huo, Weiwei & Wang, Liangmo & Wang, Tao, 2024. "Scenario-oriented adaptive ECMS using speed prediction for fuel cell vehicles in real-world driving," Energy, Elsevier, vol. 304(C).
    4. Du, Guodong & Zou, Yuan & Zhang, Xudong & Liu, Teng & Wu, Jinlong & He, Dingbo, 2020. "Deep reinforcement learning based energy management for a hybrid electric vehicle," Energy, Elsevier, vol. 201(C).
    5. Anselma, Pier Giuseppe, 2022. "Computationally efficient evaluation of fuel and electrical energy economy of plug-in hybrid electric vehicles with smooth driving constraints," Applied Energy, Elsevier, vol. 307(C).
    6. Guo, Hongqiang & Hou, Daizheng & Du, Shangye & Zhao, Ling & Wu, Jian & Yan, Ning, 2020. "A driving pattern recognition-based energy management for plug-in hybrid electric bus to counter the noise of stochastic vehicle mass," Energy, Elsevier, vol. 198(C).
    7. Ju, Fei & Zhuang, Weichao & Wang, Liangmo & Zhang, Zhe, 2020. "Comparison of four-wheel-drive hybrid powertrain configurations," Energy, Elsevier, vol. 209(C).
    8. Penghui Qiang & Peng Wu & Tao Pan & Huaiquan Zang, 2021. "Real-Time Approximate Equivalent Consumption Minimization Strategy Based on the Single-Shaft Parallel Hybrid Powertrain," Energies, MDPI, vol. 14(23), pages 1-22, November.
    9. Hou, Daizheng & Sun, Qun & Bao, Chunjiang & Cheng, Xingqun & Guo, Hongqiang & Zhao, Ying, 2019. "An all-in-one design method for plug-in hybrid electric buses considering uncertain factor of driving cycles," Applied Energy, Elsevier, vol. 253(C), pages 1-1.
    10. Chen, Jiaxin & Shu, Hong & Tang, Xiaolin & Liu, Teng & Wang, Weida, 2022. "Deep reinforcement learning-based multi-objective control of hybrid power system combined with road recognition under time-varying environment," Energy, Elsevier, vol. 239(PC).
    11. João Pedro F. Trovão & Minh Cao Ta, 2022. "Electric Vehicle Efficient Power and Propulsion Systems," Energies, MDPI, vol. 15(11), pages 1-4, May.
    12. Jure Soldo & Branimir Škugor & Joško Deur, 2021. "Online Synthesis of an Optimal Battery State-of-Charge Reference Trajectory for a Plug-in Hybrid Electric City Bus," Energies, MDPI, vol. 14(11), pages 1-24, May.
    13. Fengqi Zhang & Lihua Wang & Serdar Coskun & Hui Pang & Yahui Cui & Junqiang Xi, 2020. "Energy Management Strategies for Hybrid Electric Vehicles: Review, Classification, Comparison, and Outlook," Energies, MDPI, vol. 13(13), pages 1-35, June.
    14. Jure Soldo & Branimir Škugor & Joško Deur, 2019. "Synthesis of Optimal Battery State-of-Charge Trajectory for Blended Regime of Plug-in Hybrid Electric Vehicles in the Presence of Low-Emission Zones and Varying Road Grades," Energies, MDPI, vol. 12(22), pages 1-21, November.
    15. Yang Yang & Qiang He & Yongzheng Chen & Chunyun Fu, 2020. "Efficiency Optimization and Control Strategy of Regenerative Braking System with Dual Motor," Energies, MDPI, vol. 13(3), pages 1-21, February.
    16. Qi, Chunyang & Zhu, Yiwen & Song, Chuanxue & Yan, Guangfu & Xiao, Feng & Da wang, & Zhang, Xu & Cao, Jingwei & Song, Shixin, 2022. "Hierarchical reinforcement learning based energy management strategy for hybrid electric vehicle," Energy, Elsevier, vol. 238(PA).
    17. Lin, Xinyou & Huang, Hao & Xu, Xinhao & Xie, Liping, 2024. "Dynamic programming solutions extracted SOC-trajectory online learning generation algorithm based approximate global optimization control strategy for a fuel cell hybrid electric vehicle," Energy, Elsevier, vol. 295(C).
    18. Tri Cuong Do & Hoai Vu Anh Truong & Hoang Vu Dao & Cong Minh Ho & Xuan Dinh To & Tri Dung Dang & Kyoung Kwan Ahn, 2019. "Energy Management Strategy of a PEM Fuel Cell Excavator with a Supercapacitor/Battery Hybrid Power Source," Energies, MDPI, vol. 12(22), pages 1-24, November.
    19. Sun, Wenjing & Zou, Yuan & Zhang, Xudong & Guo, Ningyuan & Zhang, Bin & Du, Guodong, 2022. "High robustness energy management strategy of hybrid electric vehicle based on improved soft actor-critic deep reinforcement learning," Energy, Elsevier, vol. 258(C).
    20. Zhuang, Weichao & Li (Eben), Shengbo & Zhang, Xiaowu & Kum, Dongsuk & Song, Ziyou & Yin, Guodong & Ju, Fei, 2020. "A survey of powertrain configuration studies on hybrid electric vehicles," Applied Energy, Elsevier, vol. 262(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:15:y:2022:i:17:p:6214-:d:898379. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.