IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v237y2024ipbs0960148124016847.html
   My bibliography  Save this article

Comprehensive analysis of thermal performance and low-grade energy charging efficiency of pipe-embedded building envelopes enhanced with single-level tree-shaped fin structures

Author

Listed:
  • Yang, Yang
  • Chen, Sarula
  • Li, Shuying
  • Xiao, Xiuyi
  • Chen, Tianhang

Abstract

Pipe-embedded walls (CnPWs) are structural and energy composite building components that can resist external disturbances by forming stealth thermal shielding layers. To tackle the mismatch between the heat charging rate and heat diffusion rate during energy charging processes, as well as the unsatisfactory robustness of stealth thermal shielding layers, the single-level tree-shaped metal finnd pipe-embedded walls (TfPWs) are proposed. To verify the effectiveness of TfPWs and obtain dynamic performances, a simulation study is conducted on 8 risk variables in 4 pairs through the validated numerical model. Results showed that the improved design was effective in obtaining more robust thermal shielding layers in auxiliary energy supply mode, the effect gained prominence as both the injection temperature and pipe spacing were augmented. In room heat load reduction mode, favorable benefits arise when pipe spacing exceeds 400 mm. The maximum increase rate of total injected energy under different reduction ratios of external insulation layer was 11.83%–31.91 %, while the maximum extra total heat loss was 5.33 %. Secondly, the trunk fins and branch fins played different roles in minimizing the excessive heat accumulation surrounding pipes, and the vertical and horizontal sizes of heat accumulation region mainly increased with the increase in trunk fin size and branch fin size respectively. Meanwhile, the utilization efficiency of fin material was higher when trunk fin size was smaller, and parameter combinations with trunk fin size of 0.2b and branch fin size of 0.4a/0.6a could achieve a better balance between material input and performance increase. Thirdly, the improvement effect of single left branch fin schemes was close to that of double branch fin schemes and significantly better than that of single right branch fin schemes. It was recommended to use single left branch fin schemes with an inclination angle of 60°. Finally, even if the reduction ratio of external insulation layer in different cities increased to 80 %, the inside surface temperature of TfPWs was still greater than room air. Taking CnPWs with standard external insulation layer as references, the TfPWs applied in Harbin, Beijing, and Shanghai could achieve similar or better results even when the reduction ratio of external insulation layer increased to 60 %, while TfPWs applied in Guangzhou could exhibit better performance even when the reduction ratio of external insulation layer increases to 80 %.

Suggested Citation

  • Yang, Yang & Chen, Sarula & Li, Shuying & Xiao, Xiuyi & Chen, Tianhang, 2024. "Comprehensive analysis of thermal performance and low-grade energy charging efficiency of pipe-embedded building envelopes enhanced with single-level tree-shaped fin structures," Renewable Energy, Elsevier, vol. 237(PB).
  • Handle: RePEc:eee:renene:v:237:y:2024:i:pb:s0960148124016847
    DOI: 10.1016/j.renene.2024.121616
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148124016847
    Download Restriction: Full text for ScienceDirect subscribers only

    File URL: https://libkey.io/10.1016/j.renene.2024.121616?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Liu, Chang & Zhang, Zhigang, 2019. "Thermal response of wall implanted with heat pipes: Experimental analysis," Renewable Energy, Elsevier, vol. 143(C), pages 1687-1697.
    2. Zhang, Zhigang & Liu, Qiaoli & Yao, Wanxiang & Zhang, Wei & Cao, Jingfu & He, Haiyan, 2022. "Research on temperature distribution characteristics and energy saving potential of wall implanted with heat pipes in heating season," Renewable Energy, Elsevier, vol. 195(C), pages 1037-1049.
    3. Liu, Zu-An & Hou, Jiawen & Chen, Yu & Liu, Zaiqiang & Zhang, Tao & Zeng, Qian & Dewancker, Bart Julien & Meng, Xi & Jiang, Guanzhao, 2023. "Effectiveness assessment of different kinds/configurations of phase-change materials (PCM) for improving the thermal performance of lightweight building walls in summer and winter," Renewable Energy, Elsevier, vol. 202(C), pages 721-735.
    4. Chen, Liming & Zhao, Yuanyuan & Xie, Rui & Su, Bin & Liu, Yue & Renfei, Xv, 2023. "Embodied energy intensity of global high energy consumption industries: A case study of the construction industry," Energy, Elsevier, vol. 277(C).
    5. Yan, Tian & Sun, Zhongwei & Gao, Jiajia & Xu, Xinhua & Yu, Jinghua & Gang, Wenjie, 2020. "Simulation study of a pipe-encapsulated PCM wall system with self-activated heat removal by nocturnal sky radiation," Renewable Energy, Elsevier, vol. 146(C), pages 1451-1464.
    6. Huang, Xinyu & Li, Fangfei & Li, Yuanji & Meng, Xiangzhao & Yang, Xiaohu & Sundén, Bengt, 2023. "Optimization of melting performance of a heat storage tank under rotation conditions: Based on taguchi design and response surface method," Energy, Elsevier, vol. 271(C).
    7. Ba, Jin & Wei, Wu & Zhao, Lun & Gang, Xiao & Song, Zhendong & Xia, Shangfei, 2024. "Numerical simulation study of the injection characteristics affecting trans-/supercritical sprays based on orthogonal experiment design," Energy, Elsevier, vol. 293(C).
    8. Gwerder, M. & Tödtli, J. & Lehmann, B. & Dorer, V. & Güntensperger, W. & Renggli, F., 2009. "Control of thermally activated building systems (TABS) in intermittent operation with pulse width modulation," Applied Energy, Elsevier, vol. 86(9), pages 1606-1616, September.
    9. Yan, Tian & Zhou, Xuan & Xu, Xinhua & Yu, Jinghua & Li, Xianting, 2022. "Parametric analysis on performances of the pipe-encapsulated PCM (PenPCM) wall system coupled with gravity heat-pipe and nocturnal radiant cooler," Renewable Energy, Elsevier, vol. 196(C), pages 161-180.
    10. Yang, Yang & Chen, Sarula, 2022. "Thermal insulation solutions for opaque envelope of low-energy buildings: A systematic review of methods and applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 167(C).
    11. Lyu, Weihua & Li, Xianting & Yan, Shuai & Jiang, Sihang, 2020. "Utilizing shallow geothermal energy to develop an energy efficient HVAC system," Renewable Energy, Elsevier, vol. 147(P1), pages 672-682.
    12. Li, Ao & Duan, Shuangping & Han, Rubing & Wang, Chaoyu, 2022. "Investigation on the dynamic thermal storage/release of the integrated PCM solar wall embedded with an evaporator," Renewable Energy, Elsevier, vol. 200(C), pages 1506-1516.
    13. Yu, Cairui & Shen, Dongmei & He, Wei & Hu, Zhongting & Zhang, Sheng & Chu, Wenfeng, 2021. "Parametric analysis of the phase change material wall combining with micro-channel heat pipe and sky radiative cooling technology," Renewable Energy, Elsevier, vol. 178(C), pages 1057-1069.
    14. Chen, Zhaoxin & Li, Jiaxuan & Tang, Guoqiang & Zhang, Jiahao & Zhang, Donghai & Gao, Penghui, 2024. "High-efficiency heating and cooling technology with embedded pipes in buildings and underground structures: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 192(C).
    15. Schmelas, Martin & Feldmann, Thomas & Bollin, Elmar, 2017. "Savings through the use of adaptive predictive control of thermo-active building systems (TABS): A case study," Applied Energy, Elsevier, vol. 199(C), pages 294-309.
    16. Niu, Fuxin & Yu, Yuebin, 2016. "Location and optimization analysis of capillary tube network embedded in active tuning building wall," Energy, Elsevier, vol. 97(C), pages 36-45.
    17. Yan, Tian & Xu, Xinhua & Gao, Jiajia & Luo, Yongqiang & Yu, Jinghua, 2020. "Performance evaluation of a PCM-embedded wall integrated with a nocturnal sky radiator," Energy, Elsevier, vol. 210(C).
    18. Kaushik Biswas & Som Shrestha & Diana Hun & Jerald Atchley, 2019. "Thermally Anisotropic Composites for Improving the Energy Efficiency of Building Envelopes," Energies, MDPI, vol. 12(19), pages 1-15, October.
    19. Wang, Dan-Yi & Wang, Xueqing & Ding, Ru-Xi, 2022. "Welfare maximization with the least subsidy: Pricing model for surface water loop heat pump PPP projects considering occupancy rate growth and coefficient of performance," Renewable Energy, Elsevier, vol. 194(C), pages 1131-1141.
    20. Yu, Jinghua & Leng, Kangxin & Ye, Hong & Xu, Xinhua & Luo, Yongqiang & Wang, Jinbo & Yang, Xie & Yang, Qingchen & Gang, Wenjie, 2020. "Study on thermal insulation characteristics and optimized design of pipe-embedded ventilation roof with outer-layer shape-stabilized PCM in different climate zones," Renewable Energy, Elsevier, vol. 147(P1), pages 1609-1622.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zhang, Guangpeng & Wu, Huijun & Liu, Jia & Liu, Yanchen & Ding, Yujie & Huang, Huakun, 2024. "A review on switchable building envelopes for low-energy buildings," Renewable and Sustainable Energy Reviews, Elsevier, vol. 202(C).
    2. Yang, Yang & Chen, Sarula, 2022. "Thermal insulation solutions for opaque envelope of low-energy buildings: A systematic review of methods and applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 167(C).
    3. Zhang, Chunxiao & Chen, Lei & Zhou, Ziqi & Wang, Zhanwei & Wang, Lin & Zhang, Yingbo, 2023. "Cooling performance of all-orientated building facades integrated with photovoltaic-sky radiative cooling system in summer," Renewable Energy, Elsevier, vol. 217(C).
    4. Chen, Zhaoxin & Li, Jiaxuan & Tang, Guoqiang & Zhang, Jiahao & Zhang, Donghai & Gao, Penghui, 2024. "High-efficiency heating and cooling technology with embedded pipes in buildings and underground structures: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 192(C).
    5. Yan, Tian & Zhou, Xuan & Xu, Xinhua & Yu, Jinghua & Li, Xianting, 2022. "Parametric analysis on performances of the pipe-encapsulated PCM (PenPCM) wall system coupled with gravity heat-pipe and nocturnal radiant cooler," Renewable Energy, Elsevier, vol. 196(C), pages 161-180.
    6. Huang, Xinyu & Li, Fangfei & Liu, Zhengguang & Gao, Xinyu & Yang, Xiaohu & Yan, Jinyue, 2023. "Design and optimization of a novel phase change photovoltaic thermal utilization structure for building envelope," Renewable Energy, Elsevier, vol. 218(C).
    7. Jia, Hongyuan & Pang, Xiufeng & Haves, Philip, 2018. "Experimentally-determined characteristics of radiant systems for office buildings," Applied Energy, Elsevier, vol. 221(C), pages 41-54.
    8. Wang, Yabo & Huang, Xinyu & Shu, Gao & Li, Xueqiang & Yang, Xiaohu, 2024. "Influence of microgravity on melting performance of a phase-change heat storage tank," Energy, Elsevier, vol. 289(C).
    9. Yang, Yang & Chen, Sarula & Zhang, Jiqiang, 2023. "A comprehensive study on transient thermal behaviors and performances of the modular pipe-embedded energy wall system under intermittent operation conditions," Energy, Elsevier, vol. 280(C).
    10. Zhang, Wanshi & Wu, Yunlei & Li, Xiuwei & Cheng, Feng & Zhang, Xiaosong, 2021. "Performance investigation of the wood-based heat localization regenerator in liquid desiccant cooling system," Renewable Energy, Elsevier, vol. 179(C), pages 133-149.
    11. Duan, Xiaojian & Shen, Chao & Liu, Dingming & Wu, Yupeng, 2023. "The performance analysis of a photo/thermal catalytic Trombe wall with energy generation," Renewable Energy, Elsevier, vol. 218(C).
    12. Liu, Long & Wang, Mingqing & Chen, Yu, 2019. "A practical research on capillaries used as a front-end heat exchanger of seawater-source heat pump," Energy, Elsevier, vol. 171(C), pages 170-179.
    13. Yan, Peiliang & Fan, Weijun & Han, Yu & Ding, Hongbing & Wen, Chuang & Elbarghthi, Anas F.A. & Yang, Yan, 2023. "Leaf-vein bionic fin configurations for enhanced thermal energy storage performance of phase change materials in smart heating and cooling systems," Applied Energy, Elsevier, vol. 346(C).
    14. Marek Walacik & Aneta Chmielewska, 2024. "Energy Performance in Residential Buildings as a Property Market Efficiency Driver," Energies, MDPI, vol. 17(10), pages 1-18, May.
    15. Ma, Peizheng & Wang, Lin-Shu & Guo, Nianhua, 2015. "Maximum window-to-wall ratio of a thermally autonomous building as a function of envelope U-value and ambient temperature amplitude," Applied Energy, Elsevier, vol. 146(C), pages 84-91.
    16. Gao, Jiajia & Li, Anbang & Xu, Xinhua & Gang, Wenjie & Yan, Tian, 2018. "Ground heat exchangers: Applications, technology integration and potentials for zero energy buildings," Renewable Energy, Elsevier, vol. 128(PA), pages 337-349.
    17. Chen, Yuxin & Sun, Yongjun & Yang, Jinling & Tan, Jiaqi & Liu, Yang & Gao, Dian-ce, 2024. "Demand response with PCM-based pipe-embedded wall in commercial buildings: Combined passive and active energy storage in envelopes," Energy, Elsevier, vol. 308(C).
    18. Zhao, Yaxin & Wang, Huan & Li, Xianting, 2025. "Field test on the thermal performance of double-layer pipe-embedded wall heating system with shallow geothermal energy and air source heat pump," Applied Energy, Elsevier, vol. 377(PD).
    19. Lehmann, B. & Dorer, V. & Gwerder, M. & Renggli, F. & Tödtli, J., 2011. "Thermally activated building systems (TABS): Energy efficiency as a function of control strategy, hydronic circuit topology and (cold) generation system," Applied Energy, Elsevier, vol. 88(1), pages 180-191, January.
    20. Suola Shao & Chengcheng Xu, 2024. "Performance Analysis of Novel Direct-Condensation Heating Panels Integrated with Air Source Heat Pump System on Thermal Economy and System Efficiencies," Energies, MDPI, vol. 17(18), pages 1-22, September.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:237:y:2024:i:pb:s0960148124016847. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.