IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v211y2023icp269-278.html
   My bibliography  Save this article

An experimental investigation and process optimization of the oxidative liquefaction process as the recycling method of the end-of-life wind turbine blades

Author

Listed:
  • Mumtaz, Hamza
  • Sobek, Szymon
  • Sajdak, Marcin
  • Muzyka, Roksana
  • Werle, Sebastian

Abstract

The article contextualizes and expands upon research related to oxidative liquefaction of wind turbine blades for resin degradation and glass fiber recovery, presented at the 17th SDEWES conference series on Sustainable Development of Energy, Water and Environmental Systems 2022. The effect of five different parameters, including reaction temperature, residence time, pressure, waste-to-liquid ratio, and oxidant concentration, on resin degradation, has been studied in detail. Experiments were performed in the temperature range of 250 °C–350 °C with a residence time of 30–90 min, at a pressure of 20–40 bar, a waste-to-liquid ratio of 5–25%, and oxidant concentrations of 15–45% by weight. The maximum resin degradation yield achieved was in the range of 95–100% against the different combinations of tested parameters, and its minimum value was 43%, but detailed analysis revealed that the waste-to-liquid ratio is the key parameter affecting resin degradation yield. In addition, energy consumption is one of the important parameters determining the economic feasibility of the process, so a detailed optimization of the experimental plan based on maximum resin degradation and energy consumption has also been performed to identify the most suitable conditions that support the implication of the process at a larger scale.

Suggested Citation

  • Mumtaz, Hamza & Sobek, Szymon & Sajdak, Marcin & Muzyka, Roksana & Werle, Sebastian, 2023. "An experimental investigation and process optimization of the oxidative liquefaction process as the recycling method of the end-of-life wind turbine blades," Renewable Energy, Elsevier, vol. 211(C), pages 269-278.
    • Handle: RePEc:eee:renene:v:211:y:2023:i:c:p:269-278
    DOI: 10.1016/j.renene.2023.04.120
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148123005864
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2023.04.120?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Wilk, Małgorzata & Śliz, Maciej & Lubieniecki, Bogusław, 2021. "Hydrothermal co-carbonization of sewage sludge and fuel additives: Combustion performance of hydrochar," Renewable Energy, Elsevier, vol. 178(C), pages 1046-1056.
    2. Majewski, Peter & Florin, Nick & Jit, Joytishna & Stewart, Rodney A., 2022. "End-of-life policy considerations for wind turbine blades," Renewable and Sustainable Energy Reviews, Elsevier, vol. 164(C).
    3. Sarrion, A. & Ipiales, R.P. & de la Rubia, M.A. & Mohedano, A.F. & Diaz, E., 2023. "Chicken meat and bone meal valorization by hydrothermal treatment and anaerobic digestion: Biofuel production and nutrient recovery," Renewable Energy, Elsevier, vol. 204(C), pages 652-660.
    4. Rusu, Eugen, 2019. "A 30-year projection of the future wind energy resources in the coastal environment of the Black Sea," Renewable Energy, Elsevier, vol. 139(C), pages 228-234.
    5. Jensen, J.P. & Skelton, K., 2018. "Wind turbine blade recycling: Experiences, challenges and possibilities in a circular economy," Renewable and Sustainable Energy Reviews, Elsevier, vol. 97(C), pages 165-176.
    6. Zhong, Chongli & Wei, Xiaomin, 2004. "A comparative experimental study on the liquefaction of wood," Energy, Elsevier, vol. 29(11), pages 1731-1741.
    7. Wądrzyk, Mariusz & Grzywacz, Przemysław & Janus, Rafał & Michalik, Marek, 2021. "A two-stage processing of cherry pomace via hydrothermal treatment followed by biochar gasification," Renewable Energy, Elsevier, vol. 179(C), pages 248-261.
    8. Genel, Salih & Durak, Halil & Durak, Emre Demirer & Güneş, Hasret & Genel, Yaşar, 2023. "Hydrothermal liquefaction of biomass with molybdenum, aluminum, cobalt metal powder catalysts and evaluation of wastewater by fungus cultivation," Renewable Energy, Elsevier, vol. 203(C), pages 20-32.
    9. Sikkema, Richard & Proskurina, Svetlana & Banja, Manjola & Vakkilainen, Esa, 2021. "How can solid biomass contribute to the EU’s renewable energy targets in 2020, 2030 and what are the GHG drivers and safeguards in energy- and forestry sectors?," Renewable Energy, Elsevier, vol. 165(P1), pages 758-772.
    10. Couto, Eduardo Aguiar & Pinto, Filomena & Varela, Francisco & Reis, Alberto & Costa, Paula & Calijuri, Maria Lúcia, 2018. "Hydrothermal liquefaction of biomass produced from domestic sewage treatment in high-rate ponds," Renewable Energy, Elsevier, vol. 118(C), pages 644-653.
    11. Mu, Kai & Zhang, Qiang & Luo, Guangqian & Han, Jun & Qin, Linbo & Zhao, Bo & Chen, Wangsheng & Yi, Linlin, 2022. "Role of iron conditioners on organics evolution in overall process of sludge hydrothermal carbonization followed by pyrolysis," Renewable Energy, Elsevier, vol. 198(C), pages 169-175.
    12. Murray, Robynne E. & Beach, Ryan & Barnes, David & Snowberg, David & Berry, Derek & Rooney, Samantha & Jenks, Mike & Gage, Bill & Boro, Troy & Wallen, Sara & Hughes, Scott, 2021. "Structural validation of a thermoplastic composite wind turbine blade with comparison to a thermoset composite blade," Renewable Energy, Elsevier, vol. 164(C), pages 1100-1107.
    13. Qu, Yixin & Wei, Xiaomin & Zhong, Chongli, 2003. "Experimental study on the direct liquefaction of Cunninghamia lanceolata in water," Energy, Elsevier, vol. 28(7), pages 597-606.
    14. Zhao, Kaige & Li, Wanqing & Yu, Yingying & Chen, Guanyi & Yan, Beibei & Cheng, Zhanjun & Zhao, Hai & Fang, Yang, 2023. "Speciation and transformation of nitrogen in the hydrothermal liquefaction of wastewater-treated duckweed for the bio-oil production," Renewable Energy, Elsevier, vol. 204(C), pages 661-670.
    15. Wu, Yujian & Wang, Haoyu & Li, Haoyang & Han, Xue & Zhang, Mingyuan & Sun, Yan & Fan, Xudong & Tu, Ren & Zeng, Yimin & Xu, Chunbao Charles & Xu, Xiwei, 2022. "Applications of catalysts in thermochemical conversion of biomass (pyrolysis, hydrothermal liquefaction and gasification): A critical review," Renewable Energy, Elsevier, vol. 196(C), pages 462-481.
    16. Sun, Peiqin & Heng, Mingxing & Sun, Shaohui & Chen, Junwu, 2010. "Direct liquefaction of paulownia in hot compressed water: Influence of catalysts," Energy, Elsevier, vol. 35(12), pages 5421-5429.
    17. Zhou, Ying & Shao, Yuchao & Zhou, Dan & Meng, Yanjun & Shen, Dongsheng & Long, Yuyang, 2021. "Effect of mechano-chemical pretreatment on valorizing plant waste for 5-hydroxymethylfurfural under microwave hydrothermal treatment," Renewable Energy, Elsevier, vol. 180(C), pages 536-543.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Mumtaz, Hamza & Sobek, Szymon & Sajdak, Marcin & Muzyka, Roksana & Drewniak, Sabina & Werle, Sebastian, 2023. "Oxidative liquefaction as an alternative method of recycling and the pyrolysis kinetics of wind turbine blades," Energy, Elsevier, vol. 278(PB).
    2. Hamza Mumtaz & Sebastian Werle & Roksana Muzyka & Szymon Sobek & Marcin Sajdak, 2024. "Oxidative Liquefaction, an Approach for Complex Plastic Waste Stream Conversion into Valuable Oxygenated Chemicals," Energies, MDPI, vol. 17(5), pages 1-14, February.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Mumtaz, Hamza & Sobek, Szymon & Sajdak, Marcin & Muzyka, Roksana & Drewniak, Sabina & Werle, Sebastian, 2023. "Oxidative liquefaction as an alternative method of recycling and the pyrolysis kinetics of wind turbine blades," Energy, Elsevier, vol. 278(PB).
    2. Brand, Steffen & Hardi, Flabianus & Kim, Jaehoon & Suh, Dong Jin, 2014. "Effect of heating rate on biomass liquefaction: Differences between subcritical water and supercritical ethanol," Energy, Elsevier, vol. 68(C), pages 420-427.
    3. Zhu, Zhe & Toor, Saqib Sohail & Rosendahl, Lasse & Yu, Donghong & Chen, Guanyi, 2015. "Influence of alkali catalyst on product yield and properties via hydrothermal liquefaction of barley straw," Energy, Elsevier, vol. 80(C), pages 284-292.
    4. Dimitriadis, Athanasios & Bezergianni, Stella, 2017. "Hydrothermal liquefaction of various biomass and waste feedstocks for biocrude production: A state of the art review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P1), pages 113-125.
    5. Zhang, Bo & Chen, Jixiang & He, Zhixia & Chen, Haitao & Kandasamy, Sabariswaran, 2019. "Hydrothermal liquefaction of fresh lemon-peel: Parameter optimisation and product chemistry," Renewable Energy, Elsevier, vol. 143(C), pages 512-519.
    6. Minkang Liu & Yimin Zeng, 2023. "Key Processing Factors in Hydrothermal Liquefaction and Their Impacts on Corrosion of Reactor Alloys," Sustainability, MDPI, vol. 15(12), pages 1-18, June.
    7. Nizamuddin, Sabzoi & Baloch, Humair Ahmed & Griffin, G.J. & Mubarak, N.M. & Bhutto, Abdul Waheed & Abro, Rashid & Mazari, Shaukat Ali & Ali, Brahim Si, 2017. "An overview of effect of process parameters on hydrothermal carbonization of biomass," Renewable and Sustainable Energy Reviews, Elsevier, vol. 73(C), pages 1289-1299.
    8. Wądrzyk, Mariusz & Korzeniowski, Łukasz & Plata, Marek & Janus, Rafał & Lewandowski, Marek & Michalik, Marek & Magdziarz, Aneta, 2023. "Pyrolysis of hydrochars obtained from blackcurrant pomace in single and binary solvent systems," Renewable Energy, Elsevier, vol. 214(C), pages 383-394.
    9. Brand, Steffen & Susanti, Ratna Frida & Kim, Seok Ki & Lee, Hong-shik & Kim, Jaehoon & Sang, Byung-In, 2013. "Supercritical ethanol as an enhanced medium for lignocellulosic biomass liquefaction: Influence of physical process parameters," Energy, Elsevier, vol. 59(C), pages 173-182.
    10. Yuan, X.Z. & Li, H. & Zeng, G.M. & Tong, J.Y. & Xie, W., 2007. "Sub- and supercritical liquefaction of rice straw in the presence of ethanol–water and 2-propanol–water mixture," Energy, Elsevier, vol. 32(11), pages 2081-2088.
    11. Czerwińska, Klaudia & Śliz, Maciej & Wilk, Małgorzata, 2022. "Hydrothermal carbonization process: Fundamentals, main parameter characteristics and possible applications including an effective method of SARS-CoV-2 mitigation in sewage sludge. A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 154(C).
    12. Qian, Yejian & Zuo, Chengji & Tan, Jian & He, Jianhui, 2007. "Structural analysis of bio-oils from sub-and supercritical water liquefaction of woody biomass," Energy, Elsevier, vol. 32(3), pages 196-202.
    13. Chen, Wei-Hsin & Lin, Yu-Ying & Liu, Hsuan-Cheng & Baroutian, Saeid, 2020. "Optimization of food waste hydrothermal liquefaction by a two-step process in association with a double analysis," Energy, Elsevier, vol. 199(C).
    14. Younas, Rafia & Hao, Shilai & Zhang, Liwu & Zhang, Shicheng, 2017. "Hydrothermal liquefaction of rice straw with NiO nanocatalyst for bio-oil production," Renewable Energy, Elsevier, vol. 113(C), pages 532-545.
    15. Kaur, Ravneet & Gera, Poonam & Jha, Mithilesh Kumar & Bhaskar, Thallada, 2019. "Reaction parameters effect on hydrothermal liquefaction of castor (Ricinus Communis) residue for energy and valuable hydrocarbons recovery," Renewable Energy, Elsevier, vol. 141(C), pages 1026-1041.
    16. Zhang, Linghong & Champagne, Pascale & (Charles) Xu, Chunbao, 2011. "Bio-crude production from secondary pulp/paper-mill sludge and waste newspaper via co-liquefaction in hot-compressed water," Energy, Elsevier, vol. 36(4), pages 2142-2150.
    17. Sun, Peiqin & Heng, Mingxing & Sun, Shaohui & Chen, Junwu, 2010. "Direct liquefaction of paulownia in hot compressed water: Influence of catalysts," Energy, Elsevier, vol. 35(12), pages 5421-5429.
    18. Taghipour, Alireza & Ramirez, Jerome A. & Brown, Richard J. & Rainey, Thomas J., 2019. "A review of fractional distillation to improve hydrothermal liquefaction biocrude characteristics; future outlook and prospects," Renewable and Sustainable Energy Reviews, Elsevier, vol. 115(C).
    19. Ankit Mathanker & Snehlata Das & Deepak Pudasainee & Monir Khan & Amit Kumar & Rajender Gupta, 2021. "A Review of Hydrothermal Liquefaction of Biomass for Biofuels Production with a Special Focus on the Effect of Process Parameters, Co-Solvents, and Extraction Solvents," Energies, MDPI, vol. 14(16), pages 1-60, August.
    20. Déniel, Maxime & Haarlemmer, Geert & Roubaud, Anne & Weiss-Hortala, Elsa & Fages, Jacques, 2016. "Energy valorisation of food processing residues and model compounds by hydrothermal liquefaction," Renewable and Sustainable Energy Reviews, Elsevier, vol. 54(C), pages 1632-1652.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:211:y:2023:i:c:p:269-278. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.