IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v126y2018icp281-295.html
   My bibliography  Save this article

Numerical and empirical evaluation of a novel building integrated collector storage solar water heater

Author

Listed:
  • Garnier, Celine
  • Muneer, Tariq
  • Currie, John

Abstract

Integrated collector storage is a long established simple low cost solar water heater configuration combining the solar collector with a storage tank into a single unit. Previous studies have shown the potential of integrated collector storage solar water heaters to significantly reduce domestic energy requirements for water heating, however challenges still remain to integrate them in roof/façades and ensure appropriate domestic hot water demand. In this article, a novel integrated collector storage solar water heaters is being investigated. The configuration and geometry proposed incorporates an embedded heating element to provide a self-contained domestic hot water system and consider roof integration restriction allowing the unit to be embedded within a structural insulated roofing panel system. The proposed system also utilizes an inlet diffuser designed to reduce the disruption to the stratification within the storage during and following draw-off. This article presents a Computational Fluid Dynamic analysis of internal flows and heat transfer regimes within this new collector configuration and compares its performance against previous developed prototypes using empirical testing. The increased aspect ratio of the new design was shown to significantly alter the heating and cooling characteristics of the collector, both gaining and loosing heat at a greater rate than the original prototype. The computational analysis showed that the collector charges effectively with some stratification. Higher draw-off rates however resulted in higher bulk water outlet temperatures, providing better energy delivery efficiency. The inlet diffuser was also shown to improve the thermal efficiency of the unit overall. The empirical testing shows the improvement in performance of this novel integrated collector storage solar water heaters against previous developed prototypes. The study highlights the need to review the effect of draw-off regime upon the performance of such systems in order to identify optimal regime and control strategy.

Suggested Citation

  • Garnier, Celine & Muneer, Tariq & Currie, John, 2018. "Numerical and empirical evaluation of a novel building integrated collector storage solar water heater," Renewable Energy, Elsevier, vol. 126(C), pages 281-295.
    • Handle: RePEc:eee:renene:v:126:y:2018:i:c:p:281-295
    DOI: 10.1016/j.renene.2018.03.041
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148118303525
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2018.03.041?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Chung, Jae Dong & Cho, Sung Hwan & Tae, Choon Seob & Yoo, Hoseon, 2008. "The effect of diffuser configuration on thermal stratification in a rectangular storage tank," Renewable Energy, Elsevier, vol. 33(10), pages 2236-2245.
    2. Cruz, José M. S. & Hammond, Geoffrey P. & Reis, Albino J. P. S., 2002. "Thermal performance of a trapezoidal-shaped solar collector/energy store," Applied Energy, Elsevier, vol. 73(2), pages 195-212, October.
    3. Borello, Domenico & Corsini, Alessandro & Delibra, Giovanni & Evangelisti, Sara & Micangeli, Andrea, 2012. "Experimental and computational investigation of a new solar integrated collector storage system," Applied Energy, Elsevier, vol. 97(C), pages 982-989.
    4. Prakash, J. & Kaushik, S.C. & Kumar, R. & Garg, H.P., 1994. "Performance prediction for a triangular built-in-storage-type solar water heater with transparent insulation," Energy, Elsevier, vol. 19(8), pages 869-877.
    5. Garnier, C. & Currie, J. & Muneer, T., 2009. "Integrated collector storage solar water heater: Temperature stratification," Applied Energy, Elsevier, vol. 86(9), pages 1465-1469, September.
    6. Smyth, M. & Eames, P. C. & Norton, B., 2001. "Evaluation of a freeze resistant integrated collector/storage solar water-heater for northern Europe," Applied Energy, Elsevier, vol. 68(3), pages 265-274, March.
    7. Hegazy, Adel A. & Diab, M. R., 2002. "Performance of an improved design for storage-type domestic electrical water-heaters," Applied Energy, Elsevier, vol. 71(4), pages 287-306, April.
    8. Singh, Ramkishore & Lazarus, Ian J. & Souliotis, Manolis, 2016. "Recent developments in integrated collector storage (ICS) solar water heaters: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 54(C), pages 270-298.
    9. Ghaddar, N.K., 1994. "Stratified storage tank influence on performance of solar water heating system tested in Beirut," Renewable Energy, Elsevier, vol. 4(8), pages 911-925.
    10. Ingram, D.M. & Causon, D.M. & Mingham, C.G., 2003. "Developments in Cartesian cut cell methods," Mathematics and Computers in Simulation (MATCOM), Elsevier, vol. 61(3), pages 561-572.
    11. Buker, Mahmut Sami & Riffat, Saffa B., 2015. "Building integrated solar thermal collectors – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 51(C), pages 327-346.
    12. Kalogirou, Soteris A., 1999. "Performance enhancement of an integrated collector storage hot water system," Renewable Energy, Elsevier, vol. 16(1), pages 652-655.
    13. El-Sebaii, A.A., 2005. "Thermal performance of a shallow solar-pond integrated with a baffle plate," Applied Energy, Elsevier, vol. 81(1), pages 33-53, May.
    14. Henderson, D. & Junaidi, H. & Muneer, T. & Grassie, T. & Currie, J., 2007. "Experimental and CFD investigation of an ICSSWH at various inclinations," Renewable and Sustainable Energy Reviews, Elsevier, vol. 11(6), pages 1087-1116, August.
    15. Hegazy, Adel A., 2007. "Effect of inlet design on the performance of storage-type domestic electrical water heaters," Applied Energy, Elsevier, vol. 84(12), pages 1338-1355, December.
    16. Zurigat, Y. H. & Ghajar, A. J. & Moretti, P. M., 1988. "Stratified thermal storage tank inlet mixing characterization," Applied Energy, Elsevier, vol. 30(2), pages 99-111.
    17. Kalogirou, Soteris, 1997. "Design, construction, performance evaluation and economic analysis of an integrated collector storage system," Renewable Energy, Elsevier, vol. 12(2), pages 179-192.
    18. Arnaoutakis, Nektarios & Souliotis, Manolis & Papaefthimiou, Spiros, 2017. "Comparative experimental Life Cycle Assessment of two commercial solar thermal devices for domestic applications," Renewable Energy, Elsevier, vol. 111(C), pages 187-200.
    19. Smyth, M. & Eames, P.C. & Norton, B., 2006. "Integrated collector storage solar water heaters," Renewable and Sustainable Energy Reviews, Elsevier, vol. 10(6), pages 503-538, December.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Gao, Datong & Zhong, Shuai & Ren, Xiao & Kwan, Trevor Hocksun & Pei, Gang, 2022. "The energetic, exergetic, and mechanical comparison of two structurally optimized non-concentrating solar collectors for intermediate temperature applications," Renewable Energy, Elsevier, vol. 184(C), pages 881-898.
    2. Hu, Mingke & Zhao, Bin & Ao, Xianze & Feng, Junsheng & Cao, Jingyu & Su, Yuehong & Pei, Gang, 2019. "Experimental study on a hybrid photo-thermal and radiative cooling collector using black acrylic paint as the panel coating," Renewable Energy, Elsevier, vol. 139(C), pages 1217-1226.
    3. Gao, Datong & Wu, Lijun & Hao, Yong & Pei, Gang, 2022. "Ultrahigh-efficiency solar energy harvesting via a non-concentrating evacuated aerogel flat-plate solar collector," Renewable Energy, Elsevier, vol. 196(C), pages 1455-1468.
    4. Farzan, Hadi & Ameri, Mehran & Mahmoudi, Mojtaba, 2023. "Thermal assessment of a new planar thermal diode integrated collector storage solar water heater in different partial vacuums: An experimental study," Renewable Energy, Elsevier, vol. 208(C), pages 119-129.
    5. Xie, Yujie & Simbamba, Mzee Mohamed & Zhou, Jinzhi & Jiang, Fujian & Cao, Xiaoling & Sun, Liangliang & Yuan, Yanping, 2022. "Numerical investigation of the effect factors on the performance of a novel PV integrated collector storage solar water heater," Renewable Energy, Elsevier, vol. 195(C), pages 1354-1367.
    6. Vassiliades, C. & Agathokleous, R. & Barone, G. & Forzano, C. & Giuzio, G.F. & Palombo, A. & Buonomano, A. & Kalogirou, S., 2022. "Building integration of active solar energy systems: A review of geometrical and architectural characteristics," Renewable and Sustainable Energy Reviews, Elsevier, vol. 164(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ruth M. Saint & Céline Garnier & Francesco Pomponi & John Currie, 2018. "Thermal Performance through Heat Retention in Integrated Collector-Storage Solar Water Heaters: A Review," Energies, MDPI, vol. 11(6), pages 1-26, June.
    2. Barone, G. & Buonomano, A. & Palmieri, V. & Palombo, A., 2022. "A prototypal high-vacuum integrated collector storage solar water heater: Experimentation, design, and optimization through a new in-house 3D dynamic simulation model," Energy, Elsevier, vol. 238(PC).
    3. Singh, Ramkishore & Lazarus, Ian J. & Souliotis, Manolis, 2016. "Recent developments in integrated collector storage (ICS) solar water heaters: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 54(C), pages 270-298.
    4. Devanarayanan, K. & Kalidasa Murugavel, K., 2014. "Integrated collector storage solar water heater with compound parabolic concentrator – development and progress," Renewable and Sustainable Energy Reviews, Elsevier, vol. 39(C), pages 51-64.
    5. Smyth, Mervyn & Barone, Giovanni & Buonomano, Annamaria & Forzano, Cesare & Giuzio, Giovanni Francesco & Palombo, Adolfo & Mondol, Jayanta & Muhumuza, Ronald & Pugsley, Adrian & Zacharopoulos, Aggelos, 2020. "Modelling and experimental evaluation of an innovative Integrated Collector Storage Solar Water Heating (ICSSWH) prototype," Renewable Energy, Elsevier, vol. 157(C), pages 974-986.
    6. Harmim, A. & Boukar, M. & Amar, M. & Haida, Aek, 2019. "Simulation and experimentation of an integrated collector storage solar water heater designed for integration into building facade," Energy, Elsevier, vol. 166(C), pages 59-71.
    7. Souliotis, Manolis & Papaefthimiou, Spiros & Caouris, Yiannis G. & Zacharopoulos, Aggelos & Quinlan, Patrick & Smyth, Mervyn, 2017. "Integrated collector storage solar water heater under partial vacuum," Energy, Elsevier, vol. 139(C), pages 991-1002.
    8. Xie, Yujie & Simbamba, Mzee Mohamed & Zhou, Jinzhi & Jiang, Fujian & Cao, Xiaoling & Sun, Liangliang & Yuan, Yanping, 2022. "Numerical investigation of the effect factors on the performance of a novel PV integrated collector storage solar water heater," Renewable Energy, Elsevier, vol. 195(C), pages 1354-1367.
    9. Souliotis, M. & Chemisana, D. & Caouris, Y.G. & Tripanagnostopoulos, Y., 2013. "Experimental study of integrated collector storage solar water heaters," Renewable Energy, Elsevier, vol. 50(C), pages 1083-1094.
    10. Atikol, U. & Aldabbagh, L.B.Y., 2015. "The impact of two-stage discharging on the exergoeconomic performance of a storage-type domestic water-heater," Energy, Elsevier, vol. 83(C), pages 379-386.
    11. Smyth, M. & Eames, P.C. & Norton, B., 2006. "Integrated collector storage solar water heaters," Renewable and Sustainable Energy Reviews, Elsevier, vol. 10(6), pages 503-538, December.
    12. Li, Gang, 2016. "Sensible heat thermal storage energy and exergy performance evaluations," Renewable and Sustainable Energy Reviews, Elsevier, vol. 53(C), pages 897-923.
    13. Souliotis, M. & Kalogirou, S. & Tripanagnostopoulos, Y., 2009. "Modelling of an ICS solar water heater using artificial neural networks and TRNSYS," Renewable Energy, Elsevier, vol. 34(5), pages 1333-1339.
    14. Azzolin, Marco & Mariani, Andrea & Moro, Lorenzo & Tolotto, Andrea & Toninelli, Paolo & Del Col, Davide, 2018. "Mathematical model of a thermosyphon integrated storage solar collector," Renewable Energy, Elsevier, vol. 128(PA), pages 400-415.
    15. Hegazy, Adel A., 2007. "Effect of inlet design on the performance of storage-type domestic electrical water heaters," Applied Energy, Elsevier, vol. 84(12), pages 1338-1355, December.
    16. Ge, T.S. & Wang, R.Z. & Xu, Z.Y. & Pan, Q.W. & Du, S. & Chen, X.M. & Ma, T. & Wu, X.N. & Sun, X.L. & Chen, J.F., 2018. "Solar heating and cooling: Present and future development," Renewable Energy, Elsevier, vol. 126(C), pages 1126-1140.
    17. Smyth, M. & Quinlan, P. & Mondol, J.D. & Zacharopoulos, A. & McLarnon, D. & Pugsley, A., 2017. "The evolutionary thermal performance and development of a novel thermal diode pre-heat solar water heater under simulated heat flux conditions," Renewable Energy, Elsevier, vol. 113(C), pages 1160-1167.
    18. Yassen, Tadahmun A. & Mokhlif, Nassir D. & Eleiwi, Muhammad Asmail, 2019. "Performance investigation of an integrated solar water heater with corrugated absorber surface for domestic use," Renewable Energy, Elsevier, vol. 138(C), pages 852-860.
    19. Smyth, M. & Quinlan, P. & Mondol, J.D. & Zacharopoulos, A. & McLarnon, D. & Pugsley, A., 2018. "The experimental evaluation and improvements of a novel thermal diode pre-heat solar water heater under simulated solar conditions," Renewable Energy, Elsevier, vol. 121(C), pages 116-122.
    20. Pilotelli, M. & Grassi, B. & Lezzi, A.M. & Beretta, G.P., 2022. "Flow models of perforated manifolds and plates for the design of a large thermal storage tank for district heating with minimal maldistribution and thermocline growth," Applied Energy, Elsevier, vol. 322(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:126:y:2018:i:c:p:281-295. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.