IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v191y2020ics0360544219322583.html
   My bibliography  Save this article

Enhanced liquid tar production as fuels/chemicals from Powder River Basin coal through CaO catalyzed stepwise degradation in eco-friendly supercritical CO2/ethanol

Author

Listed:
  • Liu, Fang-Jing
  • Gasem, Khaled A.M.
  • Tang, Mingchen
  • Xu, Bang
  • Huang, Zaixing
  • Zhang, Riguang
  • Fan, Maohong

Abstract

Developing eco-friendly thermal conversion technologies of coals into fuels/chemicals with minimal environmental impact is highly attractive and significant for efficient coal utilization. CaO catalyzed stepwise degradation at 350–400 °C in eco-friendly supercritical CO2/ethanol (scCO2/ethanol) was carried out to produce high-yield liquid tars as fuels/chemicals from Powder River Basin (PRB) coal. The total yield of the liquid tars increased from 53.9 wt% for non-catalytic stepwise degradation to 60.1 wt% for CaO catalyzed stepwise degradation, with an increase of 6.2 wt%. The resulting ash-free liquid tars are promising raw materials as clean liquid fuels for energy production due to their high H/C ratio (1.16–1.88) and heating values (32.84–35.84 MJ/kg). Compared with non-catalytic stepwise degradation, the energy recovery increases from 62.8% to 71.6% by CaO catalyzed stepwise degradation. More than 75% of the components in the liquid tars were volatilized and/or degraded at temperature <500 °C according to thermogravimetric analysis. The distributions of the functional groups and group components in the liquid tars are similar to each other. Phenols are the most abundant volatile group component in the liquid tars, accounting for about 43% of the volatile components released at 350 °C and 375 °C by CaO catalyzed stepwise degradation. The CaO promoted forming active H+ and CH3CH2O− from ethanol, which readily attacked and cleaved weak -C-O- bonds in the PRB coal, leading to producing more phenols and arenes. Thermal dissociation of the non-covalent interactions especially hydrogen bonds or the cleavage of weak -C-O- in PRB coal could interpret the generation of phenols.

Suggested Citation

  • Liu, Fang-Jing & Gasem, Khaled A.M. & Tang, Mingchen & Xu, Bang & Huang, Zaixing & Zhang, Riguang & Fan, Maohong, 2020. "Enhanced liquid tar production as fuels/chemicals from Powder River Basin coal through CaO catalyzed stepwise degradation in eco-friendly supercritical CO2/ethanol," Energy, Elsevier, vol. 191(C).
    • Handle: RePEc:eee:energy:v:191:y:2020:i:c:s0360544219322583
    DOI: 10.1016/j.energy.2019.116563
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544219322583
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2019.116563?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Lei, Zhiping & Liu, Muxin & Gao, Lijuan & Shui, Hengfu & Wang, Zhicai & Ren, Shibiao, 2011. "Liquefaction of Shengli lignite with methanol and CaO under low pressure," Energy, Elsevier, vol. 36(5), pages 3058-3062.
    2. Zhang, Qing & Xu, Ying & Li, Yuping & Wang, Tiejun & Zhang, Qi & Ma, Longlong & He, Minghong & Li, Kai, 2015. "Investigation on the esterification by using supercritical ethanol for bio-oil upgrading," Applied Energy, Elsevier, vol. 160(C), pages 633-640.
    3. Pedersen, T.H. & Jensen, C.U. & Sandström, L. & Rosendahl, L.A., 2017. "Full characterization of compounds obtained from fractional distillation and upgrading of a HTL biocrude," Applied Energy, Elsevier, vol. 202(C), pages 408-419.
    4. Chen, Bo & Wei, Xian-Yong & Zong, Zhi-Min & Yang, Zhu-Sheng & Qing, Yu & Liu, Chang, 2011. "Difference in chemical composition of supercritical methanolysis products between two lignites," Applied Energy, Elsevier, vol. 88(12), pages 4570-4576.
    5. Liu, Fang-Jing & Gasem, Khaled A.M. & Tang, Mingchen & Goroncy, Alexander & He, Xin & Huang, Zaixing & Sun, Kaidi & Fan, Maohong, 2018. "Mild degradation of Powder River Basin sub-bituminous coal in environmentally benign supercritical CO2-ethanol system to produce valuable high-yield liquid tar," Applied Energy, Elsevier, vol. 225(C), pages 460-470.
    6. Zhang, Fan & Xu, Deping & Wang, Yonggang & Argyle, Morris D. & Fan, Maohong, 2015. "CO2 gasification of Powder River Basin coal catalyzed by a cost-effective and environmentally friendly iron catalyst," Applied Energy, Elsevier, vol. 145(C), pages 295-305.
    7. Walter Leitner, 2000. "Designed to dissolve," Nature, Nature, vol. 405(6783), pages 129-130, May.
    8. Rudyk, Svetlana & Spirov, Pavel, 2014. "Upgrading and extraction of bitumen from Nigerian tar sand by supercritical carbon dioxide," Applied Energy, Elsevier, vol. 113(C), pages 1397-1404.
    9. Liu, Fang-Jing & Wei, Xian-Yong & Fan, Maohong & Zong, Zhi-Min, 2016. "Separation and structural characterization of the value-added chemicals from mild degradation of lignites: A review," Applied Energy, Elsevier, vol. 170(C), pages 415-436.
    10. Li, Hongjun & Chang, Qinghua & Gao, Rui & Dai, Zhenghua & Chen, Xueli & Yu, Guangsuo & Wang, Fuchen, 2018. "Fractal characteristics and reactivity evolution of lignite during the upgrading process by supercritical CO2 extraction," Applied Energy, Elsevier, vol. 225(C), pages 559-569.
    11. Knez, Ž. & Markočič, E. & Leitgeb, M. & Primožič, M. & Knez Hrnčič, M. & Škerget, M., 2014. "Industrial applications of supercritical fluids: A review," Energy, Elsevier, vol. 77(C), pages 235-243.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Liu, Fang-Jing & Liu, Guang-Hui & Gasem, Khaled A.M. & Xu, Bang & Goroncy, Alexander & Tang, Ming-Chen & Huang, Zai-Xing & Fan, Maohong & Wei, Xian-Yong, 2020. "Green and efficient two-step degradation approach for converting Powder River Basin coal into fuels/chemicals and insights into their chemical compositions," Applied Energy, Elsevier, vol. 264(C).
    2. Liu, Fang-Jing & Gasem, Khaled A.M. & Tang, Mingchen & Goroncy, Alexander & He, Xin & Huang, Zaixing & Sun, Kaidi & Fan, Maohong, 2018. "Mild degradation of Powder River Basin sub-bituminous coal in environmentally benign supercritical CO2-ethanol system to produce valuable high-yield liquid tar," Applied Energy, Elsevier, vol. 225(C), pages 460-470.
    3. Kravanja, Gregor & Zajc, Gašper & Knez, Željko & Škerget, Mojca & Marčič, Simon & Knez, Maša H., 2018. "Heat transfer performance of CO2, ethane and their azeotropic mixture under supercritical conditions," Energy, Elsevier, vol. 152(C), pages 190-201.
    4. Artem A. Medvedev & Daria A. Beldova & Konstantin B. Kalmykov & Alexey V. Kravtsov & Marina A. Tedeeva & Leonid M. Kustov & Sergey F. Dunaev & Alexander L. Kustov, 2022. "Carbon Dioxide Assisted Conversion of Hydrolysis Lignin Catalyzed by Nickel Compounds," Energies, MDPI, vol. 15(18), pages 1-12, September.
    5. Song, Weiming & Zhou, Jianan & Li, Yujie & Yang, Jian & Cheng, Rijin, 2021. "New technology for producing high-quality combustible gas by high-temperature reaction of dust-removal coke powder in mixed atmosphere," Energy, Elsevier, vol. 233(C).
    6. Xu, Jialing & Rong, Siqi & Sun, Jingli & Peng, Zhiyong & Jin, Hui & Guo, Liejin & Zhang, Xiang & Zhou, Teng, 2022. "Optimal design of non-isothermal supercritical water gasification reactor: From biomass to hydrogen," Energy, Elsevier, vol. 244(PB).
    7. Ding, Lu & Dai, Zhenghua & Guo, Qinghua & Yu, Guangsuo, 2017. "Effects of in-situ interactions between steam and coal on pyrolysis and gasification characteristics of pulverized coals and coal water slurry," Applied Energy, Elsevier, vol. 187(C), pages 627-639.
    8. Sarkar, Jahar, 2015. "Review and future trends of supercritical CO2 Rankine cycle for low-grade heat conversion," Renewable and Sustainable Energy Reviews, Elsevier, vol. 48(C), pages 434-451.
    9. Feng, Junfeng & Yang, Zhongzhi & Hse, Chung-yun & Su, Qiuli & Wang, Kui & Jiang, Jianchun & Xu, Junming, 2017. "In situ catalytic hydrogenation of model compounds and biomass-derived phenolic compounds for bio-oil upgrading," Renewable Energy, Elsevier, vol. 105(C), pages 140-148.
    10. Taghipour, Alireza & Ramirez, Jerome A. & Brown, Richard J. & Rainey, Thomas J., 2019. "A review of fractional distillation to improve hydrothermal liquefaction biocrude characteristics; future outlook and prospects," Renewable and Sustainable Energy Reviews, Elsevier, vol. 115(C).
    11. Zhang, Xiaogang & Ranjith, P.G. & Ranathunga, A.S., 2019. "Sub- and super-critical carbon dioxide flow variations in large high-rank coal specimen: An experimental study," Energy, Elsevier, vol. 181(C), pages 148-161.
    12. Lozano, E.M. & Pedersen, T.H. & Rosendahl, L.A., 2020. "Integration of hydrothermal liquefaction and carbon capture and storage for the production of advanced liquid biofuels with negative CO2 emissions," Applied Energy, Elsevier, vol. 279(C).
    13. Guo, Hongguang & Zhang, Yujie & Zhang, Yiwen & Li, Xingfeng & Li, Zhigang & Liang, Weiguo & Huang, Zaixing & Urynowicz, Michael & Ali, Muhammad Ishtiaq, 2021. "Feasibility study of enhanced biogenic coalbed methane production by super-critical CO2 extraction," Energy, Elsevier, vol. 214(C).
    14. Ankit Mathanker & Snehlata Das & Deepak Pudasainee & Monir Khan & Amit Kumar & Rajender Gupta, 2021. "A Review of Hydrothermal Liquefaction of Biomass for Biofuels Production with a Special Focus on the Effect of Process Parameters, Co-Solvents, and Extraction Solvents," Energies, MDPI, vol. 14(16), pages 1-60, August.
    15. Moinuddin Ghauri & Khurram Shahzad & M. Shahzad Khurram & Mujtaba Hussain Jaffery & Najaf Ali & Waqar Ali Khan & Keith R. Cliffe, 2017. "Development of a Temperature Programmed Identification Technique to Characterize the Organic Sulphur Functional Groups in Coal," Energies, MDPI, vol. 10(6), pages 1-17, June.
    16. Krogh, Andreas & Lozano, Eliana M. & Grue, Jeppe & Pedersen, Thomas H., 2024. "Assessment of feasible site locations for biofuel production based on technoeconomic modelling and GHG impact analysis," Applied Energy, Elsevier, vol. 356(C).
    17. Shahbaz, Muhammad & Yusup, Suzana & Inayat, Abrar & Patrick, David Onoja & Pratama, Angga, 2016. "Application of response surface methodology to investigate the effect of different variables on conversion of palm kernel shell in steam gasification using coal bottom ash," Applied Energy, Elsevier, vol. 184(C), pages 1306-1315.
    18. Sapkota, Krishna & Oni, Abayomi Olufemi & Kumar, Amit & Linwei, Ma, 2018. "The development of a techno-economic model for the extraction, transportation, upgrading, and shipping of Canadian oil sands products to the Asia-Pacific region," Applied Energy, Elsevier, vol. 223(C), pages 273-292.
    19. Shafaghat, Hoda & Kim, Ji Man & Lee, In-Gu & Jae, Jungho & Jung, Sang-Chul & Park, Young-Kwon, 2019. "Catalytic hydrodeoxygenation of crude bio-oil in supercritical methanol using supported nickel catalysts," Renewable Energy, Elsevier, vol. 144(C), pages 159-166.
    20. Nikolaos Montesantos & Marco Maschietti, 2020. "Supercritical Carbon Dioxide Extraction of Lignocellulosic Bio-Oils: The Potential of Fuel Upgrading and Chemical Recovery," Energies, MDPI, vol. 13(7), pages 1-35, April.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:191:y:2020:i:c:s0360544219322583. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.