IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v97y2012icp785-791.html
   My bibliography  Save this article

Combined hydrogen and ethanol production from sugars and lignocellulosic biomass by Thermoanaerobacterium AK54, isolated from hot spring

Author

Listed:
  • Sigurbjornsdottir, Margret Audur
  • Orlygsson, Johann

Abstract

Combined biohydrogen and bioethanol (CHE) production from monosugars, polymeric carbohydrates and hydrolysates made from various lignocellulosic biomasses was investigated by strain AK54, a saccharolytic, thermophilic ethanol and hydrogen producing bacterium isolated from a hot spring in Iceland. Optimum growth conditions for the strain were between pH 5.0–6.0 and at 65°C. As determined by full 16S rRNA analysis, strain AK54 belongs to the genus Thermoanaerobacterium, most closely affiliated with Thermoanaerobacterium aciditolerans (99.0%). Effect of increased initial glucose concentration on growth and end product formation was investigated and good correlations were observed between increased substrate loadings and end product formation of up to 50mM where clear inhibition was shown. The ability to utilize various carbon substrates was tested with positive growth on xylose, glucose, fructose, mannose, galactose, sucrose and lactose. The major end products in all cases were ethanol, acetate, lactate, hydrogen and carbon dioxide. By lowering the partial pressure of hydrogen during glucose degradation, the end product formation was directed towards hydrogen, acetate and ethanol but away from lactate. Hydrogen and ethanol production from hydrolysates from biomass (7.5gL−1 (dw)); cellulose, newspaper, grass (Phleum pratense), barley straw (Hordeum vulgare), and hemp (Cannabis sativa L), was investigated. The biomass was chemically (acid/alkali) and enzymatically pretreated. The highest ethanol production was observed from cellulose hydrolysates (24.2mM) but less was produced from lignocellulosic biomasses. Chemical pretreatment of biomass hydrolysates increased hydrogen and ethanol yields substantially from barley straw, hemp and grass but not from cellulose or newspaper. The highest hydrogen was also produced from cellulose hydrolysates or 6.7mol-H2g−1 TS pretreated with alkali (12.2mol-H2g−1 glucose equivalents) but of the lignocellulosic biomass, highest yields were from grass pretreated with base (4.9mol-H2g−1 TS).

Suggested Citation

  • Sigurbjornsdottir, Margret Audur & Orlygsson, Johann, 2012. "Combined hydrogen and ethanol production from sugars and lignocellulosic biomass by Thermoanaerobacterium AK54, isolated from hot spring," Applied Energy, Elsevier, vol. 97(C), pages 785-791.
    • Handle: RePEc:eee:appene:v:97:y:2012:i:c:p:785-791
    DOI: 10.1016/j.apenergy.2011.11.035
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S030626191100732X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2011.11.035?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Saxena, R.C. & Adhikari, D.K. & Goyal, H.B., 2009. "Biomass-based energy fuel through biochemical routes: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 13(1), pages 167-178, January.
    2. Balat, Mustafa & Balat, Havva, 2009. "Recent trends in global production and utilization of bio-ethanol fuel," Applied Energy, Elsevier, vol. 86(11), pages 2273-2282, November.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Chu, Chen-Yeon & Sen, Biswarup & Lay, Chyi-How & Lin, Yi-Chun & Lin, Chiu-Yue, 2012. "Direct fermentation of sweet potato to produce maximal hydrogen and ethanol," Applied Energy, Elsevier, vol. 100(C), pages 10-18.
    2. Sean Michael Scully & Johann Orlygsson, 2014. "Recent Advances in Second Generation Ethanol Production by Thermophilic Bacteria," Energies, MDPI, vol. 8(1), pages 1-30, December.
    3. Sarma, Saurabh Jyoti & Pachapur, Vinayak & Brar, Satinder Kaur & Le Bihan, Yann & Buelna, Gerardo, 2015. "Hydrogen biorefinery: Potential utilization of the liquid waste from fermentative hydrogen production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 942-951.
    4. Arora, Richa & Behera, Shuvashish & Sharma, Nilesh Kumar & Kumar, Sachin, 2017. "Augmentation of ethanol production through statistically designed growth and fermentation medium using novel thermotolerant yeast isolates," Renewable Energy, Elsevier, vol. 109(C), pages 406-421.
    5. Varrone, C. & Liberatore, R. & Crescenzi, T. & Izzo, G. & Wang, A., 2013. "The valorization of glycerol: Economic assessment of an innovative process for the bioconversion of crude glycerol into ethanol and hydrogen," Applied Energy, Elsevier, vol. 105(C), pages 349-357.
    6. Zhang, Yan & Zhang, Fang & Chen, Man & Chu, Pei-Na & Ding, Jing & Zeng, Raymond J., 2013. "Hydrogen supersaturation in extreme-thermophilic (70°C) mixed culture fermentation," Applied Energy, Elsevier, vol. 109(C), pages 213-219.
    7. Roy, Shantonu & Vishnuvardhan, M. & Das, Debabrata, 2014. "Continuous thermophilic biohydrogen production in packed bed reactor," Applied Energy, Elsevier, vol. 136(C), pages 51-58.
    8. Silva, V. & Ratti, R.P. & Sakamoto, I.K. & Andrade, M.V.F. & Varesche, M.B.A., 2018. "Biotechnological products in batch reactors obtained from cellulose, glucose and xylose using thermophilic anaerobic consortium," Renewable Energy, Elsevier, vol. 125(C), pages 537-545.
    9. Liu, Xianhua & Hao, Miaoqing & Feng, Mengnan & Zhang, Lin & Zhao, Yong & Du, Xiwen & Wang, Guangyi, 2013. "A One-compartment direct glucose alkaline fuel cell with methyl viologen as electron mediator," Applied Energy, Elsevier, vol. 106(C), pages 176-183.
    10. Arora, Richa & Behera, Shuvashish & Kumar, Sachin, 2015. "Bioprospecting thermophilic/thermotolerant microbes for production of lignocellulosic ethanol: A future perspective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 51(C), pages 699-717.
    11. Soares, Juliana Ferreira & Confortin, Tássia Carla & Todero, Izelmar & Mayer, Flávio Dias & Mazutti, Marcio Antonio, 2020. "Dark fermentative biohydrogen production from lignocellulosic biomass: Technological challenges and future prospects," Renewable and Sustainable Energy Reviews, Elsevier, vol. 117(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Aliyu, Abubakar Sadiq & Dada, Joseph O. & Adam, Ibrahim Khalil, 2015. "Current status and future prospects of renewable energy in Nigeria," Renewable and Sustainable Energy Reviews, Elsevier, vol. 48(C), pages 336-346.
    2. Gupta, Anubhuti & Verma, Jay Prakash, 2015. "Sustainable bio-ethanol production from agro-residues: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 41(C), pages 550-567.
    3. Yasuda, Masahide & Matsumoto, Tomoko & Yamashita, Toshiaki, 2018. "Sacrificial hydrogen production over TiO2-based photocatalysts: Polyols, carboxylic acids, and saccharides," Renewable and Sustainable Energy Reviews, Elsevier, vol. 81(P2), pages 1627-1635.
    4. Bharathiraja, B. & Jayamuthunagai, J. & Sudharsanaa, T. & Bharghavi, A. & Praveenkumar, R. & Chakravarthy, M. & Yuvaraj, D., 2017. "Biobutanol – An impending biofuel for future: A review on upstream and downstream processing tecniques," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P1), pages 788-807.
    5. Al-Jabri, Hareb & Das, Probir & Khan, Shoyeb & AbdulQuadir, Mohammad & Thaher, Mehmoud Ibrahim & Hoekman, Kent & Hawari, Alaa H., 2022. "A comparison of bio-crude oil production from five marine microalgae – Using life cycle analysis," Energy, Elsevier, vol. 251(C).
    6. M'Arimi, M.M. & Mecha, C.A. & Kiprop, A.K. & Ramkat, R., 2020. "Recent trends in applications of advanced oxidation processes (AOPs) in bioenergy production: Review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 121(C).
    7. Sánchez, S. & Lozano, L.J. & Godínez, C. & Juan, D. & Pérez, A. & Hernández, F.J., 2010. "Carob pod as a feedstock for the production of bioethanol in Mediterranean areas," Applied Energy, Elsevier, vol. 87(11), pages 3417-3424, November.
    8. Qi, Jianhui & Zhao, Jianli & Xu, Yang & Wang, Yongjia & Han, Kuihua, 2018. "Segmented heating carbonization of biomass: Yields, property and estimation of heating value of chars," Energy, Elsevier, vol. 144(C), pages 301-311.
    9. Zhang, Zhikun & Zhu, Zongyuan & Shen, Boxiong & Liu, Lina, 2019. "Insights into biochar and hydrochar production and applications: A review," Energy, Elsevier, vol. 171(C), pages 581-598.
    10. Jin, Wenxiang & Chen, Ling & Hu, Meng & Sun, Dan & Li, Ao & Li, Ying & Hu, Zhen & Zhou, Shiguang & Tu, Yuanyuan & Xia, Tao & Wang, Yanting & Xie, Guosheng & Li, Yanbin & Bai, Baowei & Peng, Liangcai, 2016. "Tween-80 is effective for enhancing steam-exploded biomass enzymatic saccharification and ethanol production by specifically lessening cellulase absorption with lignin in common reed," Applied Energy, Elsevier, vol. 175(C), pages 82-90.
    11. Phanankosi Moyo & Mahluli Moyo & Donatus Dube & Oswell Rusinga, 2013. "Biofuel Policy as a Key Driver for Sustainable Development in the Biofuel Sector: The Missing Ingredient in Zimbabwe’s Biofuel Pursuit," Modern Applied Science, Canadian Center of Science and Education, vol. 8(1), pages 1-36, February.
    12. Tan, Raymond R. & Aviso, Kathleen B. & Barilea, Ivan U. & Culaba, Alvin B. & Cruz, Jose B., 2012. "A fuzzy multi-regional input–output optimization model for biomass production and trade under resource and footprint constraints," Applied Energy, Elsevier, vol. 90(1), pages 154-160.
    13. Yao, Yung-Chen & Tsai, Jiun-Horng & Wang, I-Ting, 2013. "Emissions of gaseous pollutant from motorcycle powered by ethanol–gasoline blend," Applied Energy, Elsevier, vol. 102(C), pages 93-100.
    14. Starfelt, Fredrik & Daianova, Lilia & Yan, Jinyue & Thorin, Eva & Dotzauer, Erik, 2012. "The impact of lignocellulosic ethanol yields in polygeneration with district heating – A case study," Applied Energy, Elsevier, vol. 92(C), pages 791-799.
    15. Pätäri, Satu & Puumalainen, Kaisu & Jantunen, Ari & Sandstrüm, Jaana, 2011. "The interface of the energy and forest sectors--Potential players in the bioenergy business," International Journal of Production Economics, Elsevier, vol. 131(1), pages 322-332, May.
    16. Vallinayagam, R. & Vedharaj, S. & Yang, W.M. & Roberts, W.L. & Dibble, R.W., 2015. "Feasibility of using less viscous and lower cetane (LVLC) fuels in a diesel engine: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 51(C), pages 1166-1190.
    17. Goh, Chun Sheng & Lee, Keat Teong, 2010. "A visionary and conceptual macroalgae-based third-generation bioethanol (TGB) biorefinery in Sabah, Malaysia as an underlay for renewable and sustainable development," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(2), pages 842-848, February.
    18. Katia A. Figueroa-Rodríguez & Francisco Hernández-Rosas & Benjamín Figueroa-Sandoval & Joel Velasco-Velasco & Noé Aguilar Rivera, 2019. "What Has Been the Focus of Sugarcane Research? A Bibliometric Overview," IJERPH, MDPI, vol. 16(18), pages 1-15, September.
    19. M. N. Uddin & Kuaanan Techato & Juntakan Taweekun & Md Mofijur Rahman & M. G. Rasul & T. M. I. Mahlia & S. M. Ashrafur, 2018. "An Overview of Recent Developments in Biomass Pyrolysis Technologies," Energies, MDPI, vol. 11(11), pages 1-24, November.
    20. Poder, Thomas G. & He, Jie, 2017. "Willingness to pay for a cleaner car: The case of car pollution in Quebec and France," Energy, Elsevier, vol. 130(C), pages 48-54.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:97:y:2012:i:c:p:785-791. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.