IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v15y2023i18p13993-d1244319.html
   My bibliography  Save this article

Research on Gas Recycling of Free-Piston Expander–Linear Generator for Organic Rankine Cycle of Vehicle

Author

Listed:
  • Baoying Peng

    (School of Electrical and Mechanical Engineering, Beijing Information Science and Technology University, Beijing 100192, China)

  • Kai Zhang

    (School of Electrical and Mechanical Engineering, Beijing Information Science and Technology University, Beijing 100192, China)

  • Liang Tong

    (School of Electrical and Mechanical Engineering, Beijing Information Science and Technology University, Beijing 100192, China)

  • Yonghong Xu

    (School of Electrical and Mechanical Engineering, Beijing Information Science and Technology University, Beijing 100192, China)

Abstract

A (FPE-LG) is a new type of vehicle waste heat recovery device based on an organic Rankine cycle. It is expected to achieve the reuse of vehicle internal combustion engine waste heat and improve the comprehensive utilization rate of energy. To enable the FPE-LG to recover exhaust gas to a greater extent in practical applications, based on the FPE-LG coupling gas storage tank test platform, the gas is discharged from the expander cylinder. This paper analyzes the influence of differences to the tank volume, intake pressure, intake duration time, expansion duration time and exhaust duration time on piston motion characteristics and gas storage and release time during the cycle, and verifies the feasibility of gas working as a recycling medium. The results showed that the energy storage of lithium batteries increases with the increase of intake pressure, and the energy stored in lithium batteries during gas release is higher than that during gas storage; the intake duration time, expansion duration time and exhaust duration time have little effect on the storage of lithium battery energy during the cycle. When the intake pressure is 0.5 MPa, the volume of the gas tank is 30 L, and the intake duration time, expansion duration time and exhaust duration time are 50 ms, 80 ms and 30 ms, respectively, the maximum actual stroke of the piston can reach 89.592 mm.

Suggested Citation

  • Baoying Peng & Kai Zhang & Liang Tong & Yonghong Xu, 2023. "Research on Gas Recycling of Free-Piston Expander–Linear Generator for Organic Rankine Cycle of Vehicle," Sustainability, MDPI, vol. 15(18), pages 1-16, September.
    • Handle: RePEc:gam:jsusta:v:15:y:2023:i:18:p:13993-:d:1244319
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/15/18/13993/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/15/18/13993/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Wu, Zhong & Zhang, Hongguang & Liu, Zhongliang & Hou, Xiaochen & Li, Jian & Yang, Fubin & Zhang, Jian, 2021. "Experimental study on the performance of single-piston free-piston expander—linear generator," Energy, Elsevier, vol. 221(C).
    2. Bouvier, Jean-Louis & Lemort, Vincent & Michaux, Ghislain & Salagnac, Patrick & Kientz, Thiebaut, 2016. "Experimental study of an oil-free steam piston expander for micro-combined heat and power systems," Applied Energy, Elsevier, vol. 169(C), pages 788-798.
    3. Preetham, B.S. & Weiss, L., 2016. "Investigations of a new free piston expander engine cycle," Energy, Elsevier, vol. 106(C), pages 535-545.
    4. Wang, Yaodong & Chen, Lin & Jia, Boru & Roskilly, Anthony Paul, 2017. "Experimental study of the operation characteristics of an air-driven free-piston linear expander," Applied Energy, Elsevier, vol. 195(C), pages 93-99.
    5. Tian, Yaming & Zhang, Hongguang & Li, Jian & Hou, Xiaochen & Zhao, Tenglong & Yang, Fubin & Xu, Yonghong & Wang, Xin, 2018. "Development and validation of a single-piston free piston expander-linear generator for a small-scale organic Rankine cycle," Energy, Elsevier, vol. 161(C), pages 809-820.
    6. Catapano, F. & Frazzica, A. & Freni, A. & Manzan, M. & Micheli, D. & Palomba, V. & Sementa, P. & Vaglieco, B.M., 2022. "Development and experimental testing of an integrated prototype based on Stirling, ORC and a latent thermal energy storage system for waste heat recovery in naval application," Applied Energy, Elsevier, vol. 311(C).
    7. Guo, T. & Wang, H.X. & Zhang, S.J., 2011. "Fluids and parameters optimization for a novel cogeneration system driven by low-temperature geothermal sources," Energy, Elsevier, vol. 36(5), pages 2639-2649.
    8. Xu, Yonghong & Tong, Liang & Zhang, Hongguang & Hou, Xiaochen & Yang, Fubin & Yu, Fei & Yang, Yuxin & Liu, Rong & Tian, Yaming & Zhao, Tenglong, 2018. "Experimental and simulation study of a free piston expander–linear generator for small-scale organic Rankine cycle," Energy, Elsevier, vol. 161(C), pages 776-791.
    9. Burugupally, Sindhu Preetham & Weiss, Leland, 2019. "Design and performance of a miniature free piston expander," Energy, Elsevier, vol. 170(C), pages 611-618.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hou, Xiaochen & Zhang, Hongguang & Zhao, Tenglong & Xu, Yonghong & Tian, Yaming & Li, Jian & Zhang, Mengru & Wu, Yuting, 2019. "A comparison study and performance analysis of free piston expander-linear generator for organic Rankine cycle system," Energy, Elsevier, vol. 167(C), pages 136-143.
    2. Wu, Zhong & Zhang, Hongguang & Liu, Zhongliang & Tian, Guohong & Hou, Xiaochen & Yang, Fubin, 2022. "Force and energy analysis of single-piston free-piston expander—linear generator," Energy, Elsevier, vol. 251(C).
    3. Bianchi, M. & Branchini, L. & De Pascale, A. & Melino, F. & Ottaviano, S. & Peretto, A. & Torricelli, N., 2019. "Application and comparison of semi-empirical models for performance prediction of a kW-size reciprocating piston expander," Applied Energy, Elsevier, vol. 249(C), pages 143-156.
    4. Zhuxian Liu & Zhong Wu & Yonghong Xu & Hongguang Zhang & Jian Zhang & Fubin Yang, 2022. "Performance Investigation of Single–Piston Free Piston Expander–Linear Generator with Multi–Parameter Based on Simulation Model," Energies, MDPI, vol. 15(23), pages 1-28, November.
    5. Hou, Xiaochen & Zhang, Hongguang & Xu, Yonghong & Yu, Fei & Zhao, Tenglong & Tian, Yaming & Yang, Yuxin & Zhao, Rui, 2018. "External load resistance effect on the free piston expander-linear generator for organic Rankine cycle waste heat recovery system," Applied Energy, Elsevier, vol. 212(C), pages 1252-1261.
    6. Hou, Xiaochen & Zhang, Hongguang & Yu, Fei & Liu, Hongda & Yang, Fubin & Xu, Yonghong & Tian, Yaming & Li, Gaosheng, 2017. "Free piston expander-linear generator used for organic Rankine cycle waste heat recovery system," Applied Energy, Elsevier, vol. 208(C), pages 1297-1307.
    7. Hou, Xiaochen & Ji, Deliang & Zhou, Dan & Gao, Haibo, 2023. "Simulation study and performance analysis of free piston linear generator (FPLG) used for ORC system," Energy, Elsevier, vol. 282(C).
    8. Xu, Yonghong & Tong, Liang & Zhang, Hongguang & Hou, Xiaochen & Yang, Fubin & Yu, Fei & Yang, Yuxin & Liu, Rong & Tian, Yaming & Zhao, Tenglong, 2018. "Experimental and simulation study of a free piston expander–linear generator for small-scale organic Rankine cycle," Energy, Elsevier, vol. 161(C), pages 776-791.
    9. Wu, Zhong & Zhang, Hongguang & Liu, Zhongliang & Hou, Xiaochen & Li, Jian & Yang, Fubin & Zhang, Jian, 2021. "Experimental study on the performance of single-piston free-piston expander—linear generator," Energy, Elsevier, vol. 221(C).
    10. Yang, Fubin & Zhang, Hongguang & Hou, Xiaochen & Tian, Yaming & Xu, Yonghong, 2019. "Experimental study and artificial neural network based prediction of a free piston expander-linear generator for small scale organic Rankine cycle," Energy, Elsevier, vol. 175(C), pages 630-644.
    11. Li, Jian & Yang, Fubin & Zhang, Hongguang & Wu, Zhong & Tian, Yaming & Hou, Xiaochen & Xu, Yonghong & Ren, Jing, 2020. "Comparative analysis of different valve timing control methods for single-piston free piston expander-linear generator via an orthogonal experimental design," Energy, Elsevier, vol. 195(C).
    12. Tian, Yaming & Zhang, Hongguang & Li, Jian & Hou, Xiaochen & Zhao, Tenglong & Yang, Fubin & Xu, Yonghong & Wang, Xin, 2018. "Development and validation of a single-piston free piston expander-linear generator for a small-scale organic Rankine cycle," Energy, Elsevier, vol. 161(C), pages 809-820.
    13. Ngwaka, Ugochukwu & Jia, Boru & Lawrence, Christopher & Wu, Dawei & Smallbone, Andrew & Roskilly, Anthony Paul, 2019. "The characteristics of a Linear Joule Engine Generator operating on a dry friction principle," Applied Energy, Elsevier, vol. 237(C), pages 49-59.
    14. Burugupally, Sindhu Preetham & Weiss, Leland, 2019. "Design and performance of a miniature free piston expander," Energy, Elsevier, vol. 170(C), pages 611-618.
    15. Singer, Gerald & Köll, Rebekka & Aichhorn, Lukas & Pertl, Patrick & Trattner, Alexander, 2023. "Utilizing hydrogen pressure energy by expansion machines – PEM fuel cells in mobile and other potential applications," Applied Energy, Elsevier, vol. 343(C).
    16. Tenissara, Nopporn & Thepa, Sirichai & Monyakul, Veerapol, 2018. "Simulation, construction and evaluation of cheap piston expander for low-pressure power generation by compressed air as working fluid," Energy, Elsevier, vol. 142(C), pages 655-665.
    17. Francesconi, Marco & Dori, Edoardo & Antonelli, Marco, 2019. "Analysis of Balje diagrams for a Wankel expander prototype," Applied Energy, Elsevier, vol. 238(C), pages 775-785.
    18. He, Chao & Liu, Chao & Zhou, Mengtong & Xie, Hui & Xu, Xiaoxiao & Wu, Shuangying & Li, Yourong, 2014. "A new selection principle of working fluids for subcritical organic Rankine cycle coupling with different heat sources," Energy, Elsevier, vol. 68(C), pages 283-291.
    19. Li, Tailu & Zhu, Jialing & Hu, Kaiyong & Kang, Zhenhua & Zhang, Wei, 2014. "Implementation of PDORC (parallel double-evaporator organic Rankine cycle) to enhance power output in oilfield," Energy, Elsevier, vol. 68(C), pages 680-687.
    20. Li, Jian & Zuo, Zhengxing & Jia, Boru & Feng, Huihua & Mei, Bingang & Smallbone, Andrew & Roskilly, Anthony Paul, 2024. "Operating characteristics and design parameter optimization of permanent magnet linear generator applied to free-piston energy converter," Energy, Elsevier, vol. 287(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:15:y:2023:i:18:p:13993-:d:1244319. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.