IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v8y2015i11p12359-13111d59006.html
   My bibliography  Save this article

Implementation of Single Phase Soft Switched PFC Converter for Plug-in-Hybrid Electric Vehicles

Author

Listed:
  • Aiswariya Sekar

    (Syed Ammal Engineering College, Ramanathapuram 623502, India)

  • Dhanasekaran Raghavan

    (Syed Ammal Engineering College, Ramanathapuram 623502, India)

Abstract

This paper presents a new soft switching boost converter with a passive snubber cell without additional active switches for battery charging systems. The proposed snubber finds its application in the front-end ac-dc converter of Plug-in Hybrid Electric Vehicle (PHEV) battery chargers. The proposed auxiliary snubber circuit consists of an inductor, two capacitors and two diodes. The new converter has the advantages of continuous input current, low switching stresses, high voltage gain without extreme duty cycle, minimized charger size and charging time and fewer amounts of cost and electricity drawn from the utility at higher switching frequencies. The switch is made to turn ON by Zero Current Switching (ZCS) and turn OFF by Zero Voltage Switching (ZVS). The detailed steady state analysis of the novel ac-dc Zero Current- Zero Voltage Switching (ZC-ZVS) boost Power Factor Correction (PFC) converter is presented with its operating principle. The experimental prototype of 20 kHz, 100 W converter verifies the theoretical analysis. The power factor of the prototype circuit reaches near unity with an efficiency of 97%, at nominal output power for a ±10% variation in the input voltage and ±20% variation in the snubber component values.

Suggested Citation

  • Aiswariya Sekar & Dhanasekaran Raghavan, 2015. "Implementation of Single Phase Soft Switched PFC Converter for Plug-in-Hybrid Electric Vehicles," Energies, MDPI, vol. 8(11), pages 1-16, November.
    • Handle: RePEc:gam:jeners:v:8:y:2015:i:11:p:12359-13111:d:59006
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/8/11/12359/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/8/11/12359/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Ching-Ming Lai & Ming-Ji Yang & Shih-Kun Liang, 2014. "A Zero Input Current Ripple ZVS/ZCS Boost Converter with Boundary-Mode Control," Energies, MDPI, vol. 7(10), pages 1-18, October.
    2. Huang, Ton-Churo & Leu, Yih-Guang & Chang, Yuan-Chang & Hou, Sheng-Yun & Li, Cheng-Chou, 2013. "An energy harvester using self-powered feed forward converter charging approach," Energy, Elsevier, vol. 55(C), pages 769-777.
    3. Fabrice Locment & Manuela Sechilariu, 2015. "Modeling and Simulation of DC Microgrids for Electric Vehicle Charging Stations," Energies, MDPI, vol. 8(5), pages 1-22, May.
    4. Al-Saffar, Mustafa A. & Ismail, Esam H. & Sabzali, Ahmad J., 2013. "Family of ZC-ZVS converters with wide voltage range for renewable energy systems," Renewable Energy, Elsevier, vol. 56(C), pages 32-43.
    5. S. Aiswariya & R. Dhanasekaran, 2014. "An AC/DC PFC Converter with Active Soft Switching Technique," International Journal of Energy Optimization and Engineering (IJEOE), IGI Global, vol. 3(3), pages 101-121, July.
    6. Cheng-Shan Wang & Wei Li & Zhun Meng & Yi-Feng Wang & Jie-Gui Zhou, 2015. "Three-Phase High-Power and Zero-Current-Switching OBC for Plug-In Electric Vehicles," Energies, MDPI, vol. 8(7), pages 1-33, June.
    7. Bouilouta, A. & Mellit, A. & Kalogirou, S.A., 2013. "New MPPT method for stand-alone photovoltaic systems operating under partially shaded conditions," Energy, Elsevier, vol. 55(C), pages 1172-1185.
    8. Punitha, K. & Devaraj, D. & Sakthivel, S., 2013. "Artificial neural network based modified incremental conductance algorithm for maximum power point tracking in photovoltaic system under partial shading conditions," Energy, Elsevier, vol. 62(C), pages 330-340.
    9. Cheng-Tao Tsai & Chih-Lung Shen & Jye-Chau Su, 2013. "A Power Supply System with ZVS and Current-Doubler Features for Hybrid Renewable Energy Conversion," Energies, MDPI, vol. 6(9), pages 1-20, September.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Oswaldo Lopez-Santos & Alejandro J. Cabeza-Cabeza & Germain Garcia & Luis Martinez-Salamero, 2019. "Sliding Mode Control of the Isolated Bridgeless SEPIC High Power Factor Rectifier Interfacing an AC Source with a LVDC Distribution Bus," Energies, MDPI, vol. 12(18), pages 1-22, September.
    2. Wenzheng Xu & Nelson Hon Lung Chan & Siu Wing Or & Siu Lau Ho & Ka Wing Chan, 2017. "A New Control Method for a Bi-Directional Phase-Shift-Controlled DC-DC Converter with an Extended Load Range," Energies, MDPI, vol. 10(10), pages 1-17, October.
    3. Younghoon Cho & Byeng-Joo Byen & Han-Sol Lee & Kwan-Yuhl Cho, 2017. "A Single-Loop Repetitive Voltage Controller with an Active Damping Control Technique," Energies, MDPI, vol. 10(5), pages 1-13, May.
    4. Amruta V. Kulkarni & Weiqiang Chen & Ali M. Bazzi, 2016. "Implementation of Rapid Prototyping Tools for Power Loss and Cost Minimization of DC-DC Converters," Energies, MDPI, vol. 9(7), pages 1-35, July.
    5. Jordi Everts, 2016. "Design and Optimization of an Efficient (96.1%) and Compact (2 kW/dm3) Bidirectional Isolated Single-Phase Dual Active Bridge AC-DC Converter," Energies, MDPI, vol. 9(10), pages 1-40, October.
    6. Ahmed H. Okilly & Namhun Kim & Jeihoon Baek, 2020. "Inrush Current Control of High Power Density DC–DC Converter," Energies, MDPI, vol. 13(17), pages 1-24, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Shen, Chih-Lung & Ko, Yong-Xian, 2014. "Hybrid-input power supply with PFC (power factor corrector) and MPPT (maximum power point tracking) features for battery charging and HB-LED driving," Energy, Elsevier, vol. 72(C), pages 501-509.
    2. Wenzheng Xu & Nelson Hon Lung Chan & Siu Wing Or & Siu Lau Ho & Ka Wing Chan, 2017. "A New Control Method for a Bi-Directional Phase-Shift-Controlled DC-DC Converter with an Extended Load Range," Energies, MDPI, vol. 10(10), pages 1-17, October.
    3. Ramli, Makbul A.M. & Twaha, Ssennoga & Ishaque, Kashif & Al-Turki, Yusuf A., 2017. "A review on maximum power point tracking for photovoltaic systems with and without shading conditions," Renewable and Sustainable Energy Reviews, Elsevier, vol. 67(C), pages 144-159.
    4. Belhachat, Faiza & Larbes, Cherif, 2017. "Global maximum power point tracking based on ANFIS approach for PV array configurations under partial shading conditions," Renewable and Sustainable Energy Reviews, Elsevier, vol. 77(C), pages 875-889.
    5. Sheik Mohammed, S. & Devaraj, D. & Imthias Ahamed, T.P., 2016. "A novel hybrid Maximum Power Point Tracking Technique using Perturb & Observe algorithm and Learning Automata for solar PV system," Energy, Elsevier, vol. 112(C), pages 1096-1106.
    6. Daraban, Stefan & Petreus, Dorin & Morel, Cristina, 2014. "A novel MPPT (maximum power point tracking) algorithm based on a modified genetic algorithm specialized on tracking the global maximum power point in photovoltaic systems affected by partial shading," Energy, Elsevier, vol. 74(C), pages 374-388.
    7. Yao, Ganzhou & Luo, Zirong & Lu, Zhongyue & Wang, Mangkuan & Shang, Jianzhong & Guerrerob, Josep M., 2023. "Unlocking the potential of wave energy conversion: A comprehensive evaluation of advanced maximum power point tracking techniques and hybrid strategies for sustainable energy harvesting," Renewable and Sustainable Energy Reviews, Elsevier, vol. 185(C).
    8. Rajesh, R. & Mabel, M. Carolin, 2016. "Design and real time implementation of a novel rule compressed fuzzy logic method for the determination operating point in a photo voltaic system," Energy, Elsevier, vol. 116(P1), pages 140-153.
    9. Singh, Bharat & Kumar, Ashwani, 2023. "Optimal energy management and feasibility analysis of hybrid renewable energy sources with BESS and impact of electric vehicle load with demand response program," Energy, Elsevier, vol. 278(PA).
    10. Celikel, Resat & Yilmaz, Musa & Gundogdu, Ahmet, 2022. "A voltage scanning-based MPPT method for PV power systems under complex partial shading conditions," Renewable Energy, Elsevier, vol. 184(C), pages 361-373.
    11. Tiara Freitas & Paulo Menegáz & Domingos Simonetti, 2015. "A New Application of the Multi-Resonant Zero-Current Switching Buck Converter: Analysis and Simulation in a PMSG Based WECS," Energies, MDPI, vol. 8(9), pages 1-20, September.
    12. Lei Zhao & Haoyu Li & Yanxue Yu & Yantian Wang, 2015. "A Novel Choice Procedure of Magnetic Component Values for Phase Shifted Full Bridge Converters with a Variable Dead-Time Control Method," Energies, MDPI, vol. 8(9), pages 1-15, September.
    13. Amir, Asim & Amir, Aamir & Che, Hang Seng & Elkhateb, Ahmad & Rahim, Nasrudin Abd, 2019. "Comparative analysis of high voltage gain DC-DC converter topologies for photovoltaic systems," Renewable Energy, Elsevier, vol. 136(C), pages 1147-1163.
    14. García-Triviño, Pablo & Torreglosa, Juan P. & Fernández-Ramírez, Luis M. & Jurado, Francisco, 2016. "Control and operation of power sources in a medium-voltage direct-current microgrid for an electric vehicle fast charging station with a photovoltaic and a battery energy storage system," Energy, Elsevier, vol. 115(P1), pages 38-48.
    15. Hauge, H.H. & Presser, V. & Burheim, O., 2014. "In-situ and ex-situ measurements of thermal conductivity of supercapacitors," Energy, Elsevier, vol. 78(C), pages 373-383.
    16. Irfan, Muhammad & Iqbal, Jamshed & Iqbal, Adeel & Iqbal, Zahid & Riaz, Raja Ali & Mehmood, Adeel, 2017. "Opportunities and challenges in control of smart grids – Pakistani perspective," Renewable and Sustainable Energy Reviews, Elsevier, vol. 71(C), pages 652-674.
    17. Reddy, K.S. & Kumar, Madhusudan & Mallick, T.K. & Sharon, H. & Lokeswaran, S., 2014. "A review of Integration, Control, Communication and Metering (ICCM) of renewable energy based smart grid," Renewable and Sustainable Energy Reviews, Elsevier, vol. 38(C), pages 180-192.
    18. Arshdeep Singh & Shimi Sudha Letha, 2019. "Emerging energy sources for electric vehicle charging station," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 21(5), pages 2043-2082, October.
    19. Kumar, Dipesh & Chatterjee, Kalyan, 2016. "A review of conventional and advanced MPPT algorithms for wind energy systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 55(C), pages 957-970.
    20. Ramli, Makbul A.M. & Prasetyono, Eka & Wicaksana, Ragil W. & Windarko, Novie A. & Sedraoui, Khaled & Al-Turki, Yusuf A., 2016. "On the investigation of photovoltaic output power reduction due to dust accumulation and weather conditions," Renewable Energy, Elsevier, vol. 99(C), pages 836-844.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:8:y:2015:i:11:p:12359-13111:d:59006. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.