IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v17y2024i4p891-d1338881.html
   My bibliography  Save this article

Installation Cost and Heat Extraction Performance Analysis of H-Shaped PC Pile Ground Heat Exchangers for Small Buildings

Author

Listed:
  • Takao Katsura

    (Faculty of Engineering, Hokkaido University, Sapporo 060-8628, Japan)

  • Katsuya Saito

    (Ambiente Innovation Co., Ltd., 1-12-4 Ginza, Chuo-ku, Tokyo 104-0061, Japan)

  • Motoaki Oe

    (INOAC Housing & Construction Materials Co., Ltd., 4-9-27 Taihou, Atsuta-ku, Nagoya 456-0062, Japan)

  • Katsunori Nagano

    (Faculty of Engineering, Hokkaido University, Sapporo 060-8628, Japan)

Abstract

Ground source heat pump systems are one of the renewable energy heat utilization technologies that can reduce the energy for HVAC and hot water supplies and consequently mitigate the progression of global warming. On the other hand, the development of ground heat exchangers that can be installed in small buildings with low installation costs is an important challenge for increasing the installation number of ground source heat pump systems in Japan. This study proposes H-shaped PC pile ground heat exchangers to reduce installation costs. The installation test and installation cost estimation of H-shaped PC pile ground heat exchangers showed that installation costs could be reduced to less than half compared to the conventional borehole double U-tube ground heat exchanger. The coefficient of heat extraction/injection of H-shaped PC pile ground heat exchangers was evaluated as 2.2–2.4 W/(m K) from the results of actual measurements during the heating and cooling operation of the GSHP system, and this was slightly high compared to the borehole single U-tube ground heat exchanger. In addition, the GSHP system with an 8 by 8 m long H-shaped PC pile ground heat exchanger could supply adequate heating output for the heating load of the residential house and operate with an SCOP of more than 3.0. Finally, the authors have confirmed that the GSHP system with H-shaped PC pile ground heat exchangers can reduce installation costs by 40% or more while maintaining the same running cost compared to conventional GSHP systems.

Suggested Citation

  • Takao Katsura & Katsuya Saito & Motoaki Oe & Katsunori Nagano, 2024. "Installation Cost and Heat Extraction Performance Analysis of H-Shaped PC Pile Ground Heat Exchangers for Small Buildings," Energies, MDPI, vol. 17(4), pages 1-14, February.
    • Handle: RePEc:gam:jeners:v:17:y:2024:i:4:p:891-:d:1338881
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/17/4/891/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/17/4/891/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Zarrella, Angelo & Capozza, Antonio & De Carli, Michele, 2013. "Analysis of short helical and double U-tube borehole heat exchangers: A simulation-based comparison," Applied Energy, Elsevier, vol. 112(C), pages 358-370.
    2. Kunning Yang & Takao Katsura & Shigeyuki Nagasaka & Katsunori Nagano, 2023. "Analyzing the Performance of Double Spiral Tube Ground Heat Exchangers in a Zero-Energy Building Using Measurement Data," Energies, MDPI, vol. 16(19), pages 1-25, October.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Aneta Sapińska-Sliwa & Marc A. Rosen & Andrzej Gonet & Joanna Kowalczyk & Tomasz Sliwa, 2019. "A New Method Based on Thermal Response Tests for Determining Effective Thermal Conductivity and Borehole Resistivity for Borehole Heat Exchangers," Energies, MDPI, vol. 12(6), pages 1-22, March.
    2. Shi, Yu & Song, Xianzhi & Wang, Gaosheng & McLennan, John & Forbes, Bryan & Li, Xiaojiang & Li, Jiacheng, 2019. "Study on wellbore fluid flow and heat transfer of a multilateral-well CO2 enhanced geothermal system," Applied Energy, Elsevier, vol. 249(C), pages 14-27.
    3. Somogyi, Viola & Sebestyén, Viktor & Nagy, Georgina, 2017. "Scientific achievements and regulation of shallow geothermal systems in six European countries – A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P2), pages 934-952.
    4. Pasquier, Philippe, 2018. "Interpretation of the first hours of a thermal response test using the time derivative of the temperature," Applied Energy, Elsevier, vol. 213(C), pages 56-75.
    5. Song, Xianzhi & Shi, Yu & Li, Gensheng & Yang, Ruiyue & Wang, Gaosheng & Zheng, Rui & Li, Jiacheng & Lyu, Zehao, 2018. "Numerical simulation of heat extraction performance in enhanced geothermal system with multilateral wells," Applied Energy, Elsevier, vol. 218(C), pages 325-337.
    6. Mathur, Anuj & Priyam, & Mathur, Sanjay & Agrawal, G.D. & Mathur, Jyotirmay, 2017. "Comparative study of straight and spiral earth air tunnel heat exchanger system operated in cooling and heating modes," Renewable Energy, Elsevier, vol. 108(C), pages 474-487.
    7. Liu, Kai & Wang, Mingjun & Zhang, Jing & Guo, Kailun & Tian, Wenxi & Qiu, Suizheng & Su, G.H., 2023. "Numerical investigation on the thermal load heterogeneity of multi-assembly helical coil steam generator in high temperature gas-cooled reactor," Energy, Elsevier, vol. 281(C).
    8. Han, Chanjuan & Yu, Xiong (Bill), 2016. "Performance of a residential ground source heat pump system in sedimentary rock formation," Applied Energy, Elsevier, vol. 164(C), pages 89-98.
    9. Liu, Qinggong & Tao, Yao & Shi, Long & Huang, Yi & Peng, Yuanling & Wang, Yong & Tu, Jiyuan, 2023. "Experimental investigations on the thermal performance of a novel ground heat exchanger under the synergistic effects of shape-stabilized phase change material and nanofluid," Energy, Elsevier, vol. 284(C).
    10. Kou, Huaqin & Luo, Wenhua & Huang, Zhiyong & Sang, Ge & Meng, Daqiao & Zhang, Guanghui & Chen, Changan & Luo, Deli & Hu, Changwen, 2015. "Fabrication and experimental validation of a full-scale depleted uranium bed with thin double-layered annulus configuration for hydrogen isotopes recovery and delivery," Energy, Elsevier, vol. 90(P1), pages 588-594.
    11. Lebbihiat, Nacer & Atia, Abdelmalek & Arıcı, Müslüm & Meneceur, Noureddine & Hadjadj, Abdessamia & Chetioui, Youcef, 2022. "Thermal performance analysis of helical ground-air heat exchanger under hot climate: In situ measurement and numerical simulation," Energy, Elsevier, vol. 254(PC).
    12. Sorranat Ratchawang & Srilert Chotpantarat & Sasimook Chokchai & Isao Takashima & Youhei Uchida & Punya Charusiri, 2022. "A Review of Ground Source Heat Pump Application for Space Cooling in Southeast Asia," Energies, MDPI, vol. 15(14), pages 1-18, July.
    13. Wu, Zhen & Yang, Fusheng & Zhang, Zaoxiao & Bao, Zewei, 2014. "Magnesium based metal hydride reactor incorporating helical coil heat exchanger: Simulation study and optimal design," Applied Energy, Elsevier, vol. 130(C), pages 712-722.
    14. Bayer, Peter & de Paly, Michael & Beck, Markus, 2014. "Strategic optimization of borehole heat exchanger field for seasonal geothermal heating and cooling," Applied Energy, Elsevier, vol. 136(C), pages 445-453.
    15. Shuyang Tu & Xiuqin Yang & Xiang Zhou & Maohui Luo & Xu Zhang, 2019. "Experimenting and Modeling Thermal Performance of Ground Heat Exchanger Under Freezing Soil Conditions," Sustainability, MDPI, vol. 11(20), pages 1-18, October.
    16. Dai, Jiacheng & Li, Jingbin & Wang, Tianyu & Zhu, Liying & Tian, Kangjian & Chen, Zhaoting, 2023. "Thermal performance analysis of coaxial borehole heat exchanger using liquid ammonia," Energy, Elsevier, vol. 263(PE).
    17. Cristina Sáez Blázquez & Arturo Farfán Martín & Ignacio Martín Nieto & Pedro Carrasco García & Luis Santiago Sánchez Pérez & Diego González-Aguilera, 2017. "Efficiency Analysis of the Main Components of a Vertical Closed-Loop System in a Borehole Heat Exchanger," Energies, MDPI, vol. 10(2), pages 1-15, February.
    18. Han, Chanjuan & Yu, Xiong (Bill), 2016. "Sensitivity analysis of a vertical geothermal heat pump system," Applied Energy, Elsevier, vol. 170(C), pages 148-160.
    19. Farzaneh-Gord, Mahmood & Ghezelbash, Reza & Sadi, Meisam & Moghadam, Ali Jabari, 2016. "Integration of vertical ground-coupled heat pump into a conventional natural gas pressure drop station: Energy, economic and CO2 emission assessment," Energy, Elsevier, vol. 112(C), pages 998-1014.
    20. Cui, Yuanlong & Zhu, Jie & Twaha, Ssennoga & Riffat, Saffa, 2018. "A comprehensive review on 2D and 3D models of vertical ground heat exchangers," Renewable and Sustainable Energy Reviews, Elsevier, vol. 94(C), pages 84-114.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:17:y:2024:i:4:p:891-:d:1338881. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.