IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i2p657-d1026498.html
   My bibliography  Save this article

Biodiesel from Rapeseed and Sunflower Oil: Effect of the Transesterification Conditions and Oxidation Stability

Author

Listed:
  • Elena Khan

    (Research School of Chemistry & Applied Biomedical Sciences, Tomsk Polytechnic University, Lenin Avenue 43, Tomsk 63400, Russia)

  • Kadir Ozaltin

    (Centre of Polymer Systems, University Institute, Tomas Bata University in Zlin, Nam. T.G.M. 5555, 76001 Zlin, Czech Republic)

  • Damiano Spagnuolo

    (Department of Chemical, Biological, Pharmaceutical and Environmental Sciences, University of Messina, Salita Sperone 31, 98166 Messina, Italy)

  • Andres Bernal-Ballen

    (Facultad de Educación, Grupo de investigacion Conciencia, Universidad Antonio Nariño, Calle 22 sur No. 12D-81, Bogota 111821, Colombia)

  • Maxim V. Piskunov

    (Heat Mass Transfer Laboratory, Tomsk Polytechnic University, Lenin Avenue 43, Tomsk 63400, Russia)

  • Antonio Di Martino

    (Research School of Chemistry & Applied Biomedical Sciences, Tomsk Polytechnic University, Lenin Avenue 43, Tomsk 63400, Russia)

Abstract

In this study, we produced biodiesel fuel from two vegetal sources, rapeseed oil and sunflower oil, by transesterification reaction. The study aims to evaluate the impact of type of alcohol, its concentration and the reaction time, while keeping constant the temperature and the catalyst on the yield and quality of the biodiesel. For alcohol, methanol and ethanol were used at a molar ratio with the oil from 3 to 24. Transesterification was performed at various reaction times; 20, 40, 60 and 90 min for each oil and defined alcohol:oil molar ratio. The influence of these parameters on the biodiesel yield and properties were investigated in terms of density, viscosity, heating value, flash point, elemental content, density and oxidative stability of the final product. The benefit of oxidation stabilizers, catechol and 4-allyl-2,6-dimethoxyphenol was investigated. Results demonstrate that for rapeseed oil, the optimum reaction conditions to obtain a higher yield and quality of biodiesel were an alcohol:oil molar ratio of 15:1, with 60-min reaction time at 50 °C; while in the case of sunflower oil, the best yield and biodiesel quality were at an 18:1 molar ratio, with a 40-min reaction time and at 50 °C. In both cases, methanol provides the highest yields of biodiesel, and the obtained products satisfy the required standards and present a similarity with mineral diesel tested in same conditions.

Suggested Citation

  • Elena Khan & Kadir Ozaltin & Damiano Spagnuolo & Andres Bernal-Ballen & Maxim V. Piskunov & Antonio Di Martino, 2023. "Biodiesel from Rapeseed and Sunflower Oil: Effect of the Transesterification Conditions and Oxidation Stability," Energies, MDPI, vol. 16(2), pages 1-13, January.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:2:p:657-:d:1026498
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/2/657/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/2/657/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Rodrigues, Jailson Silva & do Valle, Camila Peixoto & Uchoa, Antonia Flávia Justino & Ramos, Denise Moreira & da Ponte, Flávio Albuquerque Ferreira & Rios, Maria Alexsandra de Sousa & de Queiroz Malve, 2020. "Comparative study of synthetic and natural antioxidants on the oxidative stability of biodiesel from Tilapia oil," Renewable Energy, Elsevier, vol. 156(C), pages 1100-1106.
    2. Wang, Yi-Tong & Yang, Xing-Xia & Xu, Jie & Wang, Hong-Li & Wang, Zi-Bing & Zhang, Lei & Wang, Shao-Long & Liang, Jing-Long, 2019. "Biodiesel production from esterification of oleic acid by a sulfonated magnetic solid acid catalyst," Renewable Energy, Elsevier, vol. 139(C), pages 688-695.
    3. Khoobbakht, Golmohammad & Kheiralipour, Kamran & Rasouli, Hamed & Rafiee, Mojtaba & Hadipour, Mehrdad & Karimi, Mahmoud, 2020. "Experimental exergy analysis of transesterification in biodiesel production," Energy, Elsevier, vol. 196(C).
    4. Karishma, Shaik Mullan & Rajak, Upendra & Naik, B. Kiran & Dasore, Abhishek & Konijeti, Ramakrishna, 2022. "Performance and emission characteristics assessment of compression ignition engine fuelled with the blends of novel antioxidant catechol-daok biodiesel," Energy, Elsevier, vol. 245(C).
    5. Banerjee, A. & Chakraborty, R., 2009. "Parametric sensitivity in transesterification of waste cooking oil for biodiesel production—A review," Resources, Conservation & Recycling, Elsevier, vol. 53(9), pages 490-497.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Andra Lovasz & Nicu Cornel Sabau & Ioana Borza & Radu Brejea, 2023. "Production and Quality of Biodiesel under the Influence of a Rapeseed Fertilization System," Energies, MDPI, vol. 16(9), pages 1-27, April.
    2. Vishal Ram & Surender Reddy Salkuti, 2023. "An Overview of Major Synthetic Fuels," Energies, MDPI, vol. 16(6), pages 1-35, March.
    3. Suman Dey & Akhilendra Pratap Singh & Sameer Sheshrao Gajghate & Sagnik Pal & Bidyut Baran Saha & Madhujit Deb & Pankaj Kumar Das, 2023. "Optimization of CI Engine Performance and Emissions Using Alcohol–Biodiesel Blends: A Regression Analysis Approach," Sustainability, MDPI, vol. 15(20), pages 1-14, October.
    4. Stefan Cristian Galusnyak & Letitia Petrescu & Dora Andreea Chisalita & Calin-Cristian Cormos & Marco Ugolini, 2023. "From Secondary Biomass to Bio-Methanol through CONVERGE Technology: An Environmental Analysis," Energies, MDPI, vol. 16(6), pages 1-18, March.
    5. Sergio Nogales-Delgado & Agustina Guiberteau Cabanillas & Juan Pedro Moro & José María Encinar Martín, 2023. "Use of Propyl Gallate in Cardoon Biodiesel to Keep Its Main Properties during Oxidation," Clean Technol., MDPI, vol. 5(2), pages 1-15, May.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ho, Sze-Hwee & Wong, Yiik-Diew & Chang, Victor Wei-Chung, 2014. "Evaluating the potential of biodiesel (via recycled cooking oil) use in Singapore, an urban city," Resources, Conservation & Recycling, Elsevier, vol. 91(C), pages 117-124.
    2. Jaiswal, Krishna Kumar & Dutta, Swapnamoy & Banerjee, Ishita & Jaiswal, Km Smriti & Renuka, Nirmal & Ratha, Sachitra Kumar & Jaiswal, Amit K., 2024. "Valorization of fish processing industry waste for biodiesel production: Opportunities, challenges, and technological perspectives," Renewable Energy, Elsevier, vol. 220(C).
    3. Rajendra Uppar & P. Dinesha & Shiva Kumar, 2024. "Yield optimization of nonedible vegetable oil-based bio-lubricant using design of experiments," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 26(11), pages 29557-29582, November.
    4. Camilo Andrés Guerrero-Martin & Juan Sebastián Fernández-Ramírez & Jaime Eduardo Arturo-Calvache & Harvey Andrés Milquez-Sanabria & Fernando Antonio da Silva Fernandes & Vando José Costa Gomes & Wanes, 2023. "Exergy Load Distribution Analysis Applied to the Dehydration of Ethanol by Extractive Distillation," Energies, MDPI, vol. 16(8), pages 1-14, April.
    5. Hosseinzadeh-Bandbafha, Homa & Nizami, Abdul-Sattar & Kalogirou, Soteris A. & Gupta, Vijai Kumar & Park, Young-Kwon & Fallahi, Alireza & Sulaiman, Alawi & Ranjbari, Meisam & Rahnama, Hassan & Aghbashl, 2022. "Environmental life cycle assessment of biodiesel production from waste cooking oil: A systematic review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 161(C).
    6. Kheiralipour, Kamran & Khoobbakht, Mohammad & Karimi, Mahmoud, 2024. "Effect of biodiesel on environmental impacts of diesel mechanical power generation by life cycle assessment," Energy, Elsevier, vol. 289(C).
    7. Wang, Qingqiang & Hou, Jili & Wei, Xing & Jin, Nan & Ma, Yue & Li, Shuyuan & Zhao, Yuchao, 2022. "Advanced exergoenvironmental analysis of the oil shale retorting process with SJ-type rectangular retort," Energy, Elsevier, vol. 260(C).
    8. Saengprachum, Nisakorn & Cai, Dongren & Li, Mantian & Li, Ling & Lin, Xiaocheng & Qiu, Ting, 2019. "Acidic chitosan membrane as an efficient catalyst for biodiesel production from oleic acid," Renewable Energy, Elsevier, vol. 143(C), pages 1488-1499.
    9. Aby Cheruvathoor Poulose & Miroslav Medveď & Vasudeva Rao Bakuru & Akashdeep Sharma & Deepika Singh & Suresh Babu Kalidindi & Hugo Bares & Michal Otyepka & Kolleboyina Jayaramulu & Aristides Bakandrit, 2023. "Acidic graphene organocatalyst for the superior transformation of wastes into high-added-value chemicals," Nature Communications, Nature, vol. 14(1), pages 1-10, December.
    10. Gojun, Martin & Šalić, Anita & Zelić, Bruno, 2021. "Integrated microsystems for lipase-catalyzed biodiesel production and glycerol removal by extraction or ultrafiltration," Renewable Energy, Elsevier, vol. 180(C), pages 213-221.
    11. Gollangi, Raju & K, NagamalleswaraRao, 2022. "Energy, exergy analysis of conceptually designed monochloromethane production process from hydrochlorination of methanol," Energy, Elsevier, vol. 239(PA).
    12. Nogueira, Tiago Rocha & de Mesquita Figueredo, Igor & Tavares Luna, Francisco Murilo & Cavalcante, Célio Loureiro & Evangelista de Ávila dos Santos, João & Sousa Lima, Mary Anne & Josino da Silva, Thi, 2020. "Evaluation of oxidative stability of soybean biodiesel using ethanolic and chloroform extracts of Platymiscium floribundum as antioxidant," Renewable Energy, Elsevier, vol. 159(C), pages 767-774.
    13. Xie, Wenlei & Li, Jiangbo, 2023. "Magnetic solid catalysts for sustainable and cleaner biodiesel production: A comprehensive review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 171(C).
    14. Ebadinezhad, Behzad & Haghighi, Mohammad & Zeinalzadeh, Hossein, 2022. "Carbon-templated meso-design of nanostructured CeAPSO-34 for biodiesel production from free fatty acid and waste oil," Renewable Energy, Elsevier, vol. 195(C), pages 716-733.
    15. Rokhum, Samuel Lalthazuala & Changmai, Bishwajit & Kress, Thomas & Wheatley, Andrew E.H., 2022. "A one-pot route to tunable sugar-derived sulfonated carbon catalysts for sustainable production of biodiesel by fatty acid esterification," Renewable Energy, Elsevier, vol. 184(C), pages 908-919.
    16. Khoobbakht, Golmohammad & Kheiralipour, Kamran & Yuan, Wenqiao & Seifi, Mohammad Reza & Karimi, Mahmoud, 2020. "Desirability function approach for optimization of enzymatic transesterification catalyzed by lipase immobilized on mesoporous magnetic nanoparticles," Renewable Energy, Elsevier, vol. 158(C), pages 253-262.
    17. Ebadinezhad, Behzad & Haghighi, Mohammad & Zeinalzadeh, Hossein, 2021. "Influence of carbon casting loading and ultrasound irradiation on catalytic design of Al–Si–P zeotype nanostructure for biofuel production," Renewable Energy, Elsevier, vol. 177(C), pages 290-307.
    18. Praveena, V. & Martin, Leenus Jesu & Matijošius, Jonas & Aloui, Fethi & Pugazhendhi, Arivalagan & Varuvel, Edwin Geo, 2024. "A systematic review on biofuel production and utilization from algae and waste feedstocks– a circular economy approach," Renewable and Sustainable Energy Reviews, Elsevier, vol. 192(C).
    19. Petchsoongsakul, Nattawat & Ngaosuwan, Kanokwan & Kiatkittipong, Worapon & Wongsawaeng, Doonyapong & Assabumrungrat, Suttichai, 2020. "Different water removal methods for facilitating biodiesel production from low-cost waste cooking oil containing high water content in hybridized reactive distillation," Renewable Energy, Elsevier, vol. 162(C), pages 1906-1918.
    20. Sergio Nogales-Delgado & Agustina Guiberteau Cabanillas & Juan Pedro Moro & José María Encinar Martín, 2023. "Use of Propyl Gallate in Cardoon Biodiesel to Keep Its Main Properties during Oxidation," Clean Technol., MDPI, vol. 5(2), pages 1-15, May.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:2:p:657-:d:1026498. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.