IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v310y2024ics0360544224030214.html
   My bibliography  Save this article

Scaling up magnetocaloric heat pump for building decarbonization initiatives

Author

Listed:
  • Liang, Jierong
  • Masche, Marvin
  • Wang, Kun
  • Sittig, Tim
  • Benke, Dimitri
  • Fries, Maximilian
  • Engelbrecht, Kurt
  • Bahl, Christian R.H.

Abstract

Building decarbonization necessitates renewable heating and cooling solutions such as heat pumps. Magnetocaloric heat pumps (MCHP) offer environmental and efficiency advantages but face challenges when scaling up from existing active magnetic regenerator configurations. This study highlights uneven flow resistance, porosity, and refrigerant magnetocaloric effects as key obstacles to MCHP performance in parallel multi-bed setups. To address these effects, two control strategies for the fluid flow control system were investigated: measurement feedback control and model predictive control. Results show a 36.9 % heating power improvement with measurement feedback control, though with extended control convergence times. Model predictive control achieved approximately seven times faster control convergence compared to the measurement feedback control strategy, despite exhibiting minor overshooting. Utilization factor-based model predictive control increased the heating capacity by 1.6 %–30.9 % and the COP by 1.2 %–10.7 % in scenarios with uneven flow resistance and porosity, offering computational efficiency but assuming even magnetocaloric effects between regenerators. This assumption can be addressed by outlet temperature-based model predictive control, albeit at a higher computational cost using genetic algorithm. The findings emphasize the importance of advanced control methods to scaling up MCHP in renewable energy building systems.

Suggested Citation

  • Liang, Jierong & Masche, Marvin & Wang, Kun & Sittig, Tim & Benke, Dimitri & Fries, Maximilian & Engelbrecht, Kurt & Bahl, Christian R.H., 2024. "Scaling up magnetocaloric heat pump for building decarbonization initiatives," Energy, Elsevier, vol. 310(C).
    • Handle: RePEc:eee:energy:v:310:y:2024:i:c:s0360544224030214
    DOI: 10.1016/j.energy.2024.133245
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544224030214
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2024.133245?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Kamran, Muhammad Sajid & Ahmad, Hafiz Ozair & Wang, Hua Sheng, 2020. "Review on the developments of active magnetic regenerator refrigerators – Evaluated by performance," Renewable and Sustainable Energy Reviews, Elsevier, vol. 133(C).
    2. Aprea, C. & Greco, A. & Maiorino, A. & Masselli, C., 2020. "The use of barocaloric effect for energy saving in a domestic refrigerator with ethylene-glycol based nanofluids: A numerical analysis and a comparison with a vapor compression cooler," Energy, Elsevier, vol. 190(C).
    3. Limei Shen & Xiao Tong & Liang Li & Yiliang Lv & Zeyu Liu & Junlong Xie, 2022. "Performance Simulation of the Active Magnetic Regenerator under a Pulsed Magnetic Field," Energies, MDPI, vol. 15(18), pages 1-13, September.
    4. Zhang, Yaokang & Wu, Jianghong & He, Jing & Wang, Kai & Yu, Guoxin, 2021. "Solutions to obstacles in the commercialization of room-temperature magnetic refrigeration," Renewable and Sustainable Energy Reviews, Elsevier, vol. 143(C).
    5. Romero Gómez, J. & Ferreiro Garcia, R. & Carbia Carril, J. & Romero Gómez, M., 2013. "A review of room temperature linear reciprocating magnetic refrigerators," Renewable and Sustainable Energy Reviews, Elsevier, vol. 21(C), pages 1-12.
    6. Mubarak Ismail & Metkel Yebiyo & Issa Chaer, 2021. "A Review of Recent Advances in Emerging Alternative Heating and Cooling Technologies," Energies, MDPI, vol. 14(2), pages 1-24, January.
    7. Ciro Aprea & Adriana Greco & Angelo Maiorino & Claudia Masselli, 2019. "Enhancing the Heat Transfer in an Active Barocaloric Cooling System Using Ethylene-Glycol Based Nanofluids as Secondary Medium," Energies, MDPI, vol. 12(15), pages 1-15, July.
    8. Meggers, Forrest & Ritter, Volker & Goffin, Philippe & Baetschmann, Marc & Leibundgut, Hansjürg, 2012. "Low exergy building systems implementation," Energy, Elsevier, vol. 41(1), pages 48-55.
    9. Araceli Aznar & Pol Lloveras & Michela Romanini & María Barrio & Josep-Lluís Tamarit & Claudio Cazorla & Daniel Errandonea & Neil D. Mathur & Antoni Planes & Xavier Moya & Lluís Mañosa, 2017. "Giant barocaloric effects over a wide temperature range in superionic conductor AgI," Nature Communications, Nature, vol. 8(1), pages 1-6, December.
    10. Klinar, K. & Kitanovski, A., 2020. "Thermal control elements for caloric energy conversion," Renewable and Sustainable Energy Reviews, Elsevier, vol. 118(C).
    11. Jaka Tušek & Kurt Engelbrecht & Dan Eriksen & Stefano Dall’Olio & Janez Tušek & Nini Pryds, 2016. "A regenerative elastocaloric heat pump," Nature Energy, Nature, vol. 1(10), pages 1-6, October.
    12. Aguilera, José Joaquín & Meesenburg, Wiebke & Markussen, Wiebke Brix & Zühlsdorf, Benjamin & Elmegaard, Brian, 2024. "Real-time monitoring and optimization of a large-scale heat pump prone to fouling - towards a digital twin framework," Applied Energy, Elsevier, vol. 365(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Luca Cirillo & Adriana Greco & Claudia Masselli, 2023. "A Solid-to-Solid 2D Model of a Magnetocaloric Cooler with Thermal Diodes: A Sustainable Way for Refrigerating," Energies, MDPI, vol. 16(13), pages 1-17, July.
    2. Chdil, O. & Bikerouin, M. & Balli, M. & Mounkachi, O., 2023. "New horizons in magnetic refrigeration using artificial intelligence," Applied Energy, Elsevier, vol. 335(C).
    3. Han, Yuan & Lai, Cong & Li, Jiarui & Zhang, Zhufeng & Zhang, Houcheng & Hou, Shujin & Wang, Fu & Zhao, Jiapei & Zhang, Chunfei & Miao, He & Yuan, Jinliang, 2022. "Elastocaloric cooler for waste heat recovery from proton exchange membrane fuel cells," Energy, Elsevier, vol. 238(PA).
    4. Dai, Zhaofeng & She, Xiaohui & Wang, Chen & Ding, Yulong & Li, Yongliang & Zhang, Xiaosong & Zhao, Dongliang, 2024. "Dynamic simulation and performance analysis of a solid-state barocaloric refrigeration system," Energy, Elsevier, vol. 294(C).
    5. Luca Cirillo & Adriana Greco & Claudia Masselli, 2023. "The Application of Barocaloric Solid-State Cooling in the Cold Food Chain for Carbon Footprint Reduction," Energies, MDPI, vol. 16(18), pages 1-17, September.
    6. Qingyong Ren & Ji Qi & Dehong Yu & Zhe Zhang & Ruiqi Song & Wenli Song & Bao Yuan & Tianhao Wang & Weijun Ren & Zhidong Zhang & Xin Tong & Bing Li, 2022. "Ultrasensitive barocaloric material for room-temperature solid-state refrigeration," Nature Communications, Nature, vol. 13(1), pages 1-9, December.
    7. Tan, Jianming & Wang, Yao & Xu, Shijie & Liu, Huaican & Qian, Suxin, 2020. "Thermodynamic cycle analysis of heat driven elastocaloric cooling system," Energy, Elsevier, vol. 197(C).
    8. Cai, Yuhao & Qian, Xin & Su, Ruihang & Jia, Xiongjie & Ying, Jinhui & Zhao, Tianshou & Jiang, Haoran, 2024. "Thermo-electrochemical modeling of thermally regenerative flow batteries," Applied Energy, Elsevier, vol. 355(C).
    9. Riccardo Fraboni & Gianluca Grazieschi & Simon Pezzutto & Benjamin Mitterrutzner & Eric Wilczynski, 2023. "Environmental Assessment of Residential Space Heating and Cooling Technologies in Europe: A Review of 11 European Member States," Sustainability, MDPI, vol. 15(5), pages 1-22, February.
    10. Žiga Ahčin & Parham Kabirifar & Luka Porenta & Miha Brojan & Jaka Tušek, 2022. "Numerical Modeling of Shell-and-Tube-like Elastocaloric Regenerator," Energies, MDPI, vol. 15(23), pages 1-28, December.
    11. Kristina Navickaitė & Michael Penzel & Christian Bahl & Kurt Engelbrecht & Jaka Tušek & André Martin & Mike Zinecker & Andreas Schubert, 2020. "CFD-Simulation Assisted Design of Elastocaloric Regenerator Geometry," Sustainability, MDPI, vol. 12(21), pages 1-16, October.
    12. Belen Moreno Santamaria & Fernando del Ama Gonzalo & Danielle Pinette & Roberto-Alonso Gonzalez-Lezcano & Benito Lauret Aguirregabiria & Juan A. Hernandez Ramos, 2020. "Application and Validation of a Dynamic Energy Simulation Tool: A Case Study with Water Flow Glazing Envelope," Energies, MDPI, vol. 13(12), pages 1-20, June.
    13. Li, Wei & Dai, Renkun & Zeng, Min & Wang, Qiuwang, 2020. "Review of two types of surface modification on pool boiling enhancement: Passive and active," Renewable and Sustainable Energy Reviews, Elsevier, vol. 130(C).
    14. Lu, Zhen & Huang, Yuewu & Zhao, Yonggang, 2023. "Elastocaloric cooler for waste heat recovery from perovskite solar cell with electricity and cooling production," Renewable Energy, Elsevier, vol. 215(C).
    15. Luo, Yongqiang & Zhang, Ling & Liu, Zhongbing & Wu, Jing & Zhang, Yelin & Wu, Zhenghong & He, Xihua, 2017. "Performance analysis of a self-adaptive building integrated photovoltaic thermoelectric wall system in hot summer and cold winter zone of China," Energy, Elsevier, vol. 140(P1), pages 584-600.
    16. Johra, Hicham & Filonenko, Konstantin & Heiselberg, Per & Veje, Christian & Dall’Olio, Stefano & Engelbrecht, Kurt & Bahl, Christian, 2019. "Integration of a magnetocaloric heat pump in an energy flexible residential building," Renewable Energy, Elsevier, vol. 136(C), pages 115-126.
    17. Adriana Greco & Claudia Masselli, 2020. "The Optimization of the Thermal Performances of an Earth to Air Heat Exchanger for an Air Conditioning System: A Numerical Study," Energies, MDPI, vol. 13(23), pages 1-25, December.
    18. Zhang, Yaokang & Wu, Jianghong & He, Jing & Wang, Kai & Yu, Guoxin, 2021. "Solutions to obstacles in the commercialization of room-temperature magnetic refrigeration," Renewable and Sustainable Energy Reviews, Elsevier, vol. 143(C).
    19. Luo, Dong & Feng, Yinshan & Verma, Parmesh, 2017. "Modeling and analysis of an integrated solid state elastocaloric heat pumping system," Energy, Elsevier, vol. 130(C), pages 500-514.
    20. Scarpa, Federico & Tagliafico, Giulio & Tagliafico, Luca A., 2015. "A classification methodology applied to existing room temperature magnetic refrigerators up to the year 2014," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 497-503.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:310:y:2024:i:c:s0360544224030214. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.