IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v93y2012icp215-228.html
   My bibliography  Save this article

The effect of firing biogas on the performance and operating characteristics of simple and recuperative cycle gas turbine combined heat and power systems

Author

Listed:
  • Kang, Do Won
  • Kim, Tong Seop
  • Hur, Kwang Beom
  • Park, Jung Keuk

Abstract

We investigated the influence of firing biogas on the performance and operating characteristics of gas turbines. Combined heat and power systems based on two different gas turbines (simple and recuperative cycle engines) in a similar power class were simulated. A full off-design analysis was performed to predict the variations in operations due to firing biogas instead of natural gas. A wide range of biogas compositions differing in CH4 content was simulated. Without consideration of operating restrictions on the compressor and turbine, using biogas was predicted to augment the power output in both engines. Power output increased as CH4 content decreased. The main reason is the increase in turbine power due to increased fuel flow. Gas turbine efficiency increased with decreasing CH4 content in the simple cycle engine, but decreased in the recuperative cycle engine. Net efficiency including the fuel compression power consumption decreased with decreasing CH4 content even in the simple cycle engine. The heat recovery also increased by firing biogas. However, the increased turbine flow was accompanied by a surge margin reduction of the compressor and overheating of the turbine blade. These two problems were more severe in simple cycle gas turbines and as the ambient temperature increased. The turbine blade temperature and the compressor surge margin could be recovered to the reference values by either under-firing or compressor air bleeding, which are effective for blade temperature control and surge margin control, respectively. However, satisfaction of both restrictions by a single modulation caused excessive power and efficiency losses. An optimal combination between under-firing and air bleeding would minimize the performance penalty.

Suggested Citation

  • Kang, Do Won & Kim, Tong Seop & Hur, Kwang Beom & Park, Jung Keuk, 2012. "The effect of firing biogas on the performance and operating characteristics of simple and recuperative cycle gas turbine combined heat and power systems," Applied Energy, Elsevier, vol. 93(C), pages 215-228.
    • Handle: RePEc:eee:appene:v:93:y:2012:i:c:p:215-228
    DOI: 10.1016/j.apenergy.2011.12.038
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261911008348
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2011.12.038?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Lee, Jong Jun & Kim, Young Sik & Cha, Kyu Sang & Kim, Tong Seop & Sohn, Jeong L. & Joo, Yong Jin, 2009. "Influence of system integration options on the performance of an integrated gasification combined cycle power plant," Applied Energy, Elsevier, vol. 86(9), pages 1788-1796, September.
    2. Gupta, K.K. & Rehman, A. & Sarviya, R.M., 2010. "Bio-fuels for the gas turbine: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(9), pages 2946-2955, December.
    3. Bruno, Joan Carles & Ortega-López, Víctor & Coronas, Alberto, 2009. "Integration of absorption cooling systems into micro gas turbine trigeneration systems using biogas: Case study of a sewage treatment plant," Applied Energy, Elsevier, vol. 86(6), pages 837-847, June.
    4. Rasi, S. & Veijanen, A. & Rintala, J., 2007. "Trace compounds of biogas from different biogas production plants," Energy, Elsevier, vol. 32(8), pages 1375-1380.
    5. Rodrigues, Monica & Walter, Arnaldo & Faaij, André, 2003. "Co-firing of natural gas and Biomass gas in biomass integrated gasification/combined cycle systems," Energy, Elsevier, vol. 28(11), pages 1115-1131.
    6. Bhattacharya, Abhishek & Manna, Dulal & Paul, Bireswar & Datta, Amitava, 2011. "Biomass integrated gasification combined cycle power generation with supplementary biomass firing: Energy and exergy based performance analysis," Energy, Elsevier, vol. 36(5), pages 2599-2610.
    7. Lee, Jong Jun & Jeon, Mu Sung & Kim, Tong Seop, 2010. "The influence of water and steam injection on the performance of a recuperated cycle microturbine for combined heat and power application," Applied Energy, Elsevier, vol. 87(4), pages 1307-1316, April.
    8. Mueller, Steffen, 2007. "Manure's allure: Variation of the financial, environmental, and economic benefits from combined heat and power systems integrated with anaerobic digesters at hog farms across geographic and economic r," Renewable Energy, Elsevier, vol. 32(2), pages 248-256.
    9. Gnanapragasam, Nirmal V. & Reddy, Bale V. & Rosen, Marc A., 2009. "Optimum conditions for a natural gas combined cycle power generation system based on available oxygen when using biomass as supplementary fuel," Energy, Elsevier, vol. 34(6), pages 816-826.
    10. Kim, Young Sik & Lee, Jong Jun & Kim, Tong Seop & Sohn, Jeong L. & Joo, Yong Jin, 2010. "Performance analysis of a syngas-fed gas turbine considering the operating limitations of its components," Applied Energy, Elsevier, vol. 87(5), pages 1602-1611, May.
    11. Tricase, C. & Lombardi, M., 2009. "State of the art and prospects of Italian biogas production from animal sewage: Technical-economic considerations," Renewable Energy, Elsevier, vol. 34(3), pages 477-485.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Park, Yeseul & Choi, Minsung & Choi, Gyungmin, 2022. "Fault detection of industrial large-scale gas turbine for fuel distribution characteristics in start-up procedure using artificial neural network method," Energy, Elsevier, vol. 251(C).
    2. Kang, Do Won & Jang, Hyuck Jun & Kim, Tong Seop, 2014. "Using compressor discharge air bypass to enhance power generation of a steam-injected gas turbine for combined heat and power," Energy, Elsevier, vol. 76(C), pages 390-399.
    3. Ayşe Fidan Altun, 2022. "A Conceptual Design and Analysis of a Novel Trigeneration System Consisting of a Gas Turbine Power Cycle with Intercooling, Ammonia–Water Absorption Refrigeration, and Hot Water Production," Sustainability, MDPI, vol. 14(19), pages 1-22, September.
    4. Park, Yeseul & Choi, Minsung & Kim, Kibeom & Li, Xinzhuo & Jung, Chanho & Na, Sangkyung & Choi, Gyungmin, 2020. "Prediction of operating characteristics for industrial gas turbine combustor using an optimized artificial neural network," Energy, Elsevier, vol. 213(C).
    5. Heydari, Ali & Askarzadeh, Alireza, 2016. "Optimization of a biomass-based photovoltaic power plant for an off-grid application subject to loss of power supply probability concept," Applied Energy, Elsevier, vol. 165(C), pages 601-611.
    6. Stolecka, Katarzyna & Rusin, Andrzej, 2021. "Potential hazards posed by biogas plants," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    7. Kang, Jun Young & Kang, Do Won & Kim, Tong Seop & Hur, Kwang Beom, 2014. "Comparative economic analysis of gas turbine-based power generation and combined heat and power systems using biogas fuel," Energy, Elsevier, vol. 67(C), pages 309-318.
    8. Verstraete, Dries & Bowkett, Carlos, 2015. "Impact of heat transfer on the performance of micro gas turbines," Applied Energy, Elsevier, vol. 138(C), pages 445-449.
    9. Parisa Kazemiani-Najafabadi & Ehsan Amiri Rad, 2020. "Optimizing the bio/natural gas ratio in a dual-fuel gas turbine (DFGT) through energy-economic, environmental, and renewability analyses," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 22(6), pages 5371-5386, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Parisa Kazemiani-Najafabadi & Ehsan Amiri Rad, 2020. "Optimizing the bio/natural gas ratio in a dual-fuel gas turbine (DFGT) through energy-economic, environmental, and renewability analyses," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 22(6), pages 5371-5386, August.
    2. Soltani, S. & Yari, M. & Mahmoudi, S.M.S. & Morosuk, T. & Rosen, M.A., 2013. "Advanced exergy analysis applied to an externally-fired combined-cycle power plant integrated with a biomass gasification unit," Energy, Elsevier, vol. 59(C), pages 775-780.
    3. Kang, Jun Young & Kang, Do Won & Kim, Tong Seop & Hur, Kwang Beom, 2014. "Comparative economic analysis of gas turbine-based power generation and combined heat and power systems using biogas fuel," Energy, Elsevier, vol. 67(C), pages 309-318.
    4. Lee, Jong Jun & Kang, Do Won & Kim, Tong Seop, 2011. "Development of a gas turbine performance analysis program and its application," Energy, Elsevier, vol. 36(8), pages 5274-5285.
    5. Moioli, Stefania & Giuffrida, Antonio & Romano, Matteo C. & Pellegrini, Laura A. & Lozza, Giovanni, 2016. "Assessment of MDEA absorption process for sequential H2S removal and CO2 capture in air-blown IGCC plants," Applied Energy, Elsevier, vol. 183(C), pages 1452-1470.
    6. Saeed Soltani & Hassan Athari & Marc A. Rosen & Seyed Mohammad Seyed Mahmoudi & Tatiana Morosuk, 2015. "Thermodynamic Analyses of Biomass Gasification Integrated Externally Fired, Post-Firing and Dual-Fuel Combined Cycles," Sustainability, MDPI, vol. 7(2), pages 1-15, January.
    7. Lee, Adrian J. & Diwekar, Urmila M., 2012. "Optimal sensor placement in integrated gasification combined cycle power systems," Applied Energy, Elsevier, vol. 99(C), pages 255-264.
    8. Athari, Hassan & Soltani, Saeed & Rosen, Marc A. & Seyed Mahmoudi, Seyed Mohammad & Morosuk, Tatiana, 2016. "Gas turbine steam injection and combined power cycles using fog inlet cooling and biomass fuel: A thermodynamic assessment," Renewable Energy, Elsevier, vol. 92(C), pages 95-103.
    9. Zare, A. Darabadi & Saray, R. Khoshbakhti & Mirmasoumi, S. & Bahlouli, K., 2019. "Optimization strategies for mixing ratio of biogas and natural gas co-firing in a cogeneration of heat and power cycle," Energy, Elsevier, vol. 181(C), pages 635-644.
    10. Song, Guohui & Xiao, Jun & Yan, Chao & Gu, Haiming & Zhao, Hao, 2022. "Quality of gaseous biofuels: Statistical assessment and guidance on production technologies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 169(C).
    11. Konečná, Eva & Teng, Sin Yong & Máša, Vítězslav, 2020. "New insights into the potential of the gas microturbine in microgrids and industrial applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).
    12. Stanislaw Siatkowski & Krzysztof Wacko & Jan Kindracki, 2021. "Experimental Research on Detonation Cell Size of a Purified Biogas-Oxygen Mixture," Energies, MDPI, vol. 14(20), pages 1-13, October.
    13. Kim, Young Sik & Park, Sung Ku & Lee, Jong Jun & Kang, Do Won & Kim, Tong Seop, 2013. "Analysis of the impact of gas turbine modifications in integrated gasification combined cycle power plants," Energy, Elsevier, vol. 55(C), pages 977-986.
    14. Athari, Hassan & Soltani, Saeed & Rosen, Marc A. & Gavifekr, Masood Kordoghli & Morosuk, Tatiana, 2016. "Exergoeconomic study of gas turbine steam injection and combined power cycles using fog inlet cooling and biomass fuel," Renewable Energy, Elsevier, vol. 96(PA), pages 715-726.
    15. Chacartegui, R. & Sánchez, D. & Muñoz de Escalona, J.M. & Muñoz, A. & Sánchez, T., 2013. "Gas and steam combined cycles for low calorific syngas fuels utilisation," Applied Energy, Elsevier, vol. 101(C), pages 81-92.
    16. Park, Sung Ku & Ahn, Ji-Ho & Kim, Tong Seop, 2011. "Performance evaluation of integrated gasification solid oxide fuel cell/gas turbine systems including carbon dioxide capture," Applied Energy, Elsevier, vol. 88(9), pages 2976-2987.
    17. Kang, Do Won & Jang, Hyuck Jun & Kim, Tong Seop, 2014. "Using compressor discharge air bypass to enhance power generation of a steam-injected gas turbine for combined heat and power," Energy, Elsevier, vol. 76(C), pages 390-399.
    18. Giuffrida, Antonio & Romano, Matteo C. & Lozza, Giovanni G., 2010. "Thermodynamic assessment of IGCC power plants with hot fuel gas desulfurization," Applied Energy, Elsevier, vol. 87(11), pages 3374-3383, November.
    19. Nakata, Toshihiko & Sato, Takemi & Wang, Hao & Kusunoki, Tomoya & Furubayashi, Takaaki, 2011. "Modeling technological learning and its application for clean coal technologies in Japan," Applied Energy, Elsevier, vol. 88(1), pages 330-336, January.
    20. Pöschl, Martina & Ward, Shane & Owende, Philip, 2010. "Evaluation of energy efficiency of various biogas production and utilization pathways," Applied Energy, Elsevier, vol. 87(11), pages 3305-3321, November.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:93:y:2012:i:c:p:215-228. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.