IDEAS home Printed from https://ideas.repec.org/a/gam/jsusta/v15y2023i4p3712-d1071743.html
   My bibliography  Save this article

Reducing Emitter Clogging in Drip Fertigation Systems by Magnetization Technology

Author

Listed:
  • Kaili Shi

    (Intelligent Equipment Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China)

  • Lili Zhangzhong

    (Intelligent Equipment Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China)

  • Furong Han

    (College of Horticulture, Shanxi Agricultural University, Taiyuan 030801, China)

  • Shirui Zhang

    (Intelligent Equipment Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China)

  • Rui Guo

    (Intelligent Equipment Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing 100097, China)

  • Xueying Yao

    (College of Plant Science and Technology, Huazhong Agricultural University, Wuhan 430070, China)

Abstract

The issue of emitter clogging is a common phenomenon in drip fertigation systems, which causes uneven irrigation and fertilization. However, efficient and environmentally friendly methods are scarcely available for alleviating clogging. In the present study, we investigated the anti-fouling efficacy of three magnetic field strength levels (0, 0.4 T and 0.6 T) on emitter clogging in drip fertigation systems. Our results show that magnetized water treatment could effectively relieve emitter clogging and delay the occurrence time of clogging, which increased the average discharge variation rate (Dra) by 37.00–61.64% and decreased the dry weight (DW) by 53.00–69.29% compared with non-magnetized water treatments. X-rays were used to estimate the compositions of the main clogging substances, and the results show that phosphates were the dominant substances that induced emitter clogging. In addition, magnetized water treatment effectively reduced the contents of chemical and particulate fouling, as exhibited by a decrease in phosphates, silicate and quartz by 53.17–69.58%, 47.22–61.95% and 43.18–74.80%, respectively. In comparison, the higher strength of magnetized water treatment (0.6 T) was better in clogging control, which increased Dra and the Christiansen of uniformity (CU) by 24.64% and 43.96%, respectively, and the DW was reduced by 34.67% compared with that of 0.4 T. This study proves that magnetized water treatment is an effective, chemical-free treatment method with great potential for fouling control technology, and it is helpful for the further promotion of drip fertigation technology.

Suggested Citation

  • Kaili Shi & Lili Zhangzhong & Furong Han & Shirui Zhang & Rui Guo & Xueying Yao, 2023. "Reducing Emitter Clogging in Drip Fertigation Systems by Magnetization Technology," Sustainability, MDPI, vol. 15(4), pages 1-11, February.
    • Handle: RePEc:gam:jsusta:v:15:y:2023:i:4:p:3712-:d:1071743
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2071-1050/15/4/3712/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2071-1050/15/4/3712/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Al-Ogaidi, Ahmed A.M. & Wayayok, Aimrun & Rowshon, M.K. & Abdullah, Ahmad Fikri, 2017. "The influence of magnetized water on soil water dynamics under drip irrigation systems," Agricultural Water Management, Elsevier, vol. 180(PA), pages 70-77.
    2. Li, Yunkai & Pan, Jiachong & Chen, Xiuzhi & Xue, Song & Feng, Ji & Muhammad, Tahir & Zhou, Bo, 2019. "Dynamic effects of chemical precipitates on drip irrigation system clogging using water with high sediment and salt loads," Agricultural Water Management, Elsevier, vol. 213(C), pages 833-842.
    3. Oweis, T.Y. & Farahani, H.J. & Hachum, A.Y., 2011. "Evapotranspiration and water use of full and deficit irrigated cotton in the Mediterranean environment in northern Syria," Agricultural Water Management, Elsevier, vol. 98(8), pages 1239-1248, May.
    4. M., Jayakumar & S., Janapriya & U., Surendran, 2017. "Effect of drip fertigation and polythene mulching on growth and productivity of coconut (Cocos nucifera L.), water, nutrient use efficiency and economic benefits," Agricultural Water Management, Elsevier, vol. 182(C), pages 87-93.
    5. Wu, Dali & Xu, Xinxing & Chen, Yanling & Shao, Hui & Sokolowski, Eldad & Mi, Guohua, 2019. "Effect of different drip fertigation methods on maize yield, nutrient and water productivity in two-soils in Northeast China," Agricultural Water Management, Elsevier, vol. 213(C), pages 200-211.
    6. Bucks, D. A. & Nakayama, F. S. & Gilbert, R. G., 1979. "Trickle irrigation water quality and preventive maintenance," Agricultural Water Management, Elsevier, vol. 2(2), pages 149-162, June.
    7. Muhammad, Tahir & Zhou, Bo & Liu, Zeyuan & Chen, Xiuzhi & Li, Yunkai, 2021. "Effects of phosphorus-fertigation on emitter clogging in drip irrigation system with saline water," Agricultural Water Management, Elsevier, vol. 243(C).
    8. Kaili Shi & Tiangang Lu & Wengang Zheng & Xin Zhang & Lili Zhangzhong, 2022. "A Review of the Category, Mechanism, and Controlling Methods of Chemical Clogging in Drip Irrigation System," Agriculture, MDPI, vol. 12(2), pages 1-20, January.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Petit, Julien & García, Sílvia Mas & Molle, Bruno & Bendoula, Ryad & Ait-Mouheb, Nassim, 2022. "Methods for drip irrigation clogging detection, analysis and understanding: State of the art and perspectives," Agricultural Water Management, Elsevier, vol. 272(C).
    2. Hou, Peng & Xiao, Yang & Muhammad, Tahir & Zhou, Bo & Song, Peng & Zhou, Yunpeng & Han, Siqi & Wen, Jiaxin & Li, Yunkai, 2023. "Multi-factorial failure of pressure-compensating emitters in drip fertigation systems: An in-situ sampling investigation," Agricultural Water Management, Elsevier, vol. 275(C).
    3. Muhammad, Tahir & Zhou, Bo & Puig-Bargu´es, Jaume & Ding, Can & Li, Shuqin & Manan, Irum & Zhou, Yunpeng & Liu, Zeyuan & Li, Yunkai, 2022. "Assessment of emitter clogging with multiple fouling and root intrusion in sub-surface drip irrigation during 5-year sugarcane growth," Agricultural Water Management, Elsevier, vol. 274(C).
    4. Wang, Yayu & Muhammad, Tahir & Liu, Zeyuan & Liang, Hongbang & Wang, Xingpeng & Wang, Zhenhua & Ma, Changjian & Li, Yunkai, 2022. "Chelated copper reduces yet manganese fertilizer increases calcium-silica fouling in brackish water drip irrigation systems," Agricultural Water Management, Elsevier, vol. 269(C).
    5. Ma, Changjian & Li, Mengyao & Hou, Peng & Wang, Xuejun & Sun, Zeqiang & Li, Yan & Xiao, Yang & Li, Yunkai, 2024. "Biofilm dynamic changes in drip irrigation emitter flow channels using reclaimed water," Agricultural Water Management, Elsevier, vol. 291(C).
    6. Wang, Yayu & Puig-Bargués, Jaume & Ma, Changjian & Xiao, Yang & Maitusong, Memetmin & Li, Yunkai, 2024. "Influence and selection of nitrogen and phosphorus compound fertilizers on emitter clogging using brackish water in drip irrigation systems," Agricultural Water Management, Elsevier, vol. 291(C).
    7. Liu, Zeyuan & Ma, Changjian & Xiao, Yang & Lili, Zhangzhong & Muhammad, Tahir & Li, Yunkai, 2023. "Application of chelated fertilizers to mitigate organic-inorganic fouling in brackish water drip irrigation systems," Agricultural Water Management, Elsevier, vol. 285(C).
    8. Liu, Zeyuan & Muhammad, Tahir & Puig-Bargués, Jaume & Han, Siqi & Ma, Yongjiu & Li, Yunkai, 2021. "Horizontal roughing filter for reducing emitter composite clogging in drip irrigation systems using high sediment water," Agricultural Water Management, Elsevier, vol. 258(C).
    9. Muhammad, Tahir & Xiao, Yang & Puig-Bargués, Jaume & Liu, Wenchao & Liu, Zeyuan & Chen, Xiuzhi & Li, Yunkai, 2021. "Effects of coupling multiple factors on CaCO3 fouling in agricultural saline water distribution systems," Agricultural Water Management, Elsevier, vol. 248(C).
    10. Hou, Peng & Ma, Changjian & Wang, Jia & Li, Yan & Zhang, Kai & Hou, Shance & Li, Jingzhi & Sun, Zeqiang & Xiao, Yang & Li, Yunkai, 2024. "Failure behavior of pressure compensating emitter under different operation pressures in drip irrigation systems," Agricultural Water Management, Elsevier, vol. 297(C).
    11. Wang, Yayu & Muhammad, Tahir & Liu, Zeyuan & Ma, Changjian & Zhang, Changsheng & Wang, Zhenhua & He, Xin & Li, Yunkai, 2022. "Compounding with humic acid improved nutrient uniformity in drip fertigation system using brackish water: The perspective of emitter clogging," Agricultural Water Management, Elsevier, vol. 269(C).
    12. Wang, Yayu & Xiao, Yang & Puig-Bargués, Jaume & Zhou, Bo & Liu, Zeyuan & Muhammad, Tahir & Liang, Hongbang & Maitusong, Memetmin & Wang, Zhenhua & Li, Yunkai, 2023. "Assessment of water quality ions in brackish water on drip irrigation system performance applied in saline areas," Agricultural Water Management, Elsevier, vol. 289(C).
    13. Liu, Chunye & Wang, Rui & Wang, Wene & Hu, Xiaotao & Cheng, Yong & Liu, Fulai, 2021. "Effect of fertilizer solution concentrations on filter clogging in drip fertigation systems," Agricultural Water Management, Elsevier, vol. 250(C).
    14. Chen, Lijun & Liu, Jingze & Guo, Fukang & Jing, Song & Chu, Boyu & Qu, Yuncan & Li, Wen & Zhang, Jiyu, 2024. "The impact of drip irrigation and phosphorus fertilizer on enhancing dimorphic seed production of Lespedeza potaninii in Northwest China," Agricultural Water Management, Elsevier, vol. 299(C).
    15. Puig-Bargués, J. & Arbat, G. & Elbana, M. & Duran-Ros, M. & Barragán, J. & de Cartagena, F. Ramírez & Lamm, F.R., 2010. "Effect of flushing frequency on emitter clogging in microirrigation with effluents," Agricultural Water Management, Elsevier, vol. 97(6), pages 883-891, June.
    16. Bai, Zhentao & Bai, Wenqiang & Xie, Cong & Yu, Jiang & Dai, Yulong & Pei, Shengzhao & Zhang, Fucang & Li, Yunxia & Fan, Junliang & Yin, Feihu, 2023. "Irrigation depth and nitrogen rate effects on seed cotton yield, fiber quality and water-nitrogen utilization efficiency in southern Xinjiang, China," Agricultural Water Management, Elsevier, vol. 290(C).
    17. Eric Njuki & Boris E. Bravo-Ureta, 2019. "Examining irrigation productivity in U.S. agriculture using a single-factor approach," Journal of Productivity Analysis, Springer, vol. 51(2), pages 125-136, June.
    18. Fan, Yubing & Wang, Chenggang & Nan, Zhibiao, 2014. "Comparative evaluation of crop water use efficiency, economic analysis and net household profit simulation in arid Northwest China," Agricultural Water Management, Elsevier, vol. 146(C), pages 335-345.
    19. Li, Haoru & Li, Xiaoli & Mei, Xurong & Nangia, Vinay & Guo, Rui & Hao, Weiping & Wang, Jiandong, 2023. "An alternative water-fertilizer-saving management practice for wheat-maize cropping system in the North China Plain: Based on a 4-year field study," Agricultural Water Management, Elsevier, vol. 276(C).
    20. Wang, Jingwei & Li, Yuan & Niu, Wenquan, 2021. "Effect of alternating drip irrigation on soil gas emissions, microbial community composition, and root–soil interactions," Agricultural Water Management, Elsevier, vol. 256(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jsusta:v:15:y:2023:i:4:p:3712-:d:1071743. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.