IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v15y2022i19p7033-d924478.html
   My bibliography  Save this article

Utilization of Basalt Dust as Waste Material in Cement Grouts for Geothermal Application

Author

Listed:
  • Krzysztof Seńczuk

    (Doctoral School, AGH University of Science and Technology in Krakow, Adama Mickiewicza 30 Avenue, 30-059 Kraków, Poland)

  • Aneta Sapińska-Śliwa

    (Laboratory of Geoenergetics, AGH University of Science and Technology in Krakow, al. Adama Mickiewicza 30, 30-059 Kraków, Poland)

  • Tomasz Kowalski

    (Laboratory of Geoenergetics, AGH University of Science and Technology in Krakow, al. Adama Mickiewicza 30, 30-059 Kraków, Poland)

Abstract

Research on the utilization of the Earth’s heat focuses mainly on effective sourcing of energy accumulated in rock mass. One of the most important parameters is thermal conductivity, which can be modified using various compositions of cement grouts. Hardened cement slurry is intended to improve thermal conductivity. It should function as a sort of extension of the rock mass to the outer diameter of heat exchanger tubes. Regardless of the thermal conductivity of the rock, high conductivity of the grout increases the energy efficiency of the BHE. Heat accumulated in the rock mass can be extracted using borehole heat exchangers (BHE), in which high thermal conductivity of cement slurry is wanted over the entire length of the exchanger. Generally, in case of deep borehole heat exchangers (DBHE), it is recommended to use two types of cement slurry, one with reduced thermal conductivity in the upper part of the exchanger and grout with increased thermal conductivity in its lower part. When cementing geothermal wells, cement grout with decreased thermal conductivity along the entire length of the borehole is most commonly used. Geothermal boreholes extract geothermal water which, at the surface, is used for heating, for example. Then, after use, the cooled water is injected through injection holes. In this article, two different basalt dusts are examined. These dusts were obtained by crushing basalt boulders in open-pit mines. They were examined for their effect on thermal conductivity when added to grout. According to the Polish Ordinance of the Minister of Environment dated 9 December 2014 regarding the waste catalogue, they were classified as waste. The materials, named basalt dust A and basalt dust B, were used to create cement slurries with a water–cement ratio of 0.5–0.7 with a wide range of percentage concentration of basalt dust. The test results show that as concentrations in the slurry increase, the values of thermal conductivity and strength decrease. This correlation occurred for both tested additives.

Suggested Citation

  • Krzysztof Seńczuk & Aneta Sapińska-Śliwa & Tomasz Kowalski, 2022. "Utilization of Basalt Dust as Waste Material in Cement Grouts for Geothermal Application," Energies, MDPI, vol. 15(19), pages 1-30, September.
    • Handle: RePEc:gam:jeners:v:15:y:2022:i:19:p:7033-:d:924478
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/15/19/7033/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/15/19/7033/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Luca Alberti & Adriana Angelotti & Matteo Antelmi & Ivana La Licata, 2017. "A Numerical Study on the Impact of Grouting Material on Borehole Heat Exchangers Performance in Aquifers," Energies, MDPI, vol. 10(5), pages 1-15, May.
    2. Ilayda Berktas & Ali Nejad Ghafar & Patrick Fontana & Ayten Caputcu & Yusuf Menceloglu & Burcu Saner Okan, 2020. "Synergistic Effect of Expanded Graphite-Silane Functionalized Silica as a Hybrid Additive in Improving the Thermal Conductivity of Cementitious Grouts with Controllable Water Uptake," Energies, MDPI, vol. 13(14), pages 1-15, July.
    3. Blázquez, Cristina Sáez & Martín, Arturo Farfán & Nieto, Ignacio Martín & García, Pedro Carrasco & Sánchez Pérez, Luis Santiago & González-Aguilera, Diego, 2017. "Analysis and study of different grouting materials in vertical geothermal closed-loop systems," Renewable Energy, Elsevier, vol. 114(PB), pages 1189-1200.
    4. Marcin Kremieniewski, 2020. "Recipe of Lightweight Slurry with High Early Strength of the Resultant Cement Sheath," Energies, MDPI, vol. 13(7), pages 1-13, April.
    5. Tingting Luo & Peng Pei & Yixia Chen & Dingyi Hao & Chen Wang, 2022. "Improvements in the Water Retention Characteristics and Thermophysical Parameters of Backfill Material in Ground Source Heat Pumps by a Molecular Sieve," Energies, MDPI, vol. 15(5), pages 1-15, February.
    6. Marcin Kremieniewski, 2022. "Influence of Hblock Fine-Grained Material on Selected Parameters of Cement Slurry," Energies, MDPI, vol. 15(8), pages 1-20, April.
    7. Tomasz Sliwa & Tomasz Kowalski & Dominik Cekus & Aneta Sapińska-Śliwa, 2021. "Research on Fresh and Hardened Sealing Slurries with the Addition of Magnesium Regarding Thermal Conductivity for Energy Piles and Borehole Heat Exchangers," Energies, MDPI, vol. 14(16), pages 1-13, August.
    8. Guokun Yang & Tianle Liu & Hai Zhu & Zihan Zhang & Yingtao Feng & Ekaterina Leusheva & Valentin Morenov, 2022. "Heat Control Effect of Phase Change Microcapsules upon Cement Slurry Applied to Hydrate-Bearing Sediment," Energies, MDPI, vol. 15(12), pages 1-21, June.
    9. Zhu, Yalin & Qin, Yaosong & Liang, Shuen & Chen, Keping & Tian, Chunrong & Wang, Jianhua & Luo, Xuan & Zhang, Lin, 2019. "Graphene/SiO2/n-octadecane nanoencapsulated phase change material with flower like morphology, high thermal conductivity, and suppressed supercooling," Applied Energy, Elsevier, vol. 250(C), pages 98-108.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Luka Boban & Dino Miše & Stjepan Herceg & Vladimir Soldo, 2021. "Application and Design Aspects of Ground Heat Exchangers," Energies, MDPI, vol. 14(8), pages 1-31, April.
    2. Marcin Kremieniewski, 2022. "Improving the Efficiency of Oil Recovery in Research and Development," Energies, MDPI, vol. 15(12), pages 1-7, June.
    3. Tomasz Sliwa & Tomasz Kowalski & Dominik Cekus & Aneta Sapińska-Śliwa, 2021. "Research on Fresh and Hardened Sealing Slurries with the Addition of Magnesium Regarding Thermal Conductivity for Energy Piles and Borehole Heat Exchangers," Energies, MDPI, vol. 14(16), pages 1-13, August.
    4. Stanisław Stryczek & Andrzej Gonet & Marcin Kremieniewski, 2022. "Special Cement Slurries for Strengthening Salt Rock Mass," Energies, MDPI, vol. 15(16), pages 1-10, August.
    5. Zhang, Pengfei & Wang, Yilin & Qiu, Yu & Yan, Hongjie & Wang, Zhaolong & Li, Qing, 2024. "Novel composite phase change materials supported by oriented carbon fibers for solar thermal energy conversion and storage," Applied Energy, Elsevier, vol. 358(C).
    6. Liang, Yuntao & Wang, Ting & He, Zhenglong & Sun, Yong & Song, Shuanglin & Cui, Xinfeng & Cao, Yingjiazi, 2023. "High thermal storage capacity phase change microcapsules for heat transfer enhancement through hydroxylated-silanized nano-silicon carbide," Energy, Elsevier, vol. 285(C).
    7. Ana Vieira & Maria Alberdi-Pagola & Paul Christodoulides & Saqib Javed & Fleur Loveridge & Frederic Nguyen & Francesco Cecinato & João Maranha & Georgios Florides & Iulia Prodan & Gust Van Lysebetten , 2017. "Characterisation of Ground Thermal and Thermo-Mechanical Behaviour for Shallow Geothermal Energy Applications," Energies, MDPI, vol. 10(12), pages 1-51, December.
    8. Joanna Piotrowska-Woroniak, 2021. "Assessment of Ground Regeneration around Borehole Heat Exchangers between Heating Seasons in Cold Climates: A Case Study in Bialystok (NE, Poland)," Energies, MDPI, vol. 14(16), pages 1-32, August.
    9. Daehoon Kim & Seokhoon Oh, 2018. "Optimizing the Design of a Vertical Ground Heat Exchanger: Measurement of the Thermal Properties of Bentonite-Based Grout and Numerical Analysis," Sustainability, MDPI, vol. 10(8), pages 1-15, July.
    10. Hossein Javadi & Seyed Soheil Mousavi Ajarostaghi & Marc A. Rosen & Mohsen Pourfallah, 2018. "A Comprehensive Review of Backfill Materials and Their Effects on Ground Heat Exchanger Performance," Sustainability, MDPI, vol. 10(12), pages 1-22, November.
    11. Esmaeilpour, Morteza & Gholami Korzani, Maziar & Kohl, Thomas, 2022. "Impact of thermosiphoning on long-term behavior of closed-loop deep geothermal systems for sustainable energy exploitation," Renewable Energy, Elsevier, vol. 194(C), pages 1247-1260.
    12. Li, Jiyan & Long, Yong & Jing, Yanju & Zhang, Jiaqing & Du, Silu & Jiao, Rui & Sun, Hanxue & Zhu, Zhaoqi & Liang, Weidong & Li, An, 2024. "Superhydrophobic multi-shell hollow microsphere confined phase change materials for solar photothermal conversion and energy storage," Applied Energy, Elsevier, vol. 365(C).
    13. Claudia Naldi & Enzo Zanchini, 2019. "Full-Time-Scale Fluid-to-Ground Thermal Response of a Borefield with Uniform Fluid Temperature," Energies, MDPI, vol. 12(19), pages 1-18, September.
    14. Marcin Kremieniewski & Miłosz Kędzierski & Sławomir Błaż, 2021. "Increasing the Efficiency of Sealing the Borehole in Terms of Spacer Pumping Time," Energies, MDPI, vol. 14(20), pages 1-11, October.
    15. Andrzej Gonet & Stanisław Stryczek & Marcin Kremieniewski, 2022. "Modern Methods of Strengthening and Sealing Salt Mines," Energies, MDPI, vol. 15(14), pages 1-12, July.
    16. Stanisław Stryczek & Andrzej Gonet & Marcin Kremieniewski & Tomasz Kowalski, 2023. "Forecasting Strength Parameters of Hardened Geopolymer Slurries Applied to Seal Casing Columns in Boreholes," Energies, MDPI, vol. 16(11), pages 1-16, May.
    17. Khaled Salhein & C. J. Kobus & Mohamed Zohdy, 2022. "Control of Heat Transfer in a Vertical Ground Heat Exchanger for a Geothermal Heat Pump System," Energies, MDPI, vol. 15(14), pages 1-24, July.
    18. Ran, Fengming & Chen, Yunkang & Cong, Rongshuai & Fang, Guiyin, 2020. "Flow and heat transfer characteristics of microencapsulated phase change slurry in thermal energy systems: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).
    19. Wang, Zhaoyu & Feng, Weijian & Zhang, Nan & Zhang, Jinghong & Li, Qi & Wang, Weida & Rui, Chaofeng & Wang, Mao & Tang, Junjie & Zheng, Dechen, 2024. "Experimental study on enhanced heat transfer mechanism of U-shaped buried pipe by bio-microbial method," Renewable Energy, Elsevier, vol. 224(C).
    20. Xu, Bin & Gan, Wen-tao & Wang, Yang-liang & Chen, Xing-ni & Fei, Yue & Pei, Gang, 2023. "Thermal performance of a novel Trombe wall integrated with direct absorption solar collector based on phase change slurry in winter," Renewable Energy, Elsevier, vol. 213(C), pages 246-258.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:15:y:2022:i:19:p:7033-:d:924478. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.