IDEAS home Printed from https://ideas.repec.org/a/eee/rensus/v189y2024ipbs1364032123008912.html
   My bibliography  Save this article

Influence of pre-treatment of straw biomass and additives on the release of nitrogen species during combustion and gasification

Author

Listed:
  • Lebendig, Florian
  • Schmid, Daniel
  • Karlström, Oskar
  • Yrjas, Patrik
  • Müller, Michael

Abstract

The aim of this study is to investigate how pre-treatment of herbaceous straw biomass for ash control affects the release of nitrogen species during combustion and gasification. To comprehend the formation of NO and its precursors, NH3 and HCN, the release of these species was investigated and compared under both combustion and gasification-like conditions at 950 °C. The effects of various upgrading methods, such as torrefaction, water-leaching, a combination of leaching and torrefaction, and CaCO3 addition, were studied. The assessment of nitrogen release was divided into two consecutive conversion steps – devolatilization/pyrolysis and ash/char reactions. The release of nitrogen is highly dependent on the reaction conditions. For instance, the emissions of NO from the combustion conditions (3 vol% O2) for all fuel samples were, on average, six times higher than under gasification conditions (14.5 vol% H2O and 5 vol% CO2). The emissions of NO from the combustion and gasification of torrefied biomass were, on average, 20 % higher than those from raw biomass. Water-leaching had a suppressing effect on NO formation during char conversion. Approximately 62 % of the char-N formed NO for raw and torrefied material, whereas only 26 %–35 % was formed for pre- or postwashed samples. The effect of the applied pre-treatment approaches on the release of nitrogen was particularly significant during char conversion. Increasing calcium and decreasing potassium content had catalytic effects, mainly on the conversion of volatile-N to NH3. The Ca-doped biomass feedstock showed approximate 10 % increase in volatile-N to NH3 conversion compared to the source material.

Suggested Citation

  • Lebendig, Florian & Schmid, Daniel & Karlström, Oskar & Yrjas, Patrik & Müller, Michael, 2024. "Influence of pre-treatment of straw biomass and additives on the release of nitrogen species during combustion and gasification," Renewable and Sustainable Energy Reviews, Elsevier, vol. 189(PB).
    • Handle: RePEc:eee:rensus:v:189:y:2024:i:pb:s1364032123008912
    DOI: 10.1016/j.rser.2023.114033
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S1364032123008912
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.rser.2023.114033?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Mendiara, T. & García-Labiano, F. & Abad, A. & Gayán, P. & de Diego, L.F. & Izquierdo, M.T. & Adánez, J., 2018. "Negative CO2 emissions through the use of biofuels in chemical looping technology: A review," Applied Energy, Elsevier, vol. 232(C), pages 657-684.
    2. Broer, Karl M. & Brown, Robert C., 2015. "The role of char and tar in determining the gas-phase partitioning of nitrogen during biomass gasification," Applied Energy, Elsevier, vol. 158(C), pages 474-483.
    3. Ren, Qiangqiang & Zhao, Changsui, 2013. "NOx and N2O precursors (NH3 and HCN) from biomass pyrolysis: interaction between amino acid and mineral matter," Applied Energy, Elsevier, vol. 112(C), pages 170-174.
    4. Jianqiang Zhou & Pan Gao & Changqing Dong & Yongping Yang, 2018. "Effect of Temperature and Mineral Matter on the Formation of NOx Precursors during Fast Pyrolysis of 2,5-Diketopiperazine," Energies, MDPI, vol. 11(3), pages 1-10, March.
    5. Florian Lebendig & Ibai Funcia & Rául Pérez-Vega & Michael Müller, 2022. "Investigations on the Effect of Pre-Treatment of Wheat Straw on Ash-Related Issues in Chemical Looping Gasification (CLG) in Comparison with Woody Biomass," Energies, MDPI, vol. 15(9), pages 1-25, May.
    6. Karlström, Oskar & Hupa, Leena, 2019. "Energy conversion of biomass char: Oxidation rates in mixtures of O2/CO2/H2O," Energy, Elsevier, vol. 181(C), pages 615-624.
    7. Ozgen, S. & Cernuschi, S. & Caserini, S., 2021. "An overview of nitrogen oxides emissions from biomass combustion for domestic heat production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 135(C).
    8. Ren, Qiangqiang & Zhao, Changsui, 2015. "Evolution of fuel-N in gas phase during biomass pyrolysis," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 408-418.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Guo, Shuai & Liu, Tiecheng & Hui, Jicheng & Che, Deyong & Li, Xingcan & Sun, Baizhong & Li, Shaohua, 2019. "Effects of calcium oxide on nitrogen oxide precursor formation during sludge protein pyrolysis," Energy, Elsevier, vol. 189(C).
    2. Steiner, Maximilian & Anca-Couce, Andrés & Hochenauer, Christoph & Buchmayr, Markus & Scharler, Robert, 2024. "Relevance and prediction of N2O in small-scale multi-fuel biomass furnaces using primary NOx reduction measures," Renewable Energy, Elsevier, vol. 229(C).
    3. Huan Li & Huawei Mou & Nan Zhao & Yaohong Yu & Quan Hong & Mperejekumana Philbert & Yuguang Zhou & Hossein Beidaghy Dizaji & Renjie Dong, 2021. "Nitrogen Migration during Pyrolysis of Raw and Acid Leached Maize Straw," Sustainability, MDPI, vol. 13(7), pages 1-15, March.
    4. Xiaorui Liu & Zhongyang Luo & Chunjiang Yu & Bitao Jin & Hanchao Tu, 2018. "Release Mechanism of Fuel-N into NO x and N 2 O Precursors during Pyrolysis of Rice Straw," Energies, MDPI, vol. 11(3), pages 1-13, February.
    5. Bartocci, Pietro & Abad, Alberto & Mattisson, Tobias & Cabello, Arturo & Loscertales, Margarita de las Obras & Negredo, Teresa Mendiara & Zampilli, Mauro & Taiana, Andrea & Serra, Angela & Arauzo, Inm, 2022. "Bioenergy with Carbon Capture and Storage (BECCS) developed by coupling a Pressurised Chemical Looping combustor with a turbo expander: How to optimize plant efficiency," Renewable and Sustainable Energy Reviews, Elsevier, vol. 169(C).
    6. Stolarski, Mariusz J. & Dudziec, Paweł & Krzyżaniak, Michał & Graban, Łukasz & Lajszner, Waldemar & Olba–Zięty, Ewelina, 2024. "How do key for the bioenergy industry properties of baled biomass change over two years of storage?," Renewable Energy, Elsevier, vol. 224(C).
    7. José Antonio Soriano & Reyes García-Contreras & Antonio José Carpio de Los Pinos, 2021. "Study of the Thermochemical Properties of Lignocellulosic Biomass from Energy Crops," Energies, MDPI, vol. 14(13), pages 1-18, June.
    8. Liu, Ziyang & He, Mingfei & Tang, Xiaoping & Yuan, Guofeng & Yang, Bin & Yu, Xiaohui & Wang, Zhifeng, 2024. "Capacity optimisation and multi-dimensional analysis of air-source heat pump heating system: A case study," Energy, Elsevier, vol. 294(C).
    9. Ozdemir, Saim & Şimşek, Aslı & Ozdemir, Serkan & Dede, Cemile, 2022. "Investigation of poultry slaughterhouse waste stream to produce bio-fuel for internal utilization," Renewable Energy, Elsevier, vol. 190(C), pages 274-282.
    10. Rocío Collado & Esperanza Monedero & Víctor Manuel Casero-Alonso & Licesio J. Rodríguez-Aragón & Juan José Hernández, 2022. "Almond Shells and Exhausted Olive Cake as Fuels for Biomass Domestic Boilers: Optimization, Performance and Pollutant Emissions," Sustainability, MDPI, vol. 14(12), pages 1-17, June.
    11. Theppitak, Sarut & Hungwe, Douglas & Ding, Lu & Xin, Dai & Yu, Guangsuo & Yoshikawa, Kunio, 2020. "Comparison on solid biofuel production from wet and dry carbonization processes of food wastes," Applied Energy, Elsevier, vol. 272(C).
    12. Kamila Słupińska & Marek Wieruszewski & Piotr Szczypa & Anna Kożuch & Krzysztof Adamowicz, 2022. "Public Perception of the Use of Woody Biomass for Energy Purposes in the Evaluation of Content and Information Management on the Internet," Energies, MDPI, vol. 15(19), pages 1-11, September.
    13. Iñaki Adánez-Rubio & Antón Pérez-Astray & Alberto Abad & Pilar Gayán & Luis F. Diego & Juan Adánez, 2019. "Chemical looping with oxygen uncoupling: an advanced biomass combustion technology to avoid CO2 emissions," Mitigation and Adaptation Strategies for Global Change, Springer, vol. 24(7), pages 1293-1306, October.
    14. Mortari, Daniela A. & Pereira, Fernando M. & Crnkovic, Paula M., 2020. "Experimental investigation of the carbon dioxide effect on the devolatilization and combustion of a coal and sugarcane bagasse," Energy, Elsevier, vol. 204(C).
    15. Huang, Dexin & Song, Gongxiang & Li, Ruochen & Han, Hengda & He, Limo & Jiang, Long & Wang, Yi & Su, Sheng & Hu, Song & Xiang, Jun, 2023. "Evolution mechanisms of bio-oil from conventional and nitrogen-rich biomass during photo-thermal pyrolysis," Energy, Elsevier, vol. 282(C).
    16. Wang, Yuan & Zhu, Lin & He, Yangdong & Yu, Jianting & Zhang, Chaoli & Wang, Zi, 2023. "Comparative exergoeconomic analysis of atmosphere and pressurized CLC power plants coupled with supercritical CO2 cycle," Energy, Elsevier, vol. 265(C).
    17. Jaworek, A. & Sobczyk, A.T. & Marchewicz, A. & Krupa, A. & Czech, T., 2021. "Particulate matter emission control from small residential boilers after biomass combustion. A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 137(C).
    18. Abad, A. & Pérez-Vega, R. & de Diego, L.F. & Gayán, P. & Izquierdo, M.T. & García-Labiano, F. & Adánez, J., 2019. "Thermochemical assessment of chemical looping assisted by oxygen uncoupling with a MnFe-based oxygen carrier," Applied Energy, Elsevier, vol. 251(C), pages 1-1.
    19. Negri, Valentina & Galán-Martín, Ángel & Pozo, Carlos & Fajardy, Mathilde & Reiner, David M. & Mac Dowell, Niall & Guillén-Gosálbez, Gonzalo, 2021. "Life cycle optimization of BECCS supply chains in the European Union," Applied Energy, Elsevier, vol. 298(C).
    20. Tobias Mattisson & Fredrik Hildor & Ye Li & Carl Linderholm, 2020. "Negative emissions of carbon dioxide through chemical-looping combustion (CLC) and gasification (CLG) using oxygen carriers based on manganese and iron," Mitigation and Adaptation Strategies for Global Change, Springer, vol. 25(4), pages 497-517, April.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:rensus:v:189:y:2024:i:pb:s1364032123008912. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/600126/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.