IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v210y2023icp472-485.html
   My bibliography  Save this article

An integrated two stages inorganic membrane-based system to generate and recover decarbonized H2: An experimental study and performance indexes analysis

Author

Listed:
  • Iulianelli, Adolfo
  • Brunetti, Adele
  • Pino, Lidia
  • Italiano, Cristina
  • Ferrante, Giovanni Drago
  • Gensini, Mario
  • Vita, Antonio

Abstract

This work focuses on the utilization of a two stages inorganic membrane-based system to generate and recover decarbonized hydrogen in order to meet the targets set by the European Clean Hydrogen Partnership under the Strategic Research & Innovation Agenda 2021–2027. In the first stage, a CH4:CO2 = 60:40 mixture simulating a biogas stream is used to generate a COx-free hydrogen via steam reforming reaction carried out in a tubular Pd-Ag membrane reformer, packed with a novel non-commercial 7 wt%Ni-0.5 wt%Ru/La0.3Y0.3Zr0.4Ox catalyst, prepared by solution combustion method. The catalyst was characterized by XRD, TPR and TEM techniques. The analyses reveal well-distributed active metal particles interacting differently with the support (weakly and strongly). In particular, the XRD pattern shows the formation of perovskite and nickel oxide in addition to the pyrochlore phase. This behaviour indicates a low solubility of Ni in the pyrochlore structure. Reaction measurements were carried out at a temperature of 673 K, in the total pressure range between 250 kPa ÷ 350 kPa, weight hourly space velocity (WHSV) of 0.2 h−1, H2O/CH4 feed molar ratio between 1.5 and 2, feeding N2-sweep gas in the permeated side. As best results of Stage 1, CH4 conversion equal to 99% (@ H2O/CH4 feed molar ratio = 2 and feed pressure of 250 kPa) and a COx-free H2 recovery of 40% were reached. In the second stage, the unpermeated stream of Stage 1 rich in hydrogen was fed to a supported Pd/Al2O3 membrane separator to further recover high grade hydrogen at the same temperature and total pressure set in Stage 1. The maximum hydrogen recovery equal to 67% was reached at 673 K and 350 kPa, with a purity of the recovered stream equal to 99.9%. The total hydrogen recovered in the permeate streams of Stage 1 and Stage 2 was equal to 80% of the total hydrogen produced during the steam reforming reaction, showing an average purity equal to 99.99%, which allowed to meet the established targets. The work further analized and discussed the experimental results of the integrated system by means of performance indexes.

Suggested Citation

  • Iulianelli, Adolfo & Brunetti, Adele & Pino, Lidia & Italiano, Cristina & Ferrante, Giovanni Drago & Gensini, Mario & Vita, Antonio, 2023. "An integrated two stages inorganic membrane-based system to generate and recover decarbonized H2: An experimental study and performance indexes analysis," Renewable Energy, Elsevier, vol. 210(C), pages 472-485.
    • Handle: RePEc:eee:renene:v:210:y:2023:i:c:p:472-485
    DOI: 10.1016/j.renene.2023.04.095
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148123005463
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2023.04.095?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Gao, Yuchen & Jiang, Jianguo & Meng, Yuan & Aihemaiti, Aikelaimu & Ju, Tongyao & Chen, Xuejing & Yan, Feng, 2020. "A novel nickel catalyst supported on activated coal fly ash for syngas production via biogas dry reforming," Renewable Energy, Elsevier, vol. 149(C), pages 786-793.
    2. Papurello, Davide & Chiodo, Vitaliano & Maisano, Susanna & Lanzini, Andrea & Santarelli, Massimo, 2018. "Catalytic stability of a Ni-Catalyst towards biogas reforming in the presence of deactivating trace compounds," Renewable Energy, Elsevier, vol. 127(C), pages 481-494.
    3. Iulianelli, Adolfo & Palma, Vincenzo & Bagnato, Giuseppe & Ruocco, Concetta & Huang, Yan & Veziroğlu, Nejat T. & Basile, Angelo, 2018. "From bioethanol exploitation to high grade hydrogen generation: Steam reforming promoted by a Co-Pt catalyst in a Pd-based membrane reactor," Renewable Energy, Elsevier, vol. 119(C), pages 834-843.
    4. Meloni, Eugenio & Martino, Marco & Palma, Vincenzo, 2022. "Microwave assisted steam reforming in a high efficiency catalytic reactor," Renewable Energy, Elsevier, vol. 197(C), pages 893-901.
    5. Lachén, J. & Herguido, J. & Peña, J.A., 2020. "High purity hydrogen from biogas via steam iron process: Preventing reactor clogging by interspersed coke combustions," Renewable Energy, Elsevier, vol. 151(C), pages 619-626.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Parente, Marcelo & Soria, M.A. & Madeira, Luis M., 2020. "Hydrogen and/or syngas production through combined dry and steam reforming of biogas in a membrane reactor: A thermodynamic study," Renewable Energy, Elsevier, vol. 157(C), pages 1254-1264.
    2. Eugenio Meloni & Liberato Cafiero & Marco Martino & Vincenzo Palma, 2023. "Structured Catalysts for Non-Thermal Plasma-Assisted Ammonia Synthesis," Energies, MDPI, vol. 16(7), pages 1-17, April.
    3. Bagnato, Giuseppe & Boulet, Florent & Sanna, Aimaro, 2019. "Effect of Li-LSX zeolite, NiCe/Al2O3 and NiCe/ZrO2 on the production of drop-in bio-fuels by pyrolysis and hydrotreating of Nannochloropsis and isochrysis microalgae," Energy, Elsevier, vol. 179(C), pages 199-213.
    4. Shir Reen Chia & Saifuddin Nomanbhay & Jassinnee Milano & Kit Wayne Chew & Chung-Hong Tan & Kuan Shiong Khoo, 2022. "Microwave-Absorbing Catalysts in Catalytic Reactions of Biofuel Production," Energies, MDPI, vol. 15(21), pages 1-26, October.
    5. Chen, Qianyang & Qiu, Qianyuan & Yan, Xiaomin & Zhou, Mingyang & Zhang, Yapeng & Liu, Zhijun & Cai, Weizi & Wang, Wei & Liu, Jiang, 2020. "A compact and seal-less direct carbon solid oxide fuel cell stack stepping into practical application," Applied Energy, Elsevier, vol. 278(C).
    6. Raza, Jehangeer & Khoja, Asif Hussain & Anwar, Mustafa & Saleem, Faisal & Naqvi, Salman Raza & Liaquat, Rabia & Hassan, Muhammad & Javaid, Rahat & Qazi, Umair Yaqub & Lumbers, Brock, 2022. "Methane decomposition for hydrogen production: A comprehensive review on catalyst selection and reactor systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 168(C).
    7. Bakhtyari, Ali & Bardool, Roghayeh & Rahimpour, Mohammad Reza & Iulianelli, Adolfo, 2021. "Dehydration of bio-alcohols in an enhanced membrane-assisted reactor: A rigorous sensitivity analysis and multi-objective optimization," Renewable Energy, Elsevier, vol. 177(C), pages 519-543.
    8. Ekaterina Matus & Olga Sukhova & Ilyas Ismagilov & Mikhail Kerzhentsev & Olga Stonkus & Zinfer Ismagilov, 2021. "Hydrogen Production through Autothermal Reforming of Ethanol: Enhancement of Ni Catalyst Performance via Promotion," Energies, MDPI, vol. 14(16), pages 1-16, August.
    9. Liu, Shuai & Du, Pengzhu & Jia, Hekun & Zhang, Qiushi & Hao, Liutao, 2024. "Study on the impact of methanol steam reforming reactor channel structure on hydrogen production performance," Renewable Energy, Elsevier, vol. 228(C).
    10. Tang, Xincheng & Wu, Yanxiao & Fang, Zhenchang & Dong, Xinyu & Du, Zhongxuan & Deng, Bicai & Sun, Chunhua & Zhou, Feng & Qiao, Xinqi & Li, Xinling, 2024. "Syntheses, catalytic performances and DFT investigations: A recent review of copper-based catalysts of methanol steam reforming for hydrogen production," Energy, Elsevier, vol. 295(C).
    11. Jalali, Ramin & Rezaei, Mehran & Nematollahi, Behzad & Baghalha, Morteza, 2020. "Preparation of Ni/MeAl2O4-MgAl2O4 (Me=Fe, Co, Ni, Cu, Zn, Mg) nanocatalysts for the syngas production via combined dry reforming and partial oxidation of methane," Renewable Energy, Elsevier, vol. 149(C), pages 1053-1067.
    12. Sanchez, Nestor & Ruiz, Ruth & Rödl, Anne & Cobo, Martha, 2021. "Technical and environmental analysis on the power production from residual biomass using hydrogen as energy vector," Renewable Energy, Elsevier, vol. 175(C), pages 825-839.
    13. Labanca, A.R.C. & Cunha, A.G. & Ribeiro, R.P. & Zucolotto, C.G. & Cevolani, M.B. & Schettino, M.A., 2022. "Technological solution for distributing vehicular hydrogen using dry plasma reforming of natural gas and biogas," Renewable Energy, Elsevier, vol. 201(P2), pages 11-21.
    14. Lv, Xiuqing & Chen, Huili & Zhou, Wei & Cheng, Fangqin & Li, Si-Dian & Shao, Zongping, 2020. "Direct-methane solid oxide fuel cells with an in situ formed Ni–Fe alloy composite catalyst layer over Ni–YSZ anodes," Renewable Energy, Elsevier, vol. 150(C), pages 334-341.
    15. Dai, Huidong & Besser, R.S., 2022. "Understanding hydrogen sulfide impact on a portable, commercial, propane-powered solid-oxide fuel cell," Applied Energy, Elsevier, vol. 307(C).
    16. Meloni, Eugenio & Saraceno, Emilia & Martino, Marco & Corrado, Antonio & Iervolino, Giuseppina & Palma, Vincenzo, 2023. "SiC-based structured catalysts for a high-efficiency electrified dry reforming of methane," Renewable Energy, Elsevier, vol. 211(C), pages 336-346.
    17. Zheng, Yanhui & Hou, Xifeng & Liu, Yuheng & Ma, Zichuan, 2021. "Hexamethyldisiloxane removal from biogas using reduced graphene-oxide aerogels as adsorbents," Renewable Energy, Elsevier, vol. 178(C), pages 153-161.
    18. Darmansyah, Darmansyah & You, Sheng-Jie & Wang, Ya-Fen, 2023. "Advancements of coal fly ash and its prospective implications for sustainable materials in Southeast Asian countries: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 188(C).
    19. Hanmin Yang & Ilman Nuran Zaini & Ruming Pan & Yanghao Jin & Yazhe Wang & Lengwan Li & José Juan Bolívar Caballero & Ziyi Shi & Yaprak Subasi & Anissa Nurdiawati & Shule Wang & Yazhou Shen & Tianxiang, 2024. "Distributed electrified heating for efficient hydrogen production," Nature Communications, Nature, vol. 15(1), pages 1-10, December.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:210:y:2023:i:c:p:472-485. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.