IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v176y2019icp235-248.html
   My bibliography  Save this article

Experimental investigation of gas turbine compressor water injection for NOx emission reductions

Author

Listed:
  • Block Novelo, David Alejandro
  • Igie, Uyioghosa
  • Prakash, Vinod
  • Szymański, Artur

Abstract

The global rising demand for civil air travel shows good prospects for the industry, however, this growth is inevitably matched with higher levels of emissions and fuel consumption. In this study, demineralised water injection is presented as an alternative to reduce NOx emissions and enhance engine performance. The experimental study firstly presents the droplet size characterisation of a spray nozzle. This is done for varied injection pressure, water temperature and at varied axial and radial locations using an impaction pin nozzle. The single-shaft Artouste engine is used in conducting the compressor water injection test with water-to-air ratios of 0.5, 1 and 2%. The water droplet diameter, engine gas path and exhaust emissions are all monitored in real time. For the engine tests, droplets are measured at the spraying point and correlations are used to account for the droplet size at the inlet of the compressor due to measurement difficulties in this region. The test showed a reduction in compressor discharge temperature by up to 34 K and a NOx decrease by 25%. Nevertheless, the higher reductions in NOx at higher water-to-air ratios are attributed to a predominant cooling in the combustor because of unevaporated water in the compressor. At 0.5% water-to-air ratio, the drop in NOx is mainly due to compressor cooling and signified by the only case in which the fuel-to-air ratio reduces. The study presents evidence of the combined effects of compressor and combustor water ingestion. The CO is seen to increase significantly and associated with reduced combustor efficiency.

Suggested Citation

  • Block Novelo, David Alejandro & Igie, Uyioghosa & Prakash, Vinod & Szymański, Artur, 2019. "Experimental investigation of gas turbine compressor water injection for NOx emission reductions," Energy, Elsevier, vol. 176(C), pages 235-248.
    • Handle: RePEc:eee:energy:v:176:y:2019:i:c:p:235-248
    DOI: 10.1016/j.energy.2019.03.187
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544219306073
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2019.03.187?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Roumeliotis, I. & Mathioudakis, K., 2010. "Evaluation of water injection effect on compressor and engine performance and operability," Applied Energy, Elsevier, vol. 87(4), pages 1207-1216, April.
    2. Novelo, David Alejandro Block & Igie, Uyioghosa, 2018. "Aero engine compressor cooling by water injection - Part 1: Evaporative compressor model," Energy, Elsevier, vol. 160(C), pages 1224-1235.
    3. Block Novelo, David Alejandro & Igie, Uyioghosa, 2018. "Aero engine compressor cooling by water injection - Part 2: Performance and emission reductions," Energy, Elsevier, vol. 160(C), pages 1236-1243.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Zidong Yu & Terese Løvås & Dmytro Konovalov & Eugeniy Trushliakov & Mykola Radchenko & Halina Kobalava & Roman Radchenko & Andrii Radchenko, 2022. "Investigation of Thermopressor with Incomplete Evaporation for Gas Turbine Intercooling Systems," Energies, MDPI, vol. 16(1), pages 1-19, December.
    2. Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Ragaišis, Valdas & Paukštaitis, Linas & Jouhara, Hussam & Mingilaitė, Laura, 2022. "Experimental investigations of water droplet transient phase changes in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 256(C).
    3. Serrano, José Ramón & Martín, Jaime & Piqueras, Pedro & Tabet, Roberto & Gómez, Javier, 2023. "Effect of natural and forced charge air humidity on the performance and emissions of a compression-ignition engine operating at high warm altitude," Energy, Elsevier, vol. 266(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Pan Zhang & Xiwei Ke & Weiliang Wang & Xueyu Tang & Junfu Lyu & Qinghong Tang, 2023. "Study on the Selection of Single-Screw Steam Compressors in Industrial Steam Supply," Energies, MDPI, vol. 16(10), pages 1-15, May.
    2. Lv, Chengkun & Xu, Haiqi & Chang, Juntao & Wang, Youyin & Chen, Ruoyu & Yu, Daren, 2022. "Mode transition analysis of a turbine-based combined-cycle considering ammonia injection pre-compressor cooling and variable-geometry ram-combustor," Energy, Elsevier, vol. 261(PB).
    3. Bennett, Jeffrey A. & Simpson, Juliet G. & Qin, Chao & Fittro, Roger & Koenig, Gary M. & Clarens, Andres F. & Loth, Eric, 2021. "Techno-economic analysis of offshore isothermal compressed air energy storage in saline aquifers co-located with wind power," Applied Energy, Elsevier, vol. 303(C).
    4. Comodi, G. & Renzi, M. & Caresana, F. & Pelagalli, L., 2015. "Enhancing micro gas turbine performance in hot climates through inlet air cooling vapour compression technique," Applied Energy, Elsevier, vol. 147(C), pages 40-48.
    5. Giorgetti, S. & Bricteux, L. & Parente, A. & Blondeau, J. & Contino, F. & De Paepe, W., 2017. "Carbon capture on micro gas turbine cycles: Assessment of the performance on dry and wet operations," Applied Energy, Elsevier, vol. 207(C), pages 243-253.
    6. De Paepe, Ward & Delattin, Frank & Bram, Svend & De Ruyck, Jacques, 2012. "Steam injection experiments in a microturbine – A thermodynamic performance analysis," Applied Energy, Elsevier, vol. 97(C), pages 569-576.
    7. Saeed Bahrami & Ali Ghaffari & Marcus Thern, 2013. "Improving the Transient Performance of the Gas Turbine by Steam Injection during Frequency Dips," Energies, MDPI, vol. 6(10), pages 1-14, October.
    8. Kayadelen, Hasan Kayhan & Ust, Yasin & Bashan, Veysi, 2021. "Thermodynamic performance analysis of state of the art gas turbine cycles with inter-stage turbine reheat and steam injection," Energy, Elsevier, vol. 222(C).
    9. Aretakis, N. & Roumeliotis, I. & Doumouras, G. & Mathioudakis, K., 2012. "Compressor washing economic analysis and optimization for power generation," Applied Energy, Elsevier, vol. 95(C), pages 77-86.
    10. Kyprianidis, Konstantinos G. & Dahlquist, Erik, 2017. "On the trade-off between aviation NOx and energy efficiency," Applied Energy, Elsevier, vol. 185(P2), pages 1506-1516.
    11. S. Hamed Fatemi Alavi & Amirreza Javaherian & S. M. S. Mahmoudi & Saeed Soltani & Marc A. Rosen, 2023. "Coupling a Gas Turbine Bottoming Cycle Using CO 2 as the Working Fluid with a Gas Cycle: Exergy Analysis Considering Combustion Chamber Steam Injection," Clean Technol., MDPI, vol. 5(3), pages 1-25, September.
    12. Block Novelo, David Alejandro & Igie, Uyioghosa, 2018. "Aero engine compressor cooling by water injection - Part 2: Performance and emission reductions," Energy, Elsevier, vol. 160(C), pages 1236-1243.
    13. Chunlei Liu & Qun Zheng & Qi Wang & Aqiang Lin & Yuting Jiang & Mingcong Luo, 2019. "Sensitivity Analysis of Multistage Compressor Characteristics Under the Spray Atomization Effect Using a CFD Model," Energies, MDPI, vol. 12(2), pages 1-30, January.
    14. Renzi, M. & Caresana, F. & Pelagalli, L. & Comodi, G., 2014. "Enhancing micro gas turbine performance through fogging technique: Experimental analysis," Applied Energy, Elsevier, vol. 135(C), pages 165-173.
    15. Lv, Chengkun & Lan, Zhu & Wang, Ziao & Chang, Juntao & Yu, Daren, 2024. "Intelligent ammonia precooling control for TBCC mode transition based on neural network improved equilibrium manifold expansion model," Energy, Elsevier, vol. 288(C).
    16. Kyoung Hoon Kim & Kyoungjin Kim, 2012. "Exergy Analysis of Overspray Process in Gas Turbine Systems," Energies, MDPI, vol. 5(8), pages 1-14, July.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:176:y:2019:i:c:p:235-248. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.