IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v136y2017icp173-184.html
   My bibliography  Save this article

The ignition characteristics and combustion processes of the single coal slime particle under different hot-coflow conditions in N2/O2 atmosphere

Author

Listed:
  • Zhou, Kun
  • Lin, Qizhao
  • Hu, Hongwei
  • Hu, Huiqing
  • Song, Lanbo

Abstract

The ignition characteristics and combustion processes of single coal slime particle in a vertical heating tube furnace in N2/O2 oxidant atmosphere were investigated under different hot-coflow conditions, including variations in coflow temperature (Tc = 923, 1073, and 1173 K), gas flow rate (V = 0–30 L/min), and oxygen concentration (O2% = 5%–100%). All investigated hot-coflow conditions exhibited three ignition behaviors, homogeneous ignition of volatiles, heterogeneous ignition of char, and heterogeneous ignition of coal. Additionally, three corresponding ignition regimes were observed in the oxygen concentration-coflow temperature plane. Critical conditions for the transitions of the three ignition mechanisms varied as flow was increased from 0 to 30 L/min. Various ignition mechanisms resulted in various combustion processes. Under medium-to-low oxygen concentration and low coflow temperature, the heterogeneous ignition of char resulted in flameless combustion. The ignition temperature and ignition delay decreased as coflow temperature and oxygen concentration were increased. The trends became more obvious when test conditions progressed in medium-to-low oxygen concentrations. As the flow rate increased, ignition temperature and delay became increasingly sensitive to oxygen concentration. Experimental results are then discussed in conjunction with the various observed trends influencing mechanisms of different hot-coflow conditions.

Suggested Citation

  • Zhou, Kun & Lin, Qizhao & Hu, Hongwei & Hu, Huiqing & Song, Lanbo, 2017. "The ignition characteristics and combustion processes of the single coal slime particle under different hot-coflow conditions in N2/O2 atmosphere," Energy, Elsevier, vol. 136(C), pages 173-184.
    • Handle: RePEc:eee:energy:v:136:y:2017:i:c:p:173-184
    DOI: 10.1016/j.energy.2016.02.038
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544216300810
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2016.02.038?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Riaza, J. & Álvarez, L. & Gil, M.V. & Pevida, C. & Pis, J.J. & Rubiera, F., 2011. "Effect of oxy-fuel combustion with steam addition on coal ignition and burnout in an entrained flow reactor," Energy, Elsevier, vol. 36(8), pages 5314-5319.
    2. Riaza, J. & Gil, M.V. & Álvarez, L. & Pevida, C. & Pis, J.J. & Rubiera, F., 2012. "Oxy-fuel combustion of coal and biomass blends," Energy, Elsevier, vol. 41(1), pages 429-435.
    3. Lille, Simon & Blasiak, Wlodzimierz & Jewartowski, Marcin, 2005. "Experimental study of the fuel jet combustion in high temperature and low oxygen content exhaust gases," Energy, Elsevier, vol. 30(2), pages 373-384.
    4. Hong, Jongsup & Chaudhry, Gunaranjan & Brisson, J.G. & Field, Randall & Gazzino, Marco & Ghoniem, Ahmed F., 2009. "Analysis of oxy-fuel combustion power cycle utilizing a pressurized coal combustor," Energy, Elsevier, vol. 34(9), pages 1332-1340.
    5. Liszka, M. & Ziębik, A., 2010. "Coal-fired oxy-fuel power unit – Process and system analysis," Energy, Elsevier, vol. 35(2), pages 943-951.
    6. Dicorato, M. & Forte, G. & Trovato, M., 2012. "Wind farm stability analysis in the presence of variable-speed generators," Energy, Elsevier, vol. 39(1), pages 40-47.
    7. Gil, M.V. & Riaza, J. & Álvarez, L. & Pevida, C. & Pis, J.J. & Rubiera, F., 2012. "Kinetic models for the oxy-fuel combustion of coal and coal/biomass blend chars obtained in N2 and CO2 atmospheres," Energy, Elsevier, vol. 48(1), pages 510-518.
    8. Gallo, Michele & Mescia, Luciano & Losito, Onofrio & Bozzetti, Michele & Prudenzano, Francesco, 2012. "Design of optical antenna for solar energy collection," Energy, Elsevier, vol. 39(1), pages 27-32.
    9. Nozaki, Tomohiro & Takano, Shin-ichi & Kiga, Takashi & Omata, Kouji & Kimura, Naokazu, 1997. "Analysis of the flame formed during oxidation of pulverized coal by an O2 CO2 mixture," Energy, Elsevier, vol. 22(2), pages 199-205.
    10. Du, Shan-Wen & Chen, Wei-Hsin & Lucas, John A., 2010. "Pulverized coal burnout in blast furnace simulated by a drop tube furnace," Energy, Elsevier, vol. 35(2), pages 576-581.
    11. Carton, J.G. & Olabi, A.G., 2010. "Wind/hydrogen hybrid systems: Opportunity for Ireland’s wind resource to provide consistent sustainable energy supply," Energy, Elsevier, vol. 35(12), pages 4536-4544.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Jiang, Chunlong & Lin, Qizhao & Wang, Chengxin & Jiang, Xuedan & Bi, Haobo & Bao, Lin, 2020. "Experimental study of the ignition and combustion characteristics of cattle manure under different environmental conditions," Energy, Elsevier, vol. 197(C).
    2. Zeng, Guang & Xu, Mingchen & Tu, Yaojie & Li, Zhenwei & Cai, Yongtie & Zheng, Zhimin & Tay, Kunlin & Yang, Wenming, 2020. "Influences of initial coal concentration on ignition behaviors of low-NOx bias combustion technology," Applied Energy, Elsevier, vol. 278(C).
    3. Song, Yawei & Su, Sheng & Liu, Yushuai & Zhao, Zheng & Xu, Kai & Xu, Jun & Jiang, Long & Wang, Yi & Hu, Song & Xiang, Jun, 2024. "Characteristics of OH formation during single coal particle ignition and volatile combustion in O2/N2 and O2/CO2 atmospheres," Energy, Elsevier, vol. 288(C).
    4. Tian, Ye & Zhou, Xiong & Ji, Xuanyu & Bai, Jisong & Yuan, Liang, 2019. "Applying moderate or intense low-oxygen dilution combustion to a co-axial-jet I-shaped recuperative radiant tube for further performance enhancement," Energy, Elsevier, vol. 171(C), pages 149-160.
    5. Jiang, Chunlong & Zhou, Wenliang & Bi, Haobo & Ni, Zhanshi & Sun, Hao & Lin, Qizhao, 2022. "Co-pyrolysis of coal slime and cattle manure by TG–FTIR–MS and artificial neural network modeling: Pyrolysis behavior, kinetics, gas emission characteristics," Energy, Elsevier, vol. 247(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Jiang, Chunlong & Lin, Qizhao & Wang, Chengxin & Jiang, Xuedan & Bi, Haobo & Bao, Lin, 2020. "Experimental study of the ignition and combustion characteristics of cattle manure under different environmental conditions," Energy, Elsevier, vol. 197(C).
    2. Gil, María V. & Riaza, Juan & Álvarez, Lucía & Pevida, Covadonga & Rubiera, Fernando, 2015. "Biomass devolatilization at high temperature under N2 and CO2: Char morphology and reactivity," Energy, Elsevier, vol. 91(C), pages 655-662.
    3. Riaza, J. & Álvarez, L. & Gil, M.V. & Pevida, C. & Pis, J.J. & Rubiera, F., 2011. "Effect of oxy-fuel combustion with steam addition on coal ignition and burnout in an entrained flow reactor," Energy, Elsevier, vol. 36(8), pages 5314-5319.
    4. Lasek, Janusz A. & Janusz, Marcin & Zuwała, Jarosław & Głód, Krzysztof & Iluk, Andrzej, 2013. "Oxy-fuel combustion of selected solid fuels under atmospheric and elevated pressures," Energy, Elsevier, vol. 62(C), pages 105-112.
    5. Yin, Chungen & Yan, Jinyue, 2016. "Oxy-fuel combustion of pulverized fuels: Combustion fundamentals and modeling," Applied Energy, Elsevier, vol. 162(C), pages 742-762.
    6. Riaza, J. & Gil, M.V. & Álvarez, L. & Pevida, C. & Pis, J.J. & Rubiera, F., 2012. "Oxy-fuel combustion of coal and biomass blends," Energy, Elsevier, vol. 41(1), pages 429-435.
    7. Mostafa, Mohamed E. & He, Limo & Xu, Jun & Hu, Song & Wang, Yi & Su, Sheng & Hu, Xun & Elsayed, Saad A. & Xiang, Jun, 2019. "Investigating the effect of integrated CO2 and H2O on the reactivity and kinetics of biomass pellets oxy-steam combustion using new double parallel volumetric model (DVM)," Energy, Elsevier, vol. 179(C), pages 343-357.
    8. Díez, Luis I. & García-Mariaca, Alexander & Canalís, Paula & Llera, Eva, 2023. "Oxy-combustion characteristics of torrefied biomass and blends under O2/N2, O2/CO2 and O2/CO2/H2O atmospheres," Energy, Elsevier, vol. 284(C).
    9. Rashwan, Sherif S. & Ibrahim, Abdelmaged H. & Abou-Arab, Tharwat W. & Nemitallah, Medhat A. & Habib, Mohamed A., 2017. "Experimental study of atmospheric partially premixed oxy-combustion flames anchored over a perforated plate burner," Energy, Elsevier, vol. 122(C), pages 159-167.
    10. Warzecha, Piotr & Boguslawski, Andrzej, 2014. "LES and RANS modeling of pulverized coal combustion in swirl burner for air and oxy-combustion technologies," Energy, Elsevier, vol. 66(C), pages 732-743.
    11. Zhang, Yongliang & Jin, Bo & Zou, Xixian & Zhao, Haibo, 2016. "A clean coal utilization technology based on coal pyrolysis and chemical looping with oxygen uncoupling: Principle and experimental validation," Energy, Elsevier, vol. 98(C), pages 181-189.
    12. Tanui, J.K. & Kioni, P.N. & Mirre, T. & Nowitzki, M. & Karuri, N.W., 2020. "The influence of particle packing density on wood combustion in a fixed bed under oxy-fuel conditions," Energy, Elsevier, vol. 194(C).
    13. Tang, Yuting & Ma, Xiaoqian & Lai, Zhiyi & Zhou, Daoxi & Lin, Hai & Chen, Yong, 2012. "NOx and SO2 emissions from municipal solid waste (MSW) combustion in CO2/O2 atmosphere," Energy, Elsevier, vol. 40(1), pages 300-306.
    14. Fu, Chao & Gundersen, Truls, 2012. "Using exergy analysis to reduce power consumption in air separation units for oxy-combustion processes," Energy, Elsevier, vol. 44(1), pages 60-68.
    15. Wang, Yingli & Duan, Jialong & Zhao, Yuanyuan & Yuan, Haiwen & He, Benlin & Tang, Qunwei, 2018. "Film-type rain energy converters from conductive polymer/PtCo hybrids," Applied Energy, Elsevier, vol. 218(C), pages 317-324.
    16. Irfan, Muhammad Faisal & Arami-Niya, Arash & Chakrabarti, Mohammed Harun & Wan Daud, Wan Mohd. Ashri & Usman, Muhammad Rashid, 2012. "Kinetics of gasification of coal, biomass and their blends in air (N2/O2) and different oxy-fuel (O2/CO2) atmospheres," Energy, Elsevier, vol. 37(1), pages 665-672.
    17. Chen, Shiyi & Yu, Ran & Soomro, Ahsanullah & Xiang, Wenguo, 2019. "Thermodynamic assessment and optimization of a pressurized fluidized bed oxy-fuel combustion power plant with CO2 capture," Energy, Elsevier, vol. 175(C), pages 445-455.
    18. López, R. & Fernández, C. & Fierro, J. & Cara, J. & Martínez, O. & Sánchez, M.E., 2014. "Oxy-combustion of corn, sunflower, rape and microalgae bioresidues and their blends from the perspective of thermogravimetric analysis," Energy, Elsevier, vol. 74(C), pages 845-854.
    19. Mao, Zhihui & Zhang, Liqi & Zhu, Xinyang & Pan, Cong & Yi, Baojun & Zheng, Chuguang, 2016. "Modeling of an oxy-coal flame under a steam-rich atmosphere," Applied Energy, Elsevier, vol. 161(C), pages 112-123.
    20. Jiao, Anyao & Zhang, Hai & Liu, Jiaxun & Shen, Jun & Jiang, Xiumin, 2017. "The role of CO played in the nitric oxide heterogeneous reduction: A quantum chemistry study," Energy, Elsevier, vol. 141(C), pages 1538-1546.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:136:y:2017:i:c:p:173-184. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.