IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v355y2024ics0306261923015982.html
   My bibliography  Save this article

Accelerated aging for after-treatment devices of diesel engine: Method, emission characteristics, and equivalence

Author

Listed:
  • Lyu, Liqun
  • Wang, Junfang
  • Yin, Hang
  • Ji, Zhongrui
  • Tan, Jianwei
  • Hao, Lijun
  • Ge, Yunshan

Abstract

After-treatment devices of diesel engines effectively reduce exhaust emissions but deteriorate over time. Consequently, the China-VI emission regulation mandates a useful life of seven years or 700,000 km for after-treatment devices. Conventional engine bench aging methods, being costly and time-consuming, are inapplicable for long-term emission durability verification. This paper introduces an accelerated aging method based on the thermal accumulation and Arrhenius equation. Accelerated aging of four after-treatment devices of the same model at different temperatures and durations was carried out. Results revealed that barring the CDPF's PN filtration efficiency, the efficiencies of the DOC, SCR, and ASC catalysts declined with accelerated aging, especially under lower temperatures. Deterioration in conversion efficiencies of catalysts increased the NOx, CO, THC, and NH3 emissions under cold- and warm-WHTC tests. Considering that the equivalent durability mileage of the after-treatment devices under 150 h 650 °C accelerated aging condition is approximately 870,000 km, while the CO, THC, PN, NOx, and NH3 emission factors are 0.05 g/kWh, 0.21 g/kWh, 2.14 × 1010 #/kWh, 0.44 g/kWh, and 3.48 ppm, respectively, so the durability of the tested after-treatment devices could comply with the China-VI emission regulation. Although accelerated aging did not significantly affect PN emissions, it increased the balanced point temperature of CDPF and the proportion of sub-23 nm particles. If emission regulations further reduce the lower limit of PN measurement to 10 nm, it could negatively impact the emission durability of CDPF. In addition, comparing the 1000 h of conventional aging showed similar characteristics and results in NOx conversion efficiency and NOx emission, suggesting that the accelerated aging method is reliable. In conclusion, the accelerated aging method reduces the durability verification duration, providing a cost-effective regulatory tool for environmental protection authorities and guidance for manufacturers to optimize device performance and durability.

Suggested Citation

  • Lyu, Liqun & Wang, Junfang & Yin, Hang & Ji, Zhongrui & Tan, Jianwei & Hao, Lijun & Ge, Yunshan, 2024. "Accelerated aging for after-treatment devices of diesel engine: Method, emission characteristics, and equivalence," Applied Energy, Elsevier, vol. 355(C).
    • Handle: RePEc:eee:appene:v:355:y:2024:i:c:s0306261923015982
    DOI: 10.1016/j.apenergy.2023.122234
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261923015982
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2023.122234?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Tan, Pi-qiang & Wang, Shi-yan & Hu, Zhi-yuan & Lou, Di-ming, 2019. "Durability of V2O5-WO3/TiO2 selective catalytic reduction catalysts for heavy-duty diesel engines using B20 blend fuel," Energy, Elsevier, vol. 179(C), pages 383-391.
    2. Yulong Shan & Guangzhi He & Jinpeng Du & Yu Sun & Zhongqi Liu & Yu Fu & Fudong Liu & Xiaoyan Shi & Yunbo Yu & Hong He, 2022. "Strikingly distinctive NH3-SCR behavior over Cu-SSZ-13 in the presence of NO2," Nature Communications, Nature, vol. 13(1), pages 1-10, December.
    3. Su, Sheng & Ge, Yang & Hou, Pan & Wang, Xin & Wang, Yachao & Lyu, Tao & Luo, Wanyou & Lai, Yitu & Ge, Yunshan & Lyu, Liqun, 2021. "China VI heavy-duty moving average window (MAW) method: Quantitative analysis of the problem, causes, and impacts based on the real driving data," Energy, Elsevier, vol. 225(C).
    4. Sun, Chuanwang & Xu, Shuhua & Yang, Mian & Gong, Xu, 2022. "Urban traffic regulation and air pollution: A case study of urban motor vehicle restriction policy," Energy Policy, Elsevier, vol. 163(C).
    5. Jacek Pielecha & Kinga Skobiej & Maciej Gis & Wojciech Gis, 2022. "Particle Number Emission from Vehicles of Various Drives in the RDE Tests," Energies, MDPI, vol. 15(17), pages 1-20, September.
    6. Sheng Su & Yunshan Ge & Xin Wang & Mengzhu Zhang & Lijun Hao & Jianwei Tan & Fulu Shi & Dongdong Guo & Zhengjun Yang, 2020. "Evaluating the In-Service Emissions of High-Mileage Dedicated Methanol-Fueled Passenger Cars: Regulated and Unregulated Emissions," Energies, MDPI, vol. 13(11), pages 1-15, May.
    7. Zhao, Qiaonan & Yang, Qiguo & Xu, Hongtao & Jiao, Anyao & Pan, Donghui, 2023. "Experimental study on pollutant emission characteristics of diesel urea-based selective catalytic reduction system based on corrugated substrate," Energy, Elsevier, vol. 267(C).
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Liu, Shang & Lin, Zhelong & Qi, Yunliang & Wang, Zhi & Yang, Dongsheng & Lu, Guoxiang & Wang, Bo, 2024. "Combustion and emission characteristics of a spark ignition engine fueled with ammonia/gasoline and pure ammonia," Applied Energy, Elsevier, vol. 369(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Xu, Shuhua & Sun, Chuanwang & Wei, Haoyu & Hou, Xinshuo, 2023. "Road construction and air pollution: Analysis of road area ratio in China," Applied Energy, Elsevier, vol. 351(C).
    2. Chao Jin & Xiaodan Li & Teng Xu & Juntong Dong & Zhenlong Geng & Jia Liu & Chenyun Ding & Jingjing Hu & Ahmed El ALAOUI & Qing Zhao & Haifeng Liu, 2023. "Zero-Carbon and Carbon-Neutral Fuels: A Review of Combustion Products and Cytotoxicity," Energies, MDPI, vol. 16(18), pages 1-29, September.
    3. Wang, Yachao & Yin, Hang & Yang, Zhengjun & Su, Sheng & Hao, Lijun & Tan, Jianwei & Wang, Xin & Niu, Zhihui & Ge, Yunshan, 2022. "Assessing the brake particle emissions for sustainable transport: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 167(C).
    4. Monika Andrych-Zalewska & Zdzislaw Chlopek & Jerzy Merkisz & Jacek Pielecha, 2022. "Comparison of Gasoline Engine Exhaust Emissions of a Passenger Car through the WLTC and RDE Type Approval Tests," Energies, MDPI, vol. 15(21), pages 1-13, November.
    5. Wu, Zhicong & Xu, Gang & Zhang, Wentao & Xue, Xiaojun & Chen, Heng, 2023. "Thermodynamic and economic analysis of a new methanol steam reforming system integrated with CO2 heat pump and cryogenic separation system," Energy, Elsevier, vol. 283(C).
    6. Zhao, Qiaonan & Yang, Qiguo & Xu, Hongtao & Jiao, Anyao & Pan, Donghui, 2023. "Experimental study on pollutant emission characteristics of diesel urea-based selective catalytic reduction system based on corrugated substrate," Energy, Elsevier, vol. 267(C).
    7. Xiaojia Chen & Wei Xu, 2022. "Exploring the Effects of Traffic Noise on Innovation through Health Mechanism: A Quasi-Experimental Study in China," Sustainability, MDPI, vol. 14(19), pages 1-16, October.
    8. Wojciech Cieslik & Weronika Antczak, 2023. "Research of Load Impact on Energy Consumption in an Electric Delivery Vehicle Based on Real Driving Conditions: Guidance for Electrification of Light-Duty Vehicle Fleet," Energies, MDPI, vol. 16(2), pages 1-19, January.
    9. Seongin Jo & Hyung Jun Kim & Sang Il Kwon & Jong Tae Lee & Suhan Park, 2023. "Assessment of Energy Consumption Characteristics of Ultra-Heavy-Duty Vehicles under Real Driving Conditions," Energies, MDPI, vol. 16(5), pages 1-18, February.
    10. Maksymilian Mądziel, 2023. "Vehicle Emission Models and Traffic Simulators: A Review," Energies, MDPI, vol. 16(9), pages 1-31, May.
    11. Liudan Jiao & Fenglian Luo & Fengyan Wu & Yu Zhang & Xiaosen Huo & Ya Wu, 2022. "Exploring the Interactive Coercing Relationship between Urban Rail Transit and the Ecological Environment," Land, MDPI, vol. 11(6), pages 1-20, June.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:355:y:2024:i:c:s0306261923015982. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.