IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v353y2024ipas0306261923013624.html
   My bibliography  Save this article

Combustion stability and NOx emission characteristics of three combustion modes of pulverized coal boilers under low or ultra-low loads

Author

Listed:
  • Ma, Dafu
  • Zhang, Shouyu
  • He, Xiang
  • Ding, Xian
  • Li, Wangfan
  • Liu, Pingyuan

Abstract

Under low or ultra-low loads, poor combustion stability and high NOx emissions hinder the stable operation of pulverized coal boilers. Numerical simulation was used to investigate the impact of boiler load rate and operation oxygen on combustion stability and NOx emission characteristics in tangentially fired, swirl-opposed fired, and W-flame boilers. To quantitatively assess combustion stability, a combustion stability index was introduced using ignition distance and average temperature of the main combustion zone as parameters. The results indicate that as the load decreased, the temperature and combustion stability decreased rapidly below the 50% load; ignition distance and NOx emission concentration (@6% O2) increased. Moreover, under stable low loads, reduced operation oxygen enhanced temperature and combustion stability while reducing ignition distance and NOx emissions (@6% O2), with minimal impact on CO concentration. Under stable low loads in all three boilers, reducing operation oxygen to 3.5% led to an average temperature increase of 56.8 °C. Additionally, the W-flame boiler exhibits the highest average temperature (1371 °C), oxygen concentration, and NOx concentration, and the lowest temperature-decrease rate. Under equal conditions, the average combustion stability index (Ics) decrease rate of the three boilers under low loads was 2.3 times that under mid–high loads. The tangentially fired boiler demonstrates the highest combustion stability capacity (Ics = 0.78), possibly owing to the close distance between each direct-current burner layer, and the mutual support and ignition between each corner of the same layer.

Suggested Citation

  • Ma, Dafu & Zhang, Shouyu & He, Xiang & Ding, Xian & Li, Wangfan & Liu, Pingyuan, 2024. "Combustion stability and NOx emission characteristics of three combustion modes of pulverized coal boilers under low or ultra-low loads," Applied Energy, Elsevier, vol. 353(PA).
    • Handle: RePEc:eee:appene:v:353:y:2024:i:pa:s0306261923013624
    DOI: 10.1016/j.apenergy.2023.121998
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261923013624
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2023.121998?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Li, Zhengqi & Liu, Guangkui & Zhu, Qunyi & Chen, Zhichao & Ren, Feng, 2011. "Combustion and NOx emission characteristics of a retrofitted down-fired 660Â MWe utility boiler at different loads," Applied Energy, Elsevier, vol. 88(7), pages 2400-2406, July.
    2. Qiao, Yanyu & Li, Song & Jing, Xinjing & Chen, Zhichao & Fan, Subo & Li, Zhengqi, 2022. "Combustion and NOx formation characteristics from a 330 MWe retrofitted anthracite-fired utility boiler with swirl burner under deeply-staged-combustion," Energy, Elsevier, vol. 258(C).
    3. Wang, Qingxiang & Chen, Zhichao & Li, Liankai & Zeng, Lingyan & Li, Zhengqi, 2020. "Achievement in ultra-low-load combustion stability for an anthracite- and down-fired boiler after applying novel swirl burners: From laboratory experiments to industrial applications," Energy, Elsevier, vol. 192(C).
    4. Jiang, Yu & Lee, Byoung-Hwa & Oh, Dong-Hun & Jeon, Chung-Hwan, 2022. "Influence of various air-staging on combustion and NOX emission characteristics in a tangentially fired boiler under the 50% load condition," Energy, Elsevier, vol. 244(PB).
    5. Ma, Dafu & Zhang, Shouyu & He, Xiang & Zhang, Jian & Ding, Xian, 2023. "Combustion stability and NOX emission characteristics of a 300 MWe tangentially fired boiler under ultra-low loads with deep-air staging," Energy, Elsevier, vol. 269(C).
    6. Drosatos, Panagiotis & Nikolopoulos, Nikolaos & Karampinis, Emmanouil & Strotos, George & Grammelis, Panagiotis & Kakaras, Emmanouil, 2020. "Numerical comparative investigation of a flexible lignite-fired boiler using pre-dried lignite or biomass as supporting fuel," Renewable Energy, Elsevier, vol. 145(C), pages 1831-1848.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Peian Chong & Xiaolei Zhu & Jianning Li & Xiao Li & Lei Deng, 2024. "Investigation on Hydrodynamic Performance and Wall Temperature of Water-Cooled Wall in 1000 MW Boiler Under Low-Load Conditions," Energies, MDPI, vol. 17(22), pages 1-17, November.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ma, Dafu & Zhang, Shouyu & He, Xiang & Zhang, Jian & Ding, Xian, 2023. "Combustion stability and NOX emission characteristics of a 300 MWe tangentially fired boiler under ultra-low loads with deep-air staging," Energy, Elsevier, vol. 269(C).
    2. Bolegenova, Saltanat & Askarova, Аliya & Georgiev, Aleksandar & Nugymanova, Aizhan & Maximov, Valeriy & Bolegenova, Symbat & Adil'bayev, Nurken, 2024. "Staged supply of fuel and air to the combustion chamber to reduce emissions of harmful substances," Energy, Elsevier, vol. 293(C).
    3. Su, Kun & Ouyang, Ziqu & Ding, Hongliang & Wang, Wenyu & Zhang, Jinyang & Wang, Hongshuai & Zhu, Shujun, 2023. "Experimental investigation on effect of external circulation system on preheating characteristics of pulverized coal," Energy, Elsevier, vol. 278(C).
    4. Tang, Zhenhao & Sui, Mengxuan & Wang, Xu & Xue, Wenyuan & Yang, Yuan & Wang, Zhi & Ouyang, Tinghui, 2024. "Theory-guided deep neural network for boiler 3-D NOx concentration distribution prediction," Energy, Elsevier, vol. 299(C).
    5. Li, Zhengqi & Liu, Zheng & Huang, Haolin & Du, He & Chen, Zhichao, 2024. "The effects of key parameters on the gas/particle flows characteristics in the furnace of a Foster Wheeler down-fired boiler retrofitted with novel low-load stable combustion technology," Energy, Elsevier, vol. 288(C).
    6. Belal, Belal Y. & Li, Gesheng & Zhang, Zunhua & El-Batsh, H.M. & Moneib, Hany A. & Attia, Ali M.A., 2021. "The effect of swirl burner design configuration on combustion and emission characteristics of lean pre-vaporized premixed flames," Energy, Elsevier, vol. 228(C).
    7. Zhang, Xin & Chen, Zhichao & Hou, Jian & Liu, Zheng & Zeng, Lingyan & Li, Zhengqi, 2022. "Evaluation of wide-range coal combustion performance of a novel down-fired combustion technology based on gas–solid two-phase flow characteristics," Energy, Elsevier, vol. 248(C).
    8. Sajad Koochakinia & Amir Ebrahimi-Moghadam & Mahdi Deymi-Dashtebayaz, 2022. "Techno-Environmental Analyses and Optimization of a Utility Boiler Based on Real Data," Sustainability, MDPI, vol. 14(5), pages 1-19, February.
    9. Yuan, Zhenhua & Chen, Zhichao & Bian, Liguo & Li, Zhengqi, 2023. "Influence of over-fired air location on gas-particle flow characteristics within a coal-fired industrial boiler under radial air staging," Energy, Elsevier, vol. 283(C).
    10. Hong, Tang & Zuodong, Liu & Xiaoju, Han & Xueqiang, Shen & Yuqiu, Liu & Siyuan, Wang & Zhiming, Xu, 2024. "Experimental study on combustion characteristics of a 40 MW pulverized coal boiler based on a new low NOx burner with preheating function," Energy, Elsevier, vol. 305(C).
    11. Zhang, Mengzhu & Ge, Yunshan & Wang, Xin & Xu, Hongming & Tan, Jianwei & Hao, Lijun, 2021. "Effects of ethanol and aromatic compositions on regulated and unregulated emissions of E10-fuelled China-6 compliant gasoline direct injection vehicles," Renewable Energy, Elsevier, vol. 176(C), pages 322-333.
    12. Wu, Zheng & Zhang, Yue & Dong, Ze, 2024. "NOx concentration prediction based on multi-channel fused spectral temporal graph neural network in coal-fired power plants," Energy, Elsevier, vol. 305(C).
    13. Kuang, Min & Wu, Haiqian & Zhu, Qunyi & Ti, Shuguang, 2018. "Establishing an overall symmetrical combustion setup for a 600 MWe supercritical down-fired boiler: A numerical and cold-modeling experimental verification," Energy, Elsevier, vol. 147(C), pages 208-225.
    14. Zhu, Shujun & Hui, Jicheng & Lyu, Qinggang & Ouyang, Ziqu & Zeng, Xiongwei & Zhu, Jianguo & Liu, Jingzhang & Cao, Xiaoyang & Zhang, Xiaoyu & Ding, Hongliang & Liu, Yuhua, 2023. "Experimental study on pulverized coal swirl-opposed combustion preheated by a circulating fluidized bed. Part A. Wide-load operation and low-NOx emission characteristics," Energy, Elsevier, vol. 284(C).
    15. Taler, Jan & Trojan, Marcin & Dzierwa, Piotr & Kaczmarski, Karol & Węglowski, Bohdan & Taler, Dawid & Zima, Wiesław & Grądziel, Sławomir & Ocłoń, Paweł & Sobota, Tomasz & Rerak, Monika & Jaremkiewicz,, 2023. "The flexible boiler operation in a wide range of load changes with considering the strength and environmental restrictions," Energy, Elsevier, vol. 263(PB).
    16. Ahn, Jonghoon & Cho, Soolyeon & Chung, Dae Hun, 2017. "Analysis of energy and control efficiencies of fuzzy logic and artificial neural network technologies in the heating energy supply system responding to the changes of user demands," Applied Energy, Elsevier, vol. 190(C), pages 222-231.
    17. Kuang, Min & Li, Zhengqi & Zhu, Qunyi & Zhang, Yan, 2013. "Performance assessment of staged-air declination in improving asymmetric gas/particle flow characteristics within a down-fired 600 MWe supercritical utility boiler," Energy, Elsevier, vol. 49(C), pages 423-433.
    18. Zhang, Qijun & Dong, Jianning & Chen, Heng & Feng, Fuyuan & Xu, Gang & Wang, Xiuyan & Liu, Tong, 2024. "Dynamic characteristics and economic analysis of a coal-fired power plant integrated with molten salt thermal energy storage for improving peaking capacity," Energy, Elsevier, vol. 290(C).
    19. Liu, Guangkui & Chen, Zhichao & Li, Zhengqi & Zong, Qiudong & Zhang, Hao, 2014. "Effect of the arch-supplied over-fire air ratio on gas/solid flow characteristics of a down-fired boiler," Energy, Elsevier, vol. 70(C), pages 95-109.
    20. Wang, Yanhong & Yu, Jie & Liang, Hejun & Li, Qi & Hu, Pengfei & Wang, Di, 2024. "Modeling on rapid prediction and cause diagnosis of boiler combustion efficiency," Energy, Elsevier, vol. 302(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:353:y:2024:i:pa:s0306261923013624. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.