IDEAS home Printed from https://ideas.repec.org/a/eee/agiwat/v184y2017icp36-45.html
   My bibliography  Save this article

Controlling mechanism of chlorination on emitter bio-clogging for drip irrigation using reclaimed water

Author

Listed:
  • Song, Peng
  • Li, Yunkai
  • Zhou, Bo
  • Zhou, Chunfa
  • Zhang, Zhijing
  • Li, Jiusheng

Abstract

Drip irrigation using reclaimed water or polluted surface water involves a higher risk of bio-clogging, which is the most typical and the most complex type of clogging, and the clogging of drip irrigation emitters limits the use and spread of drip irrigation technology. Due to its strong oxidizing effect, chlorination has been considered as the most effective method of controlling emitter bio-clogging. However, the detailed controlling mechanism has remained unclear until now. Meanwhile, there have been no unified standards established for chlorination to refer to. Therefore, field experiments were carried out in a sewage treatment plant, where the reclaimed water after secondary treatment was treated with the Cyclic Activated Sludge System (CASS) process that had been incorporated to the drip irrigation system to study the controlling mechanism and impacts on non-pressure-compensating emitter bio-clogging. There were three chlorination treatments studied, which included 2.5mg/L×2h (low concentration, long duration), 5.0mg/L×1h (moderate concentration and duration), and 10mg/L×0.5h (high concentration, short duration). The results showed that the chemical chlorination could control the microbial growth in the bio-clogging substances effectively, with the microbial phospholipid fatty acids (PLFAs) decreased by 8.3%–36.1%, the number of microbial species decreased by 2–3, the microbial activity decreased by 2.6%–23.2%, and the secretion of extracellular polymeric substances (EPS) decreased by 19.8%–43.4%. Thus, the bio-clogging substances were well controlled, and the contents of solid particles (SD) content decreased by 4.8%–48.2% compared to the non- chlorinated treatment, while the discharge ratio variation (Dra) and Christiansen uniformity coefficient (CU) increased by 14.7%–22.8% and 6.77%–19.9%, respectively. However, the effects of different chlorination modes varied significantly. Chlorination with a low concentration and a long contacting duration decreased microbial activity, and better controlled emitter bio-clogging. Thus, the chlorination treatment of 2.5mg/L×2h was recommended in the drip irrigation system using reclaimed water treated with CASS technology.

Suggested Citation

  • Song, Peng & Li, Yunkai & Zhou, Bo & Zhou, Chunfa & Zhang, Zhijing & Li, Jiusheng, 2017. "Controlling mechanism of chlorination on emitter bio-clogging for drip irrigation using reclaimed water," Agricultural Water Management, Elsevier, vol. 184(C), pages 36-45.
    • Handle: RePEc:eee:agiwat:v:184:y:2017:i:c:p:36-45
    DOI: 10.1016/j.agwat.2016.12.017
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0378377416305145
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.agwat.2016.12.017?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Liu, Haijun & Huang, Guanhua, 2009. "Laboratory experiment on drip emitter clogging with fresh water and treated sewage effluent," Agricultural Water Management, Elsevier, vol. 96(5), pages 745-756, May.
    2. Ravina, I. & Paz, E. & Sofer, Z. & Marm, A. & Schischa, A. & Sagi, G. & Yechialy, Z. & Lev, Y., 1997. "Control of clogging in drip irrigation with stored treated municipal sewage effluent," Agricultural Water Management, Elsevier, vol. 33(2-3), pages 127-137, June.
    3. Capra, A. & Scicolone, B., 2004. "Emitter and filter tests for wastewater reuse by drip irrigation," Agricultural Water Management, Elsevier, vol. 68(2), pages 135-149, August.
    4. Bucks, D. A. & Nakayama, F. S. & Gilbert, R. G., 1979. "Trickle irrigation water quality and preventive maintenance," Agricultural Water Management, Elsevier, vol. 2(2), pages 149-162, June.
    5. Puig-Bargues, J. & Arbat, G. & Barragan, J. & Ramirez de Cartagena, F., 2005. "Hydraulic performance of drip irrigation subunits using WWTP effluents," Agricultural Water Management, Elsevier, vol. 77(1-3), pages 249-262, August.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Zhangzhong, Lili & Yang, Peiling & Zhen, Wengang & Zhang, Xin & Wang, Caiyuan, 2019. "A kinetic model for the chemical clogging of drip irrigation system using saline water," Agricultural Water Management, Elsevier, vol. 223(C), pages 1-1.
    2. Duran-Ros, Miquel & Puig-Bargués, Jaume & Cufí, Sílvia & Solé-Torres, Carles & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2022. "Effect of different filter media on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 266(C).
    3. Liu, Zeyuan & Xiao, Yang & Li, Yunkai & Zhou, Bo & Feng, Ji & Han, Siqi & Muhammad, Tahir, 2019. "Influence of operating pressure on emitter anti-clogging performance of drip irrigation system with high-sediment water," Agricultural Water Management, Elsevier, vol. 213(C), pages 174-184.
    4. Petit, Julien & García, Sílvia Mas & Molle, Bruno & Bendoula, Ryad & Ait-Mouheb, Nassim, 2022. "Methods for drip irrigation clogging detection, analysis and understanding: State of the art and perspectives," Agricultural Water Management, Elsevier, vol. 272(C).
    5. Zhou, Hongxu & Li, Yunkai & Wang, Yan & Zhou, Bo & Bhattarai, Rabin, 2019. "Composite fouling of drip emitters applying surface water with high sand concentration: Dynamic variation and formation mechanism," Agricultural Water Management, Elsevier, vol. 215(C), pages 25-43.
    6. Muhammad, Tahir & Zhou, Bo & Puig-Bargu´es, Jaume & Ding, Can & Li, Shuqin & Manan, Irum & Zhou, Yunpeng & Liu, Zeyuan & Li, Yunkai, 2022. "Assessment of emitter clogging with multiple fouling and root intrusion in sub-surface drip irrigation during 5-year sugarcane growth," Agricultural Water Management, Elsevier, vol. 274(C).
    7. Yao, Chunping & Zhang, Lin & Wu, Pute & Liu, Ying & Cai, Yaohui & Zhou, Wei, 2021. "Clogging formation and an anti-clogging method in subsurface irrigation system with porous ceramic emitter," Agricultural Water Management, Elsevier, vol. 250(C).
    8. Han, Siqi & Li, Yunkai & Zhou, Bo & Liu, Zeyuan & Feng, Ji & Xiao, Yang, 2019. "An in-situ accelerated experimental testing method for drip irrigation emitter clogging with inferior water," Agricultural Water Management, Elsevier, vol. 212(C), pages 136-154.
    9. Liu, Zeyuan & Ma, Changjian & Xiao, Yang & Lili, Zhangzhong & Muhammad, Tahir & Li, Yunkai, 2023. "Application of chelated fertilizers to mitigate organic-inorganic fouling in brackish water drip irrigation systems," Agricultural Water Management, Elsevier, vol. 285(C).
    10. Solé-Torres, Carles & Puig-Bargués, Jaume & Duran-Ros, Miquel & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2019. "Effect of different sand filter underdrain designs on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 223(C), pages 1-1.
    11. Zhang, Wenqian & Niu, Wenquan & Li, Guochun & Wang, Jie & Wang, Yanbang & Dong, Aihong, 2020. "Lateral inner environment changes and effects on emitter clogging risk for different irrigation times," Agricultural Water Management, Elsevier, vol. 233(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Oliver, M.M.H. & Hewa, G.A. & Pezzaniti, D., 2014. "Bio-fouling of subsurface type drip emitters applying reclaimed water under medium soil thermal variation," Agricultural Water Management, Elsevier, vol. 133(C), pages 12-23.
    2. Liu, Haijun & Huang, Guanhua, 2009. "Laboratory experiment on drip emitter clogging with fresh water and treated sewage effluent," Agricultural Water Management, Elsevier, vol. 96(5), pages 745-756, May.
    3. Duran-Ros, M. & Puig-Bargués, J. & Arbat, G. & Barragán, J. & Cartagena, F. Ramírez de, 2009. "Effect of filter, emitter and location on clogging when using effluents," Agricultural Water Management, Elsevier, vol. 96(1), pages 67-79, January.
    4. Mohammad ZAMANIYAN & Rouhollah FATAHI & Saeed BOROOMAND-NASAB, 2014. "Field performance evaluation of micro irrigation systems in Iran," Soil and Water Research, Czech Academy of Agricultural Sciences, vol. 9(3), pages 135-142.
    5. Puig-Bargués, J. & Arbat, G. & Elbana, M. & Duran-Ros, M. & Barragán, J. & de Cartagena, F. Ramírez & Lamm, F.R., 2010. "Effect of flushing frequency on emitter clogging in microirrigation with effluents," Agricultural Water Management, Elsevier, vol. 97(6), pages 883-891, June.
    6. Puig-Bargues, J. & Arbat, G. & Barragan, J. & Ramirez de Cartagena, F., 2005. "Hydraulic performance of drip irrigation subunits using WWTP effluents," Agricultural Water Management, Elsevier, vol. 77(1-3), pages 249-262, August.
    7. Duran-Ros, Miquel & Puig-Bargués, Jaume & Cufí, Sílvia & Solé-Torres, Carles & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2022. "Effect of different filter media on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 266(C).
    8. Ma, Changjian & Jiang, Cuiling & Li, Yan & Shi, Ning & Liu, Shenglin & Hu, Xinhui & Liu, Zhaohui & Sun, Zeqiang & Muhammad, Tahir, 2024. "Effect of lateral flushing on emitter clogging in drip irrigation using high-sediment water," Agricultural Water Management, Elsevier, vol. 293(C).
    9. Han, Siqi & Li, Yunkai & Zhou, Bo & Liu, Zeyuan & Feng, Ji & Xiao, Yang, 2019. "An in-situ accelerated experimental testing method for drip irrigation emitter clogging with inferior water," Agricultural Water Management, Elsevier, vol. 212(C), pages 136-154.
    10. Zhang, Wenqian & Niu, Wenquan & Li, Guochun & Wang, Jie & Wang, Yanbang & Dong, Aihong, 2020. "Lateral inner environment changes and effects on emitter clogging risk for different irrigation times," Agricultural Water Management, Elsevier, vol. 233(C).
    11. Zhou, Bo & Li, Yunkai & Xue, Song & Feng, Ji, 2019. "Variation of microorganisms in drip irrigation systems using high-sand surface water," Agricultural Water Management, Elsevier, vol. 218(C), pages 37-47.
    12. Zhou, Bo & Wang, Tianzhi & Li, Yunkai & Bralts, Vincent, 2017. "Effects of microbial community variation on bio-clogging in drip irrigation emitters using reclaimed water," Agricultural Water Management, Elsevier, vol. 194(C), pages 139-149.
    13. Deepak Singh & Neelam Patel & Agossou Gadedjisso-Tossou & Sridhar Patra & Nisha Singh & Pushpendra Kumar Singh, 2020. "Incidence of Escherichia coli in Vegetable Crops and Soil Profile Drip Irrigated with Primarily Treated Municipal Wastewater in a Semi-Arid Peri Urban Area," Agriculture, MDPI, vol. 10(7), pages 1-17, July.
    14. Petit, Julien & García, Sílvia Mas & Molle, Bruno & Bendoula, Ryad & Ait-Mouheb, Nassim, 2022. "Methods for drip irrigation clogging detection, analysis and understanding: State of the art and perspectives," Agricultural Water Management, Elsevier, vol. 272(C).
    15. Li, Yunkai & Pan, Jiachong & Chen, Xiuzhi & Xue, Song & Feng, Ji & Muhammad, Tahir & Zhou, Bo, 2019. "Dynamic effects of chemical precipitates on drip irrigation system clogging using water with high sediment and salt loads," Agricultural Water Management, Elsevier, vol. 213(C), pages 833-842.
    16. Solé-Torres, Carles & Puig-Bargués, Jaume & Duran-Ros, Miquel & Arbat, Gerard & Pujol, Joan & Ramírez de Cartagena, Francisco, 2019. "Effect of different sand filter underdrain designs on emitter clogging using reclaimed effluents," Agricultural Water Management, Elsevier, vol. 223(C), pages 1-1.
    17. Soliman, Azza I.E. & Morad, M.M. & Wasfy, Kamal I. & Moursy, M.A.M., 2020. "Utilization of aquaculture drainage for enhancing onion crop yield under surface and subsurface drip irrigation systems," Agricultural Water Management, Elsevier, vol. 239(C).
    18. Seyedzadeh, Amin & Maroufpoor, Saman & Maroufpoor, Eisa & Shiri, Jalal & Bozorg-Haddad, Omid & Gavazi, Farnoosh, 2020. "Artificial intelligence approach to estimate discharge of drip tape irrigation based on temperature and pressure," Agricultural Water Management, Elsevier, vol. 228(C).
    19. Masoud Ghaffari & Jaber Soltani, 2016. "Evaluation and Comparison of Performance in the Disc Filter with Sand Filters of Filtration Equipment in Micro Irrigation Systems," Modern Applied Science, Canadian Center of Science and Education, vol. 10(8), pages 264-264, August.
    20. Oliver, M.M.H. & Hewa, Guna Alankerage & Pezzaniti, David, 2016. "Thermal variation and pressure compensated emitters," Agricultural Water Management, Elsevier, vol. 176(C), pages 29-39.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:agiwat:v:184:y:2017:i:c:p:36-45. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/locate/agwat .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.