IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i12p4634-d1168359.html
   My bibliography  Save this article

Experimental Development of the Horizontal Drain Water Heat Recovery Unit

Author

Listed:
  • Sabina Kordana-Obuch

    (Department of Infrastructure and Water Management, Rzeszow University of Technology, al. Powstańców Warszawy 6, 35-959 Rzeszow, Poland)

  • Mariusz Starzec

    (Department of Infrastructure and Water Management, Rzeszow University of Technology, al. Powstańców Warszawy 6, 35-959 Rzeszow, Poland)

Abstract

The increase in energy demand, the scarcity of resources, as well as the adverse environmental impact of burning fossil fuels make it necessary to diversify the energy sources used. This also applies to the residential sector, which accounts for a significant proportion of global energy consumption. Particular attention should be paid to water heating, as the importance of this process in the energy balance of buildings is steadily increasing. One of the methods used to decrease energy consumption for heating water is to recover heat from greywater. However, commercially available horizontal drain water heat recovery (DWHR) units are characterized by low effectiveness, which creates a need for further research to improve it. The aim of the paper was to evaluate the possibility of improving the effectiveness of a circular horizontal DWHR unit through the use of baffles. Six different baffle models for installation in the greywater section of the heat exchanger were analyzed. The tests were conducted under the assumption of the installation of the DWHR unit on the horizontal shower waste pipe. They showed that the effectiveness of the unit equipped with baffles was higher by several to as much as 40% compared to the DWHR unit without baffles. This is tantamount to an increase in annual financial savings resulting from greywater heat recovery, as well as a reduction in CO 2 emissions into the atmosphere. However, it was not possible to clearly identify the optimum baffle model. In any case, the selection should consider the hydraulic conditions in the heat exchanger before installing the baffles. The results can provide guidance for companies interested in bringing new equipment and technologies to the market.

Suggested Citation

  • Sabina Kordana-Obuch & Mariusz Starzec, 2023. "Experimental Development of the Horizontal Drain Water Heat Recovery Unit," Energies, MDPI, vol. 16(12), pages 1-24, June.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:12:p:4634-:d:1168359
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/12/4634/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/12/4634/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Sabina Kordana-Obuch & Mariusz Starzec & Michał Wojtoń & Daniel Słyś, 2023. "Greywater as a Future Sustainable Energy and Water Source: Bibliometric Mapping of Current Knowledge and Strategies," Energies, MDPI, vol. 16(2), pages 1-34, January.
    2. Yuriy Bilan & Yaryna Samusevych & Serhiy Lyeonov & Marcin Strzelec & Iryna Tenytska, 2022. "The Keys to Clean Energy Technology: Impact of Environmental Taxes on Biofuel Production and Consumption," Energies, MDPI, vol. 15(24), pages 1-22, December.
    3. Sabina Kordana-Obuch & Mariusz Starzec, 2022. "Horizontal Shower Heat Exchanger as an Effective Domestic Hot Water Heating Alternative," Energies, MDPI, vol. 15(13), pages 1-22, July.
    4. Bartłomiej Igliński & Michał Bernard Pietrzak & Urszula Kiełkowska & Mateusz Skrzatek & Artur Gajdos & Anas Zyadin & Karthikeyan Natarajan, 2022. "How to Meet the Green Deal Objectives—Is It Possible to Obtain 100% RES at the Regional Level in the EU?," Energies, MDPI, vol. 15(6), pages 1-24, March.
    5. Leonardo Sierra & Maximiliano Lizana & Catalina Pino & Amilkar Ilaya-Ayza & Briguitte Neculman, 2023. "Structural Model for Socially Sustainable Public Housing Decision-Making in Chile," IJERPH, MDPI, vol. 20(3), pages 1-21, January.
    6. Barbara Tchórzewska-Cieślak & Katarzyna Pietrucha-Urbanik, 2023. "Water System Safety Analysis Model," Energies, MDPI, vol. 16(6), pages 1-18, March.
    7. Orest Voznyak & Nadiia Spodyniuk & Ievgen Antypov & Edyta Dudkiewicz & Mariana Kasynets & Olena Savchenko & Svitlana Tarasenko, 2023. "Efficiency Improvement of Eco-Friendly Solar Heat Supply System as a Building Coating," Sustainability, MDPI, vol. 15(3), pages 1-18, February.
    8. Łukasz Amanowicz & Katarzyna Ratajczak & Edyta Dudkiewicz, 2023. "Recent Advancements in Ventilation Systems Used to Decrease Energy Consumption in Buildings—Literature Review," Energies, MDPI, vol. 16(4), pages 1-39, February.
    9. Łukasz Amanowicz, 2021. "Peak Power of Heat Source for Domestic Hot Water Preparation (DHW) for Residential Estate in Poland as a Representative Case Study for the Climate of Central Europe," Energies, MDPI, vol. 14(23), pages 1-15, December.
    10. Brett Watson & Ian Lange & Joshua Linn, 2023. "Coal demand, market forces, and U.S. coal mine closures," Economic Inquiry, Western Economic Association International, vol. 61(1), pages 35-57, January.
    11. Igliński, Bartłomiej & Pietrzak, Michał Bernard & Kiełkowska, Urszula & Skrzatek, Mateusz & Kumar, Gopalakrishnan & Piechota, Grzegorz, 2022. "The assessment of renewable energy in Poland on the background of the world renewable energy sector," Energy, Elsevier, vol. 261(PB).
    12. Giglio, T. & Santos, V. & Lamberts, R., 2019. "Analyzing the impact of small solar water heating systems on peak demand and on emissions in the Brazilian context," Renewable Energy, Elsevier, vol. 133(C), pages 1404-1413.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Beata Piotrowska & Daniel Słyś, 2023. "Analysis of the Life Cycle Cost of a Heat Recovery System from Greywater Using a Vertical “Tube-in-Tube” Heat Exchanger: Case Study of Poland," Resources, MDPI, vol. 12(9), pages 1-17, August.
    2. Mariusz Starzec & Sabina Kordana-Obuch & Beata Piotrowska, 2024. "Evaluation of the Suitability of Using Artificial Neural Networks in Assessing the Effectiveness of Greywater Heat Exchangers," Sustainability, MDPI, vol. 16(7), pages 1-26, March.
    3. Sabina Kordana-Obuch & Michał Wojtoń & Mariusz Starzec & Beata Piotrowska, 2023. "Opportunities and Challenges for Research on Heat Recovery from Wastewater: Bibliometric and Strategic Analyses," Energies, MDPI, vol. 16(17), pages 1-36, September.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Sabina Kordana-Obuch & Michał Wojtoń & Mariusz Starzec & Beata Piotrowska, 2023. "Opportunities and Challenges for Research on Heat Recovery from Wastewater: Bibliometric and Strategic Analyses," Energies, MDPI, vol. 16(17), pages 1-36, September.
    2. Beata Piotrowska & Daniel Słyś, 2023. "Analysis of the Life Cycle Cost of a Heat Recovery System from Greywater Using a Vertical “Tube-in-Tube” Heat Exchanger: Case Study of Poland," Resources, MDPI, vol. 12(9), pages 1-17, August.
    3. Sabina Kordana-Obuch & Mariusz Starzec & Michał Wojtoń & Daniel Słyś, 2023. "Greywater as a Future Sustainable Energy and Water Source: Bibliometric Mapping of Current Knowledge and Strategies," Energies, MDPI, vol. 16(2), pages 1-34, January.
    4. Enrico Maria Carlini & Corrado Gadaleta & Michela Migliori & Francesca Ferretti & Riccardo Vailati & Andrea Venturini & Cinzia Puglisi, 2024. "Cost-Effective Target Capacity Assessment in the Energy Transition: The Italian Methodology," Energies, MDPI, vol. 17(12), pages 1-25, June.
    5. Katarzyna Ratajczak & Łukasz Amanowicz & Katarzyna Pałaszyńska & Filip Pawlak & Joanna Sinacka, 2023. "Recent Achievements in Research on Thermal Comfort and Ventilation in the Aspect of Providing People with Appropriate Conditions in Different Types of Buildings—Semi-Systematic Review," Energies, MDPI, vol. 16(17), pages 1-55, August.
    6. Przemysław Ogarek & Michał Wojtoń & Daniel Słyś, 2023. "Hydrogen as a Renewable Energy Carrier in a Hybrid Configuration of Distributed Energy Systems: Bibliometric Mapping of Current Knowledge and Strategies," Energies, MDPI, vol. 16(14), pages 1-18, July.
    7. Czekała, Wojciech & Łukomska, Aleksandra & Pulka, Jakub & Bojarski, Wiktor & Pochwatka, Patrycja & Kowalczyk-Juśko, Alina & Oniszczuk, Anna & Dach, Jacek, 2023. "Waste-to-energy: Biogas potential of waste from coffee production and consumption," Energy, Elsevier, vol. 276(C).
    8. Kristiana Dolge & Dagnija Blumberga, 2023. "Transitioning to Clean Energy: A Comprehensive Analysis of Renewable Electricity Generation in the EU-27," Energies, MDPI, vol. 16(18), pages 1-27, September.
    9. Rivera, Nathaly M. & Loveridge, Scott, 2022. "Coal-to-gas fuel switching and its effects on housing prices," Energy Economics, Elsevier, vol. 106(C).
    10. Piotr Michalak, 2023. "Simulation and Experimental Study on the Use of Ventilation Air for Space Heating of a Room in a Low-Energy Building," Energies, MDPI, vol. 16(8), pages 1-17, April.
    11. Dawid Czajor & Łukasz Amanowicz, 2024. "Methodology for Modernizing Local Gas-Fired District Heating Systems into a Central District Heating System Using Gas-Fired Cogeneration Engines—A Case Study," Sustainability, MDPI, vol. 16(4), pages 1-30, February.
    12. Paul Calanter, 2023. "Assessing the Energy State of the EU under Green Deal Objectives," Global Economic Observer, "Nicolae Titulescu" University of Bucharest, Faculty of Economic Sciences;Institute for World Economy of the Romanian Academy, vol. 11(1), pages 16-23, May.
    13. Bogdan Saletnik & Marcin Fiedur & Radosław Kwarciany & Grzegorz Zaguła & Marcin Bajcar, 2024. "Pyrolysis as a Method for Processing of Waste from Production of Cultivated Tobacco ( Nicotiana tabacum L.)," Sustainability, MDPI, vol. 16(7), pages 1-15, March.
    14. Nibas Chandra Deb & Jayanta Kumar Basak & Bhola Paudel & Sijan Karki & Dae-yeong Kang & Seong-woo Jeon & Eun-wan Seo & Junghoo Kook & Myeong-yong Kang & Hyeon-tae Kim, 2024. "Estimation of Energy Balance throughout the Growing–Finishing Stage of Pigs in an Experimental Pig Barn," Agriculture, MDPI, vol. 14(6), pages 1-16, May.
    15. Mariusz Starzec & Sabina Kordana-Obuch, 2024. "Evaluating the Utility of Selected Machine Learning Models for Predicting Stormwater Levels in Small Streams," Sustainability, MDPI, vol. 16(2), pages 1-29, January.
    16. Anderson Breno Souza & Alvaro Antonio Villa Ochoa & José Ângelo Peixoto da Costa & Gustavo de Novaes Pires Leite & Héber Claudius Nunes Silva & Andrezza Carolina Carneiro Tómas & David Campos Barbosa , 2023. "A Review of Tropical Organic Materials for Biodiesel as a Substitute Energy Source in Internal Combustion Engines: A Viable Solution?," Energies, MDPI, vol. 16(9), pages 1-25, April.
    17. Michieka, Nyakundi M. & Graziano, Marcello & Musso, Marta & Fouquet, Roger, 2022. "Energy transitions and labor market patterns in the U.S. coal industry," Structural Change and Economic Dynamics, Elsevier, vol. 63(C), pages 501-514.
    18. Jakub Jasiński & Mariusz Kozakiewicz & Maciej Sołtysik, 2024. "Analysis of the Economic Soundness and Viability of Migrating from Net Billing to Net Metering Using Energy Cooperatives," Energies, MDPI, vol. 17(6), pages 1-14, March.
    19. Maria Hurnik, 2025. "Testing Method for Non-Isothermal Radial Wall Jets from Ceiling Diffusers Used in Building Ventilation," Energies, MDPI, vol. 18(2), pages 1-13, January.
    20. Katarzyna Ratajczak & Edward Szczechowiak & Aneta Pobudkowska, 2023. "Energy-Saving Scenarios of an Existing Swimming Pool with the Use of Simple In Situ Measurement," Energies, MDPI, vol. 16(16), pages 1-25, August.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:12:p:4634-:d:1168359. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.