IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v14y2021i7p1992-d529889.html
   My bibliography  Save this article

Transformers Improvement and Environment Conservation by Using Synthetic Esters in Egypt

Author

Listed:
  • Ali A. Radwan

    (Electrical Engineering Department, Faculty of Engineering, Minia University, Minia 61517, Egypt
    Egyptian Electricity Holding Company, Middle Egypt DisCo., Minia 61111, Egypt)

  • Ahmed A. Zaki Diab

    (Electrical Engineering Department, Faculty of Engineering, Minia University, Minia 61517, Egypt)

  • Abo-Hashima M. Elsayed

    (Electrical Engineering Department, Faculty of Engineering, Minia University, Minia 61517, Egypt)

  • Yehya S. Mohamed

    (Electrical Engineering Department, Faculty of Engineering, Minia University, Minia 61517, Egypt)

  • Hassan Haes Alhelou

    (School of Electrical and Electronic Engineering, University College Dublin, Dublin 4, Ireland)

  • Pierluigi Siano

    (Department of Management and Innovation Systems, University of Salerno, 84084 Salerno, Italy)

Abstract

Distribution transformer (DT) is a crucial component in power systems as it exchanges energies between different voltage levels or between utility grid and DC microgrids. Nevertheless, the operation of an oil-immersed DT is limited by the thermal and electrical capabilities of the internal insulating liquid. This paper aims to raise the efficiency of distribution transformers and preserve the environment by using a biodegradable insulating liquid instead of the conventional mineral insulating oil (MIO). This work examines the Egyptian case, where a real distribution network located in middle Egypt is selected as a pilot project. Study and analysis of the status que of the insulation system inside DTs are done with the aid of fault-tree analysis. The deficiency of the insulation system is confirmed by conducting an electronic survey of 100 expert participants. The most appropriate solution among three different alternatives is confirmed using the weighting and ranking method. The best choice suitable for the selected area is the substitution of MIO by synthetic ester (SE). The technical and environmental advantages achieved by the presented solution are discussed. The feasibility studies have proven that the solution is positively acceptable in all aspects. An execution plan is established for the application of proposed solution on the selected Egyptian distribution network.

Suggested Citation

  • Ali A. Radwan & Ahmed A. Zaki Diab & Abo-Hashima M. Elsayed & Yehya S. Mohamed & Hassan Haes Alhelou & Pierluigi Siano, 2021. "Transformers Improvement and Environment Conservation by Using Synthetic Esters in Egypt," Energies, MDPI, vol. 14(7), pages 1-15, April.
    • Handle: RePEc:gam:jeners:v:14:y:2021:i:7:p:1992-:d:529889
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/14/7/1992/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/14/7/1992/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Xiaobo Wang & Chao Tang & Bo Huang & Jian Hao & George Chen, 2018. "Review of Research Progress on the Electrical Properties and Modification of Mineral Insulating Oils Used in Power Transformers," Energies, MDPI, vol. 11(3), pages 1-31, February.
    2. Ali A. Radwan & Ahmed A. Zaki Diab & Abo-Hashima M. Elsayed & Hassan Haes Alhelou & Pierluigi Siano, 2020. "Active Distribution Network Modeling for Enhancing Sustainable Power System Performance; a Case Study in Egypt," Sustainability, MDPI, vol. 12(21), pages 1-22, October.
    3. Ahn, Byeong Seok, 2017. "Approximate weighting method for multiattribute decision problems with imprecise parameters," Omega, Elsevier, vol. 72(C), pages 87-95.
    4. Radek Doskočil & Branislav Lacko, 2019. "Root Cause Analysis in Post Project Phases as Application of Knowledge Management," Sustainability, MDPI, vol. 11(6), pages 1-15, March.
    5. Dominika Szcześniak & Piotr Przybylek, 2021. "Oxidation Stability of Natural Ester Modified by Means of Fullerene Nanoparticles," Energies, MDPI, vol. 14(2), pages 1-13, January.
    6. Pawel Rozga & Abderrahmane Beroual & Piotr Przybylek & Maciej Jaroszewski & Konrad Strzelecki, 2020. "A Review on Synthetic Ester Liquids for Transformer Applications," Energies, MDPI, vol. 13(23), pages 1-33, December.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Teresa Nogueira & José Carvalho & José Magano, 2022. "Eco-Friendly Ester Fluid for Power Transformers versus Mineral Oil: Design Considerations," Energies, MDPI, vol. 15(15), pages 1-18, July.
    2. Maciej Zdanowski, 2022. "Streaming Electrification of C 60 Fullerene Doped Insulating Liquids for Power Transformers Applications," Energies, MDPI, vol. 15(7), pages 1-14, March.
    3. Miloš Šárpataky & Juraj Kurimský & Michal Rajňák & Michal Krbal & Marek Adamčák, 2022. "Dielectric Performance of Natural- and Synthetic-Ester-Based Nanofluids with Fullerene Nanoparticles," Energies, MDPI, vol. 16(1), pages 1-15, December.
    4. Łukasz Nagi & Mateusz Bogacz, 2023. "Statistical Analysis of Breakdown Voltage of Insulating Liquid Dopped with Surfactants," Energies, MDPI, vol. 16(3), pages 1-23, January.
    5. Arputhasamy Joseph Amalanathan & Ramanujam Sarathi & Maciej Zdanowski, 2023. "A Critical Overview of the Impact of Nanoparticles in Ester Fluid for Power Transformers," Energies, MDPI, vol. 16(9), pages 1-24, April.
    6. Piotr Przybylek, 2023. "Determination of Mineral Oil Concentration in the Mixture with Synthetic Ester Using Near-Infrared Spectroscopy," Energies, MDPI, vol. 16(17), pages 1-12, September.
    7. Suhaib Ahmad Khan & Mohd Tariq & Asfar Ali Khan & Shabana Urooj & Lucian Mihet-Popa, 2022. "An Experimental Study and Statistical Analysis on the Electrical Properties of Synthetic Ester-Based Nanofluids," Energies, MDPI, vol. 15(23), pages 1-14, December.
    8. Stephanie Azlyn Anak Felix & Muhamad Faiz Md Din & Asnor Mazuan Ishak & Jianli Wang & Nurul Hayati Idris & Wan Fathul Hakim Wan Zamri, 2023. "Investigation of the Electrical Properties of Mineral Oils with and without Carbon Nanotube Concentration under Different Magnetic Fields Applied in Transformer Applications," Energies, MDPI, vol. 16(8), pages 1-15, April.
    9. Mohammad Kharezy & Hassan Reza Mirzaei & Torbjörn Thiringer & Yuriy V. Serdyuk, 2022. "Green Solution for Insulation System of a Medium Frequency High Voltage Transformer for an Offshore Wind Farm," Energies, MDPI, vol. 15(6), pages 1-21, March.
    10. Peter Makeen & Hani A. Ghali & Saim Memon & Fang Duan, 2023. "Insightful Electric Vehicle Utility Grid Aggregator Methodology Based on the G2V and V2G Technologies in Egypt," Sustainability, MDPI, vol. 15(2), pages 1-14, January.
    11. Mehmet Ali Dereli & Emre Tercan, 2021. "Comparison of GIS-based surrogate weighting methods for multi-directional landfill site selection in West Mediterranean Planning Region in Turkey," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 23(3), pages 3438-3457, March.
    12. Leila Safiddine & Hadj-Ziane Zafour & Ungarala Mohan Rao & Issouf Fofana, 2019. "Regeneration of Transformer Insulating Fluids Using Membrane Separation Technology," Energies, MDPI, vol. 12(3), pages 1-13, January.
    13. Pawel Rozga & Filip Stuchala & Tomasz Piotrowski & Abderrahmane Beroual, 2022. "Influence of Temperature on Lightning Performance of Mineral Oil," Energies, MDPI, vol. 15(3), pages 1-11, January.
    14. Kakou D. Kouassi & Issouf Fofana & Ladji Cissé & Yazid Hadjadj & Kouba M. Lucia Yapi & K. Ambroise Diby, 2018. "Impact of Low Molecular Weight Acids on Oil Impregnated Paper Insulation Degradation," Energies, MDPI, vol. 11(6), pages 1-13, June.
    15. Maciej Zdanowski, 2020. "Streaming Electrification of Nycodiel 1255 Synthetic Ester and Trafo EN Mineral Oil Mixtures by Using Rotating Disc Method," Energies, MDPI, vol. 13(23), pages 1-14, November.
    16. Bo Gao & Rui Yu & Guangcai Hu & Cheng Liu & Xin Zhuang & Peng Zhou, 2019. "Development Processes of Surface Trucking and Partial Discharge of Pressboards Immersed in Mineral Oil: Effect of Tip Curvatures," Energies, MDPI, vol. 12(3), pages 1-14, February.
    17. Piotr Przybylek & Hubert Moranda & Hanna Moscicka-Grzesiak & Dominika Szczesniak, 2019. "Application of Synthetic Ester for Drying Distribution Transformer Insulation—The Influence of Cellulose Thickness on Drying Efficiency," Energies, MDPI, vol. 12(20), pages 1-16, October.
    18. Shahid Nawaz Khan & Syed Ali Abbas Kazmi & Abdullah Altamimi & Zafar A. Khan & Mohammed A. Alghassab, 2022. "Smart Distribution Mechanisms—Part I: From the Perspectives of Planning," Sustainability, MDPI, vol. 14(23), pages 1-109, December.
    19. Pawel Zukowski & Przemyslaw Rogalski & Vitalii Bondariev & Milan Sebok, 2022. "Diagnostics of High Water Content Paper-Oil Transformer Insulation Based on the Temperature and Frequency Dependencies of the Loss Tangent," Energies, MDPI, vol. 15(8), pages 1-16, April.
    20. Issouf Fofana & U. Mohan Rao, 2018. "Engineering Dielectric Liquid Applications," Energies, MDPI, vol. 11(10), pages 1-4, October.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:14:y:2021:i:7:p:1992-:d:529889. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.