IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v13y2020i4p1006-d324478.html
   My bibliography  Save this article

Thermodynamic and Economic Analysis of Trigeneration System Comprising a Hierarchical Gas-Gas Engine for Production of Electricity, Heat and Cold

Author

Listed:
  • Ryszard Bartnik

    (Department of Power Management, Faculty of Production Engineering and Logistics, Opole University of Technology, 76 Prószkowska str., 45-768 Opole, Poland)

  • Zbigniew Buryn

    (Department of Power Management, Faculty of Production Engineering and Logistics, Opole University of Technology, 76 Prószkowska str., 45-768 Opole, Poland)

  • Anna Hnydiuk-Stefan

    (Department of Power Management, Faculty of Production Engineering and Logistics, Opole University of Technology, 76 Prószkowska str., 45-768 Opole, Poland)

  • Waldemar Skomudek

    (Department of Power Management, Faculty of Production Engineering and Logistics, Opole University of Technology, 76 Prószkowska str., 45-768 Opole, Poland)

  • Aleksandra Otawa

    (Department of Power Management, Faculty of Production Engineering and Logistics, Opole University of Technology, 76 Prószkowska str., 45-768 Opole, Poland)

Abstract

This paper presents the results of analysis of energy and economic efficiency of the hierarchical gas-gas engine, with a note that a trigeneration system was analyzed, in which the production of electricity, heat and cold are combined. This solution significantly increases the energy efficiency of the gas and gas system compared to a system without cold production. The analysis includes a system comprising a compressor chiller which is driven by an electric motor in the system, as well as a system applying the mechanical work that is carried out via a rotating shaft of rotor-based machines, i.e., a gas turbine and a turboexpander. The comfort of the regulation of the refrigerating power rather promotes the use of a solution including an electric motor. Analysis contains also a schematic diagram of the system with a absorption chiller, which is driven by low-temperature enthalpy of exhaust gases extracted from a hierarchical gas-gas engine. Application of turboexpander with heat regeneration in the trigeneration system is also analyzed. Based on the multi-variant economic and thermodynamic calculations, the most favorable system variant was determined using, among others, the specific cost of cold production.

Suggested Citation

  • Ryszard Bartnik & Zbigniew Buryn & Anna Hnydiuk-Stefan & Waldemar Skomudek & Aleksandra Otawa, 2020. "Thermodynamic and Economic Analysis of Trigeneration System Comprising a Hierarchical Gas-Gas Engine for Production of Electricity, Heat and Cold," Energies, MDPI, vol. 13(4), pages 1-33, February.
    • Handle: RePEc:gam:jeners:v:13:y:2020:i:4:p:1006-:d:324478
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/13/4/1006/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/13/4/1006/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Benedetto Conte & Joan Carles Bruno & Alberto Coronas, 2016. "Optimal Cooling Load Sharing Strategies for Different Types of Absorption Chillers in Trigeneration Plants," Energies, MDPI, vol. 9(8), pages 1-16, July.
    2. Bartnik, Ryszard & Hnydiuk-Stefan, Anna & Buryn, Zbigniew, 2020. "Thermodynamic and economic analysis of a gas turbine set coupled with a turboexpander in a hierarchical gas-gas system," Energy, Elsevier, vol. 190(C).
    3. Karol Sztekler & Wojciech Kalawa & Lukasz Mika & Jaroslaw Krzywanski & Karolina Grabowska & Marcin Sosnowski & Wojciech Nowak & Tomasz Siwek & Artur Bieniek, 2020. "Modeling of a Combined Cycle Gas Turbine Integrated with an Adsorption Chiller," Energies, MDPI, vol. 13(3), pages 1-12, January.
    4. Dabwan, Yousef N. & Pei, Gang, 2020. "A novel integrated solar gas turbine trigeneration system for production of power, heat and cooling: Thermodynamic-economic-environmental analysis," Renewable Energy, Elsevier, vol. 152(C), pages 925-941.
    5. Khairulnadzmi Jamaluddin & Sharifah Rafidah Wan Alwi & Zainuddin Abdul Manan & Khaidzir Hamzah & Jiří Jaromír Klemeš, 2019. "A Process Integration Method for Total Site Cooling, Heating and Power Optimisation with Trigeneration Systems," Energies, MDPI, vol. 12(6), pages 1-34, March.
    6. Robert Zarzycki & Andrzej Kacprzak & Zbigniew Bis, 2018. "The Use of Direct Carbon Fuel Cells in Compact Energy Systems for the Generation of Electricity, Heat and Cold," Energies, MDPI, vol. 11(11), pages 1-11, November.
    7. Chris Underwood & Bobo Ng & Francis Yik, 2015. "Scheduling of Multiple Chillers in Trigeneration Plants," Energies, MDPI, vol. 8(10), pages 1-25, October.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Tong Xin & Guolai Yang & Liqun Wang & Quanzhao Sun, 2020. "Numerical Calculation and Uncertain Optimization of Energy Conversion in Interior Ballistics Stage," Energies, MDPI, vol. 13(21), pages 1-21, November.
    2. Bartnik, Ryszard & Buryn, Zbigniew & Hnydiuk-Stefan, Anna & Kowalczyk, Tomasz, 2022. "Thermodynamic and economic comparative analyses of a hierarchic gas-gas combined heat and power (CHP) plant coupled with a compressor heat pump," Energy, Elsevier, vol. 244(PB).
    3. Evangelos Bellos & Christos Tzivanidis, 2020. "Parametric Investigation of a Trigeneration System with an Organic Rankine Cycle and Absorption Heat Pump Driven by Parabolic Trough Collectors for the Building Sector," Energies, MDPI, vol. 13(7), pages 1-26, April.
    4. Serhiy Serbin & Mykola Radchenko & Anatoliy Pavlenko & Kateryna Burunsuz & Andrii Radchenko & Daifen Chen, 2023. "Improving Ecological Efficiency of Gas Turbine Power System by Combusting Hydrogen and Hydrogen-Natural Gas Mixtures," Energies, MDPI, vol. 16(9), pages 1-23, April.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Yang, Dechang & Wang, Ming & Yang, Ruiqi & Zheng, Yingying & Pandzic, Hrvoje, 2021. "Optimal dispatching of an energy system with integrated compressed air energy storage and demand response," Energy, Elsevier, vol. 234(C).
    2. Afzali, Sayyed Faridoddin & Mahalec, Vladimir, 2017. "Optimal design, operation and analytical criteria for determining optimal operating modes of a CCHP with fired HRSG, boiler, electric chiller and absorption chiller," Energy, Elsevier, vol. 139(C), pages 1052-1065.
    3. Alipour, Mehran & Deymi-Dashtebayaz, Mahdi & Asadi, Mostafa, 2023. "Investigation of energy, exergy, and economy of co-generation system of solar electricity and cooling using linear parabolic collector for a data center," Energy, Elsevier, vol. 279(C).
    4. Gheorghe Dumitrașcu & Michel Feidt & Ştefan Grigorean, 2021. "Finite Physical Dimensions Thermodynamics Analysis and Design of Closed Irreversible Cycles," Energies, MDPI, vol. 14(12), pages 1-19, June.
    5. Jolanta Telenga-Kopyczyńska & Izabela Jonek-Kowalska, 2021. "Algorithm for Selecting Best Available Techniques in Polish Coking Plants Supporting Multi-Criteria Investment Decisions in European Environmental Conditions," Energies, MDPI, vol. 14(9), pages 1-24, May.
    6. Sheykhi, Mohammad & Chahartaghi, Mahmood & Safaei Pirooz, Amir Ali & Flay, Richard G.J., 2020. "Investigation of the effects of operating parameters of an internal combustion engine on the performance and fuel consumption of a CCHP system," Energy, Elsevier, vol. 211(C).
    7. Dabwan, Yousef N. & Zhang, Liang & Pei, Gang, 2023. "A novel inlet air cooling system to improve the performance of intercooled gas turbine combined cycle power plants in hot regions," Energy, Elsevier, vol. 283(C).
    8. Marco Pellegrini & Augusto Bianchini, 2018. "The Innovative Concept of Cold District Heating Networks: A Literature Review," Energies, MDPI, vol. 11(1), pages 1-16, January.
    9. Calise, Francesco & de Notaristefani di Vastogirardi, Giulio & Dentice d'Accadia, Massimo & Vicidomini, Maria, 2018. "Simulation of polygeneration systems," Energy, Elsevier, vol. 163(C), pages 290-337.
    10. Jamaluddin, Khairulnadzmi & Wan Alwi, Sharifah Rafidah & Abd Manan, Zainuddin & Hamzah, Khaidzir & Klemeš, Jiří Jaromír, 2022. "Design of Total Site-Integrated TrigenerationSystem using trigeneration cascade analysis considering transmission losses and sensitivity analysis," Energy, Elsevier, vol. 252(C).
    11. Alkasmoul, Fahad & Asaker, Mohammed & Widuch, Aleksander & Malicki, Marcin & Zwierzchowski, Ryszard & Wołowicz, Marcin, 2023. "Multigeneration source based on novel triple-component chiller configuration co-supplied with renewable and fossil energy operated in Arabic Peninsula conditions," Energy, Elsevier, vol. 263(PC).
    12. Renos Rotas & Petros Iliadis & Nikos Nikolopoulos & Ananias Tomboulides & Elias Kosmatopoulos, 2022. "Dynamic Simulation and Performance Enhancement Analysis of a Renewable Driven Trigeneration System," Energies, MDPI, vol. 15(10), pages 1-27, May.
    13. Akhtar Hussain & Van-Hai Bui & Hak-Man Kim & Yong-Hoon Im & Jae-Yong Lee, 2017. "Optimal Energy Management of Combined Cooling, Heat and Power in Different Demand Type Buildings Considering Seasonal Demand Variations," Energies, MDPI, vol. 10(6), pages 1-21, June.
    14. Bartnik, Ryszard & Buryn, Zbigniew & Hnydiuk-Stefan, Anna & Kowalczyk, Tomasz, 2022. "Thermodynamic and economic comparative analyses of a hierarchic gas-gas combined heat and power (CHP) plant coupled with a compressor heat pump," Energy, Elsevier, vol. 244(PB).
    15. Muhammad Usman & Muhammad Ali Ijaz Malik & Rehmat Bashir & Fahid Riaz & Muhammad Juniad Raza & Khubaib Suleman & Abd-ul Rehman & Waqar Muhammad Ashraf & Jaroslaw Krzywanski, 2022. "Enviro-Economic Assessment of HHO–CNG Mixture Utilization in Spark Ignition Engine for Performance and Environmental Sustainability," Energies, MDPI, vol. 15(21), pages 1-15, November.
    16. Francesco Calise & Massimo Dentice D’Accadia, 2016. "Simulation of Polygeneration Systems," Energies, MDPI, vol. 9(11), pages 1-9, November.
    17. Urbanucci, Luca & Bruno, Joan Carles & Testi, Daniele, 2019. "Thermodynamic and economic analysis of the integration of high-temperature heat pumps in trigeneration systems," Applied Energy, Elsevier, vol. 238(C), pages 516-533.
    18. Yi Dong & Jianmin Liu & Yanbin Liu & Xinyong Qiao & Xiaoming Zhang & Ying Jin & Shaoliang Zhang & Tianqi Wang & Qi Kang, 2020. "A RBFNN & GACMOO-Based Working State Optimization Control Study on Heavy-Duty Diesel Engine Working in Plateau Environment," Energies, MDPI, vol. 13(1), pages 1-24, January.
    19. Marcin Sosnowski & Jaroslaw Krzywanski & Norbert Skoczylas, 2022. "Adsorption Desalination and Cooling Systems: Advances in Design, Modeling and Performance," Energies, MDPI, vol. 15(11), pages 1-6, May.
    20. Konečná, Eva & Teng, Sin Yong & Máša, Vítězslav, 2020. "New insights into the potential of the gas microturbine in microgrids and industrial applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 134(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:13:y:2020:i:4:p:1006-:d:324478. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.