IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i11p2097-d236268.html
   My bibliography  Save this article

Experimental Study on Temperature Change and Crack Expansion of High Temperature Granite under Different Cooling Shock Treatments

Author

Listed:
  • Yan-Jun Shen

    (Geological Research Institute for Coal Green Mining, Xi’an University of Science and Technology, Xi’an 710054, China)

  • Xin Hou

    (School of Architecture and Civil Engineering, Xi’an University of Science and Technology, Xi’an 710054, China)

  • Jiang-Qiang Yuan

    (School of Architecture and Civil Engineering, Xi’an University of Science and Technology, Xi’an 710054, China)

  • Chun-Hu Zhao

    (Xi’an Research Institute Co. Ltd., China Coal Technology and Engineering Group Corp., Xi’an 710077, China)

Abstract

It is valuable to observe the influence of different cooling methods on the exploitation of geothermal energy and breaking hard rocks in deep geo-engineering. In this work, the effects of different cooling shock treatments on high temperature granite are discussed. First, perforated 100-mm-side cubic biotite adamellite samples were heated to four targeted temperatures (150 °C, 350 °C, 550 °C, and 750 °C). Then, anti-freeze solutions were compounded to produce the different cooling shock effects (20 °C, 0 °C, and −30 °C) by adjusting the calcium chloride solution concentration, and these anti-freeze solutions were injected rapidly into the holes to reflect the rapid cooling shock of high-temperature granite. Finally, the temperature variations and crack expansions of high-temperature granite under different cooling shock treatments were analyzed and the cooling shock cracking mechanism is discussed briefly. The main results can be summarized as: (1) The high temperature granite exposed to the cooling shock exhibited a "rapid cooling + rapid heating" change during the first 5 min. Due to the cooling shock, the total temperature was significantly lower than the natural cooling until 120 min later. (2) Below 350 °C, the macrocracking effect was not significant, and the sample reflected a certain range of uniform microcracks around the injection hole, while the macrocracks tended to be obvious above 550 °C. Moreover, as the refrigerant temperature decreased, the local distribution characteristics of the macrocracking became more obvious. (3) Based on the analysis of the dynamic heat balance, the undulation and width of the cracks around the heat balance zone were stable, but the numbers and widths of cracks near the hole wall and the side of the sample were visibly increased. This study extends our understanding of the influence of cooling shock on granite cracking.

Suggested Citation

  • Yan-Jun Shen & Xin Hou & Jiang-Qiang Yuan & Chun-Hu Zhao, 2019. "Experimental Study on Temperature Change and Crack Expansion of High Temperature Granite under Different Cooling Shock Treatments," Energies, MDPI, vol. 12(11), pages 1-17, May.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:11:p:2097-:d:236268
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/11/2097/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/11/2097/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Guo, Liang-Liang & Zhang, Yong-Bo & Zhang, Yan-Jun & Yu, Zi-Wang & Zhang, Jia-Ning, 2018. "Experimental investigation of granite properties under different temperatures and pressures and numerical analysis of damage effect in enhanced geothermal system," Renewable Energy, Elsevier, vol. 126(C), pages 107-125.
    2. Zhao, Yangsheng & Feng, Zijun & Xi, Baoping & Wan, Zhijun & Yang, Dong & Liang, Weiguo, 2015. "Deformation and instability failure of borehole at high temperature and high pressure in Hot Dry Rock exploitation," Renewable Energy, Elsevier, vol. 77(C), pages 159-165.
    3. Badulla Liyanage Avanthi Isaka & Ranjith Pathegama Gamage & Tharaka Dilanka Rathnaweera & Mandadige Samintha Anne Perera & Dornadula Chandrasekharam & Wanniarachchige Gnamani Pabasara Kumari, 2018. "An Influence of Thermally-Induced Micro-Cracking under Cooling Treatments: Mechanical Characteristics of Australian Granite," Energies, MDPI, vol. 11(6), pages 1-24, May.
    4. Hou, Jianchao & Cao, Mengchao & Liu, Pingkuo, 2018. "Development and utilization of geothermal energy in China: Current practices and future strategies," Renewable Energy, Elsevier, vol. 125(C), pages 401-412.
    5. Clauser, Christoph & Ewert, Markus, 2018. "The renewables cost challenge: Levelized cost of geothermal electric energy compared to other sources of primary energy – Review and case study," Renewable and Sustainable Energy Reviews, Elsevier, vol. 82(P3), pages 3683-3693.
    6. Yan-Jun Shen & Yu-Liang Zhang & Feng Gao & Geng-She Yang & Xing-Ping Lai, 2018. "Influence of Temperature on the Microstructure Deterioration of Sandstone," Energies, MDPI, vol. 11(7), pages 1-17, July.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Jizhe Guo & Zengchao Feng & Xuecheng Li, 2023. "Shear Strength and Energy Evolution of Granite under Real-Time Temperature," Sustainability, MDPI, vol. 15(11), pages 1-18, May.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Yang, Fujian & Wang, Guiling & Hu, Dawei & Liu, Yanguang & Zhou, Hui & Tan, Xianfeng, 2021. "Calibrations of thermo-hydro-mechanical coupling parameters for heating and water-cooling treated granite," Renewable Energy, Elsevier, vol. 168(C), pages 544-558.
    2. Wang, Yongzhen & Li, Chengjun & Zhao, Jun & Wu, Boyuan & Du, Yanping & Zhang, Jing & Zhu, Yilin, 2021. "The above-ground strategies to approach the goal of geothermal power generation in China: State of art and future researches," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).
    3. Peng Xiao & Jun Zheng & Bin Dou & Hong Tian & Guodong Cui & Muhammad Kashif, 2021. "Mechanical Behaviors of Granite after Thermal Shock with Different Cooling Rates," Energies, MDPI, vol. 14(13), pages 1-17, June.
    4. Ma, Cong & Cheok, Mui Yee & Chok, Nyen Vui, 2023. "Economic recovery through multisector management resources in small and medium businesses in China," Resources Policy, Elsevier, vol. 80(C).
    5. Li, Hui & Ni, Long & Yao, Yang & Sun, Cheng, 2020. "Annual performance experiments of an earth-air heat exchanger fresh air-handling unit in severe cold regions: Operation, economic and greenhouse gas emission analyses," Renewable Energy, Elsevier, vol. 146(C), pages 25-37.
    6. Ma, Cong & Cheok, Mui Yee, 2022. "The impact of financing role and organizational culture in small and medium enterprises: Developing business strategies for economic recovery," Economic Analysis and Policy, Elsevier, vol. 75(C), pages 26-38.
    7. Guo, Liang-Liang & Zhang, Yong-Bo & Wang, Zhi-Chao & Zeng, Jian & Zhang, Yan-Jun & Zhang, Zhi-Xiang, 2020. "Parameter sensitivity analysis and optimization strategy research of enhanced geothermal system: A case study in Guide Basin, Northwestern China," Renewable Energy, Elsevier, vol. 153(C), pages 813-831.
    8. Wang, Gang & Zhang, Zhen & Lin, Jianqing, 2024. "Multi-energy complementary power systems based on solar energy: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 199(C).
    9. Ma, Sining & Guo, Siyue & Zheng, Dingqian & Chang, Shiyan & Zhang, Xiliang, 2021. "Roadmap towards clean and low carbon heating to 2035: A provincial analysis in northern China," Energy, Elsevier, vol. 225(C).
    10. Yujiang He & Xianbiao Bu, 2020. "Performance of Hybrid Single Well Enhanced Geothermal System and Solar Energy for Buildings Heating," Energies, MDPI, vol. 13(10), pages 1-10, May.
    11. Chang, Lei & Gan, Xiaojun & Mohsin, Muhammad, 2022. "Studying corporate liquidity and regulatory responses for economic recovery in COVID-19 crises," Economic Analysis and Policy, Elsevier, vol. 76(C), pages 211-225.
    12. Esmaeilpour, Morteza & Gholami Korzani, Maziar & Kohl, Thomas, 2023. "Stochastic performance assessment on long-term behavior of multilateral closed deep geothermal systems," Renewable Energy, Elsevier, vol. 208(C), pages 26-35.
    13. Moore, Kayla R. & Holländer, Hartmut M., 2020. "Feasibility of low-temperature geothermal systems: Considerations of thermal anomalies, geochemistry, and local assets," Applied Energy, Elsevier, vol. 275(C).
    14. Chao Yu & Tian Tian & Chengyu Hui & Haochen Huang & Yiqun Zhang, 2022. "Study on Unblocking and Permeability Enhancement Technology with Rotary Water Jet for Low Recharge Efficiency Wells in Sandstone Geothermal Reservoirs," Energies, MDPI, vol. 15(24), pages 1-21, December.
    15. Yibo Wang & Lijuan Wang & Yang Bai & Zhuting Wang & Jie Hu & Di Hu & Yaqi Wang & Shengbiao Hu, 2021. "Assessment of Geothermal Resources in the North Jiangsu Basin, East China, Using Monte Carlo Simulation," Energies, MDPI, vol. 14(2), pages 1-17, January.
    16. Yangchun Wu & Linqi Huang & Xibing Li & Yide Guo & Huilin Liu & Jiajun Wang, 2022. "Effects of Strain Rate and Temperature on Physical Mechanical Properties and Energy Dissipation Features of Granite," Mathematics, MDPI, vol. 10(9), pages 1-20, May.
    17. Chen, Yun & Ma, Guowei & Wang, Huidong & Li, Tuo & Wang, Yang & Sun, Zizheng, 2020. "Optimizing heat mining strategies in a fractured geothermal reservoir considering fracture deformation effects," Renewable Energy, Elsevier, vol. 148(C), pages 326-337.
    18. Mohamed Elgharib Gomah & Guichen Li & Changlun Sun & Jiahui Xu & Sen Yang & Jinghua Li, 2022. "On the Physical and Mechanical Responses of Egyptian Granodiorite after High-Temperature Treatments," Sustainability, MDPI, vol. 14(8), pages 1-22, April.
    19. Halilovic, Smajil & Böttcher, Fabian & Zosseder, Kai & Hamacher, Thomas, 2023. "Optimizing the spatial arrangement of groundwater heat pumps and their well locations," Renewable Energy, Elsevier, vol. 217(C).
    20. Anderson, Austin & Rezaie, Behnaz, 2019. "Geothermal technology: Trends and potential role in a sustainable future," Applied Energy, Elsevier, vol. 248(C), pages 18-34.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:11:p:2097-:d:236268. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.