IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v294y2024ics036054422400700x.html
   My bibliography  Save this article

A green and efficient lignite-fired power generation process based on superheated-steam-dried open pulverizing system

Author

Listed:
  • Ma, Youfu
  • Chi, Tonghui
  • Yu, Yi
  • Lyu, Junfu
  • Wang, Zirui

Abstract

Currently, lignite-fired boilers often feature low thermal efficiency, difficult coal pulverizing and poor combustion stability owing to lignite having high water content. A novel lignite-fired power generation process is proposed in this paper with using a superheated-steam-drying open-pulverizing-system boiler (SSD-OPSB) and a deep utilization of waste heat from the steam for coal drying. Through using an open pulverizing system, the problems of low furnace temperature and low boiler efficiency are resolved. Meanwhile, the operation safety of the coal pulverizing system is ensured by using superheated steam as the drying agent. This paper described the working principle and engineering feasibility of the SSD-OPSB process, and established analysis model for its thermo-economic performance. Energy savings and environmental benefits of applying the process were calculated and discussed based on an in-service 600 MW supercritical power unit firing lignite with water content of 39.5% at its turbine heat acceptance condition. The result shows that for the power unit, applying the SSD-OPSB process can decrease coal consumption by 6.86% under the same power supply, meanwhile recovering water by 132.2 t/h and reducing CO2 emission by 27.78 t/h. It indicates that the SSD-OPSB process would significantly benefit lignite-fired power plants regarding energy-saving and environmental protection.

Suggested Citation

  • Ma, Youfu & Chi, Tonghui & Yu, Yi & Lyu, Junfu & Wang, Zirui, 2024. "A green and efficient lignite-fired power generation process based on superheated-steam-dried open pulverizing system," Energy, Elsevier, vol. 294(C).
    • Handle: RePEc:eee:energy:v:294:y:2024:i:c:s036054422400700x
    DOI: 10.1016/j.energy.2024.130928
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S036054422400700X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2024.130928?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Li, Jie & Liang, Qian-Chao & Bennamoun, Lyes, 2016. "Superheated steam drying: Design aspects, energetic performances, and mathematical modeling," Renewable and Sustainable Energy Reviews, Elsevier, vol. 60(C), pages 1562-1583.
    2. Ma, Youfu & Yuan, Yichao & Jin, Jing & Zhang, Hua & Hu, Xiaohong & Shi, Dengyu, 2013. "An environment friendly and efficient lignite-fired power generation process based on a boiler with an open pulverizing system and the recovery of water from mill-exhaust," Energy, Elsevier, vol. 59(C), pages 105-115.
    3. Liu, Ming & Yan, JunJie & Chong, DaoTong & Liu, JiPing & Wang, JinShi, 2013. "Thermodynamic analysis of pre-drying methods for pre-dried lignite-fired power plant," Energy, Elsevier, vol. 49(C), pages 107-118.
    4. Ma, Youfu & Zhang, Hua & Yuan, Yichao & Wang, Zhiyun, 2015. "Optimization of a lignite-fired open pulverizing system boiler process based on variations in the drying agent composition," Energy, Elsevier, vol. 81(C), pages 304-316.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Han, Xiaoqu & Liu, Ming & Zhai, Mengxu & Chong, Daotong & Yan, Junjie & Xiao, Feng, 2015. "Investigation on the off-design performances of flue gas pre-dried lignite-fired power system integrated with waste heat recovery at variable external working conditions," Energy, Elsevier, vol. 90(P2), pages 1743-1758.
    2. Li, Yong & Wang, Yanhong & Cao, Lihua & Hu, Pengfei & Han, Wei, 2018. "Modeling for the performance evaluation of 600 MW supercritical unit operating No.0 high pressure heater," Energy, Elsevier, vol. 149(C), pages 639-661.
    3. Han, Xiaoqu & Liu, Ming & Wu, Kaili & Chen, Weixiong & Xiao, Feng & Yan, Junjie, 2016. "Exergy analysis of the flue gas pre-dried lignite-fired power system based on the boiler with open pulverizing system," Energy, Elsevier, vol. 106(C), pages 285-300.
    4. Han, Xiaoqu & Liu, Ming & Wang, Jinshi & Yan, Junjie & Liu, Jiping & Xiao, Feng, 2014. "Simulation study on lignite-fired power system integrated with flue gas drying and waste heat recovery – Performances under variable power loads coupled with off-design parameters," Energy, Elsevier, vol. 76(C), pages 406-418.
    5. Chantasiriwan, Somchart, 2021. "Optimum installation of flue gas dryer and additional air heater to increase the efficiency of coal-fired utility boiler," Energy, Elsevier, vol. 221(C).
    6. Ma, Youfu & Zhang, Hua & Yuan, Yichao & Wang, Zhiyun, 2015. "Optimization of a lignite-fired open pulverizing system boiler process based on variations in the drying agent composition," Energy, Elsevier, vol. 81(C), pages 304-316.
    7. Liu, Ming & Wu, Dongyin & Xiao, Feng & Yan, JunJie, 2015. "A novel lignite-fired power plant integrated with a vacuum dryer: System design and thermodynamic analysis," Energy, Elsevier, vol. 82(C), pages 968-975.
    8. Xu, Cheng & Xu, Gang & Zhao, Shifei & Zhou, Luyao & Yang, Yongping & Zhang, Dongke, 2015. "An improved configuration of lignite pre-drying using a supplementary steam cycle in a lignite fired supercritical power plant," Applied Energy, Elsevier, vol. 160(C), pages 882-891.
    9. Zbigniew Plutecki & Paweł Sattler & Krystian Ryszczyk & Anna Duczkowska & Stanisław Anweiler, 2020. "Thermokinetics of Brown Coal during a Fluidized Drying Process," Energies, MDPI, vol. 13(3), pages 1-16, February.
    10. Li, Zixiang & Miao, Zhengqing & Shen, Xusheng & Li, Jiangtao, 2018. "Prevention of boiler performance degradation under large primary air ratio scenario in a 660 MW brown coal boiler," Energy, Elsevier, vol. 155(C), pages 474-483.
    11. Han, Yu & Sun, Yingying & Wu, Junjie, 2023. "A novel solar-driven waste heat recovery system in solar-fuel hybrid power plants," Energy, Elsevier, vol. 285(C).
    12. Janusz Kotowicz & Sebastian Michalski & Mateusz Brzęczek, 2019. "The Characteristics of a Modern Oxy-Fuel Power Plant," Energies, MDPI, vol. 12(17), pages 1-34, September.
    13. Mondal, Md. Hasan Tarek & Sarker, Md. Sazzat Hossain, 2024. "Comprehensive energy analysis and environmental sustainability of industrial grain drying," Renewable and Sustainable Energy Reviews, Elsevier, vol. 199(C).
    14. Liu, Ming & Wang, Shan & Yan, Junjie, 2021. "Operation scheduling of a coal-fired CHP station integrated with power-to-heat devices with detail CHP unit models by particle swarm optimization algorithm," Energy, Elsevier, vol. 214(C).
    15. Ullah, Habib & Liu, Guijian & Yousaf, Balal & Ali, Muhammad Ubaid & Abbas, Qumber & Zhou, Chuncai & Rashid, Audil, 2018. "Hydrothermal dewatering of low-rank coals: Influence on the properties and combustion characteristics of the solid products," Energy, Elsevier, vol. 158(C), pages 1192-1203.
    16. Li, Zixiang & Miao, Zhengqing & Shen, Xusheng & Li, Jiangtao, 2018. "Effects of momentum ratio and velocity difference on combustion performance in lignite-fired pulverized boiler," Energy, Elsevier, vol. 165(PA), pages 825-839.
    17. Karasmanaki, Evangelia & Ioannou, Konstantinos & Katsaounis, Konstantinos & Tsantopoulos, Georgios, 2020. "The attitude of the local community towards investments in lignite before transitioning to the post-lignite era: The case of Western Macedonia, Greece," Resources Policy, Elsevier, vol. 68(C).
    18. Atsonios, K. & Violidakis, I. & Sfetsioris, K. & Rakopoulos, D.C. & Grammelis, P. & Kakaras, E., 2016. "Pre-dried lignite technology implementation in partial load/low demand cases for flexibility enhancement," Energy, Elsevier, vol. 96(C), pages 427-436.
    19. Jiayou Liu & Xiaoyun Gong & Wenhua Zhang & Fengzhong Sun & Qingbiao Wang, 2020. "Experimental Study on a Flue Gas Waste Heat Cascade Recovery System under Variable Working Conditions," Energies, MDPI, vol. 13(2), pages 1-19, January.
    20. Anna Sciazko & Yosuke Komatsu & Marcin Zakrzewski & Taro Akiyama & Akira Hashimoto & Naoki Shikazono & Shozo Kaneko & Shinji Kimijima & Janusz S. Szmyd & Yoshinori Kobayashi, 2016. "Experimental Attempts to Investigate the Influence of Petrographic Properties on Drying Characteristics of Lignite in Superheated Steam Atmosphere," Energies, MDPI, vol. 9(5), pages 1-18, May.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:294:y:2024:i:c:s036054422400700x. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.