IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v260y2020ics0306261919318902.html
   My bibliography  Save this article

Experimental evaluation on co-combustion characteristics of semi-coke and coal under enhanced high-temperature and strong-reducing atmosphere

Author

Listed:
  • Wang, Pengqian
  • Wang, Chang'an
  • Yuan, Maobo
  • Wang, Chaowei
  • Zhang, Jinping
  • Du, Yongbo
  • Tao, Zichen
  • Che, Defu

Abstract

Co-combustion of coal pyrolysis semi-coke and coal can be a promising approach for large-scale utilization of the high-grade carbon-based product with ultra-low volatiles content. In this paper, experimental evaluation on co-combustion characteristics of semi-coke and coal was conducted with a focus on combustion and NOx formation characteristics using a high-temperature (up to 1873 K) vertical tandem-type drop-tube furnace. A novel technology of enhanced high temperature and strong reducing atmosphere (HT&SRA) was proposed, and the effects of fuel type, blending ratio, blending method were evaluated. More NOx and unburned carbon were produced during combustion of semi-coke than bituminous coal. The combustion characteristics of semi-coke were improved by the addition of more bituminous coal due to interaction. The in-furnace blending method had advantage over out-blending method on the improvement of combustion and NOx reduction. Both NOx formation and unburned carbon first declined and then increased with the delayed injection of bituminous coal. When the stoichiometric ratio in primary zone (SR1) is lower than 1.0, the higher temperature (T1) led to more NOx formation, which was contrary in the oxidizing atmosphere. The parameters of T1 = 1873 K and 0.6 ≤ SR1 ≤ 0.8 were recommended as HT&SRA for the co-combustion. The enhanced HT&SRA was obtained by the approach of increasing oxygen fraction of secondary air (Osa) with the reasonable SR1, and the NOx formation was fortunately further reduced. The parameters of SR1 = 0.8 and Osa = 84% were suggested for the co-combustion. The approach of increasing oxygen faction of over-fire air is an alternative to further improve combustion characteristic due to the acceptable increase of NOx formation. The oxygen fraction of primary air should be limited to 42% to avoid excess NOx formation.

Suggested Citation

  • Wang, Pengqian & Wang, Chang'an & Yuan, Maobo & Wang, Chaowei & Zhang, Jinping & Du, Yongbo & Tao, Zichen & Che, Defu, 2020. "Experimental evaluation on co-combustion characteristics of semi-coke and coal under enhanced high-temperature and strong-reducing atmosphere," Applied Energy, Elsevier, vol. 260(C).
    • Handle: RePEc:eee:appene:v:260:y:2020:i:c:s0306261919318902
    DOI: 10.1016/j.apenergy.2019.114203
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261919318902
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2019.114203?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Mosqueda, Alexander & Wei, Juntao & Medrano, Katleya & Gonzales, Hazel & Ding, Lu & Yu, Guangsuo & Yoshikawa, Kunio, 2019. "Co-gasification reactivity and synergy of banana residue hydrochar and anthracite coal blends," Applied Energy, Elsevier, vol. 250(C), pages 92-97.
    2. Wang, Chang'an & Wu, Song & Lv, Qiang & Liu, Xuan & Chen, Wufeng & Che, Defu, 2017. "Study on correlations of coal chemical properties based on database of real-time data," Applied Energy, Elsevier, vol. 204(C), pages 1115-1123.
    3. Fan, Weidong & Li, Yu & Guo, Qinghong & Chen, Can & Wang, Yong, 2017. "Coal-nitrogen release and NOx evolution in the oxidant-staged combustion of coal," Energy, Elsevier, vol. 125(C), pages 417-426.
    4. Xie, Candie & Liu, Jingyong & Zhang, Xiaochun & Xie, Wuming & Sun, Jian & Chang, Kenlin & Kuo, Jiahong & Xie, Wenhao & Liu, Chao & Sun, Shuiyu & Buyukada, Musa & Evrendilek, Fatih, 2018. "Co-combustion thermal conversion characteristics of textile dyeing sludge and pomelo peel using TGA and artificial neural networks," Applied Energy, Elsevier, vol. 212(C), pages 786-795.
    5. Burra, K.G. & Gupta, A.K., 2018. "Kinetics of synergistic effects in co-pyrolysis of biomass with plastic wastes," Applied Energy, Elsevier, vol. 220(C), pages 408-418.
    6. Xu, Mingxin & Li, Shiyuan & Wu, Yinghai & Jia, Lufei & Lu, Qinggang, 2017. "The characteristics of recycled NO reduction over char during oxy-fuel fluidized bed combustion," Applied Energy, Elsevier, vol. 190(C), pages 553-562.
    7. Li, Sen & Xu, Tongmo & Hui, Shien & Wei, Xiaolin, 2009. "NOx emission and thermal efficiency of a 300Â MWe utility boiler retrofitted by air staging," Applied Energy, Elsevier, vol. 86(9), pages 1797-1803, September.
    8. Xu, Mingxin & Li, Shiyuan & Wu, Yinghai & Jia, Lufei, 2017. "Reduction of recycled NO over char during oxy-fuel fluidized bed combustion: Effects of operating parameters," Applied Energy, Elsevier, vol. 199(C), pages 310-322.
    9. Pawlak-Kruczek, Halina & Ostrycharczyk, Michał & Czerep, Michał & Baranowski, Marcin & Zgóra, Jacek, 2015. "Examinations of the process of hard coal and biomass blend combustion in OEA (oxygen enriched atmosphere)," Energy, Elsevier, vol. 92(P1), pages 40-46.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Jiahang Zhang & Jianguo Zhu & Jingzhang Liu, 2023. "Preheating Analysis of Semi-Coke in a Circulating Fluidized Bed and Its Kinetic Characteristics," Energies, MDPI, vol. 16(10), pages 1-16, May.
    2. Wang, Chaowei & Wang, Chang'an & Luo, Maoyun & Zhao, Lin & Wang, Pengqian & Hou, Yujie & Zhao, Pengbo & Che, Defu, 2023. "Co-gasification behaviors of various coal-based solid fuels blends at initial stage of oxy-fuel Co-combustion," Energy, Elsevier, vol. 271(C).
    3. Wang, Chaowei & Wang, Chang'an & Feng, Qinqin & Mao, Qisen & Gao, Xinyue & Du, Yongbo & Li, Guangyu & Che, Defu, 2022. "Experimental evaluation on NOx formation and burnout characteristics of oxy-fuel co-combustion of ultra-low volatile carbon-based solid fuels and bituminous coal," Energy, Elsevier, vol. 248(C).
    4. Wang, Chang'an & Zhao, Lin & Sun, Ruijin & Zhou, Lei & Jin, Liyan & Che, Defu, 2022. "Experimental study on NO emission and ash deposition during oxy-fuel combustion of high-alkali coal under oxygen-staged conditions," Energy, Elsevier, vol. 251(C).
    5. Qiao, Yanyu & Chen, Zhichao & Wu, Xiaolan & Li, Zhengqi, 2023. "Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses," Energy, Elsevier, vol. 269(C).
    6. Chen, Zhichao & Qiao, Yanyu & Guan, Shuo & Wang, Zhenwang & Zheng, Yu & Zeng, Lingyan & Li, Zhengqi, 2022. "Effect of inner and outer secondary air ratios on ignition, C and N conversion process of pulverized coal in swirl burner under sub-stoichiometric ratio," Energy, Elsevier, vol. 239(PD).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Engin, Berrin & Kayahan, Ufuk & Atakül, Hüsnü, 2020. "A comparative study on the air, the oxygen-enriched air and the oxy-fuel combustion of lignites in CFB," Energy, Elsevier, vol. 196(C).
    2. Chen, Zhichao & Qiao, Yanyu & Guan, Shuo & Wang, Zhenwang & Zheng, Yu & Zeng, Lingyan & Li, Zhengqi, 2022. "Effect of inner and outer secondary air ratios on ignition, C and N conversion process of pulverized coal in swirl burner under sub-stoichiometric ratio," Energy, Elsevier, vol. 239(PD).
    3. Zhao, Yijun & Feng, Dongdong & Li, Bowen & Wang, Pengxiang & Tan, Heping & Sun, Shaozeng, 2019. "Effects of flue gases (CO/CO2/SO2/H2O/O2) on NO-Char interaction at high temperatures," Energy, Elsevier, vol. 174(C), pages 519-525.
    4. Li, Zixiang & Miao, Zhengqing, 2019. "Primary air ratio affects coal utilization mode and NOx emission in lignite pulverized boiler," Energy, Elsevier, vol. 187(C).
    5. Zhang, Hai & Luo, Lei & Liu, Jiaxun & Jiao, Anyao & Liu, Jianguo & Jiang, Xiumin, 2019. "Theoretical study on the reduction reactions from solid char(N): The effect of the nearby group and the high-spin state," Energy, Elsevier, vol. 189(C).
    6. Wu, Hai-bo & Xu, Ming-xin & Li, Yan-bing & Wu, Jin-hua & Shen, Jian-chong & Liao, Haiyan, 2020. "Experimental research on the process of compression and purification of CO2 in oxy-fuel combustion," Applied Energy, Elsevier, vol. 259(C).
    7. Gürel, Barış & Kurtuluş, Karani & Yurdakul, Sema & Karaca Dolgun, Gülşah & Akman, Remzi & Önür, Muhammet Enes & Varol, Murat & Keçebaş, Ali & Gürbüz, Habib, 2024. "Combustion of chicken manure and Turkish lignite mixtures in a circulating fluidized bed," Renewable and Sustainable Energy Reviews, Elsevier, vol. 189(PA).
    8. Wen, Shaoting & Buyukada, Musa & Evrendilek, Fatih & Liu, Jingyong, 2020. "Uncertainty and sensitivity analyses of co-combustion/pyrolysis of textile dyeing sludge and incense sticks: Regression and machine-learning models," Renewable Energy, Elsevier, vol. 151(C), pages 463-474.
    9. Nawaz, Ahmad & Razzak, Shaikh Abdur, 2024. "Co-pyrolysis of biomass and different plastic waste to reduce hazardous waste and subsequent production of energy products: A review on advancement, synergies, and future prospects," Renewable Energy, Elsevier, vol. 224(C).
    10. Shahbeig, Hossein & Nosrati, Mohsen, 2020. "Pyrolysis of municipal sewage sludge for bioenergy production: Thermo-kinetic studies, evolved gas analysis, and techno-socio-economic assessment," Renewable and Sustainable Energy Reviews, Elsevier, vol. 119(C).
    11. Zhao, Jingyu & Deng, Jun & Wang, Tao & Song, Jiajia & Zhang, Yanni & Shu, Chi-Min & Zeng, Qiang, 2019. "Assessing the effectiveness of a high-temperature-programmed experimental system for simulating the spontaneous combustion properties of bituminous coal through thermokinetic analysis of four oxidatio," Energy, Elsevier, vol. 169(C), pages 587-596.
    12. Lei Han & Jinling Li & Chengtun Qu & Zhiguo Shao & Tao Yu & Bo Yang, 2022. "Recent Progress in Sludge Co-Pyrolysis Technology," Sustainability, MDPI, vol. 14(13), pages 1-12, June.
    13. Alam, Mahboob & Bhavanam, Anjireddy & Jana, Ashirbad & Viroja, Jaimin kumar S. & Peela, Nageswara Rao, 2020. "Co-pyrolysis of bamboo sawdust and plastic: Synergistic effects and kinetics," Renewable Energy, Elsevier, vol. 149(C), pages 1133-1145.
    14. Sajad Koochakinia & Amir Ebrahimi-Moghadam & Mahdi Deymi-Dashtebayaz, 2022. "Techno-Environmental Analyses and Optimization of a Utility Boiler Based on Real Data," Sustainability, MDPI, vol. 14(5), pages 1-19, February.
    15. Li, Shiyuan & Xu, Mingxin & Jia, Lufei & Tan, Li & Lu, Qinggang, 2016. "Influence of operating parameters on N2O emission in O2/CO2 combustion with high oxygen concentration in circulating fluidized bed," Applied Energy, Elsevier, vol. 173(C), pages 197-209.
    16. Chen, Yu-Kai & Lin, Cheng-Han & Wang, Wei-Cheng, 2020. "The conversion of biomass into renewable jet fuel," Energy, Elsevier, vol. 201(C).
    17. Bi, Haobo & Wang, Chengxin & Lin, Qizhao & Jiang, Xuedan & Jiang, Chunlong & Bao, Lin, 2020. "Combustion behavior, kinetics, gas emission characteristics and artificial neural network modeling of coal gangue and biomass via TG-FTIR," Energy, Elsevier, vol. 213(C).
    18. Li, Chao & Sun, Yifan & Yi, Zijun & Zhang, Lijun & Zhang, Shu & Hu, Xun, 2022. "Co-pyrolysis of coke bottle wastes with cellulose, lignin and sawdust: Impacts of the mixed feedstock on char properties," Renewable Energy, Elsevier, vol. 181(C), pages 1126-1139.
    19. Żaklin Grądz & Waldemar Wójcik & Konrad Gromaszek & Andrzej Kotyra & Saule Smailova & Aigul Iskakova & Bakhyt Yeraliyeva & Saule Kumargazhanova & Baglan Imanbek, 2023. "Application of Fuzzy Neural Networks in Combustion Process Diagnostics," Energies, MDPI, vol. 17(1), pages 1-19, December.
    20. Wu, Junnan & Liao, Yanfen & Lin, Yan & Tian, Yunlong & Ma, Xiaoqian, 2019. "Study on thermal decomposition kinetics model of sewage sludge and wheat based on multi distributed activation energy," Energy, Elsevier, vol. 185(C), pages 795-803.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:260:y:2020:i:c:s0306261919318902. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.