IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v79y2015icp38-44.html
   My bibliography  Save this article

Conversion of cassava rhizome using an in-situ catalytic drop tube reactor for fuel gas generation

Author

Listed:
  • Sornkade, Panchaluck
  • Atong, Duangduen
  • Sricharoenchaikul, Viboon

Abstract

The air-gasification of cassava rhizome mixed with Ni/α-Al2O3 catalyst in a drop tube reactor for production of fuel gas was carried out in this work. The conversion was performed at different temperatures from 873 to 1073 K, equivalence ratio (ER) of 0.2–0.6, and semi-continuous feeding of raw material for 30 min. Gas yields, cold gas efficiency (CGE) and lower heating value of fuel gas (LHV) were compared with non-catalytic cases. Generally, higher temperature and ER significantly improved the performance of cassava rhizome gasification. Similar for both of non-catalytic and catalytic cases, at optimum temperature of 1073 K and ER of 0.6, the maximum gas yields were closed to 80% while yields of char and tar were kept minimal at 4% and 11%, respectively. Addition of prepared catalysts resulted in greater CGE and LHV of 92% and 8.6 MJ/N m3, respectively, comparing to the non-catalytic case of 61% and 6.36 MJ/N m3, respectively. Moreover, the measured gas distribution data were comparable with the result obtained from thermodynamics conversion model based on minimization of Gibbs free energy of product gases using elemental composition of cassava rhizome (C3.13H5.2O3.52N0.03S0.04.) constrained by mass and energy balances for the system. As a result, the gas product distribution and characteristics obtained from this experimental implied its suitability for heat and power applications.

Suggested Citation

  • Sornkade, Panchaluck & Atong, Duangduen & Sricharoenchaikul, Viboon, 2015. "Conversion of cassava rhizome using an in-situ catalytic drop tube reactor for fuel gas generation," Renewable Energy, Elsevier, vol. 79(C), pages 38-44.
    • Handle: RePEc:eee:renene:v:79:y:2015:i:c:p:38-44
    DOI: 10.1016/j.renene.2014.07.043
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148114004418
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2014.07.043?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Loha, Chanchal & Chattopadhyay, Himadri & Chatterjee, Pradip K., 2011. "Thermodynamic analysis of hydrogen rich synthetic gas generation from fluidized bed gasification of rice husk," Energy, Elsevier, vol. 36(7), pages 4063-4071.
    2. Prins, Mark J. & Ptasinski, Krzysztof J. & Janssen, Frans J.J.G., 2007. "From coal to biomass gasification: Comparison of thermodynamic efficiency," Energy, Elsevier, vol. 32(7), pages 1248-1259.
    3. W. A. Wan Ab Karim Ghani & Reza Alipour Moghadam & M. A. Mohd Salleh & A. B. Alias, 2009. "Air Gasification of Agricultural Waste in a Fluidized Bed Gasifier: Hydrogen Production Performance," Energies, MDPI, vol. 2(2), pages 1-11, May.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Yu, Haimiao & Wu, Zilu & Chen, Geng, 2018. "Catalytic gasification characteristics of cellulose, hemicellulose and lignin," Renewable Energy, Elsevier, vol. 121(C), pages 559-567.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Loha, Chanchal & Gu, Sai & De Wilde, Juray & Mahanta, Pinakeswar & Chatterjee, Pradip K., 2014. "Advances in mathematical modeling of fluidized bed gasification," Renewable and Sustainable Energy Reviews, Elsevier, vol. 40(C), pages 688-715.
    2. Silva, Isabelly P. & Lima, Rafael M.A. & Silva, Gabriel F. & Ruzene, Denise S. & Silva, Daniel P., 2019. "Thermodynamic equilibrium model based on stoichiometric method for biomass gasification: A review of model modifications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 114(C), pages 1-1.
    3. Ramos, Ana & Monteiro, Eliseu & Rouboa, Abel, 2019. "Numerical approaches and comprehensive models for gasification process: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 110(C), pages 188-206.
    4. Gassner, Martin & Maréchal, François, 2009. "Thermodynamic comparison of the FICFB and Viking gasification concepts," Energy, Elsevier, vol. 34(10), pages 1744-1753.
    5. Balcombe, Paul & Speirs, Jamie & Johnson, Erin & Martin, Jeanne & Brandon, Nigel & Hawkes, Adam, 2018. "The carbon credentials of hydrogen gas networks and supply chains," Renewable and Sustainable Energy Reviews, Elsevier, vol. 91(C), pages 1077-1088.
    6. Loha, Chanchal & Chattopadhyay, Himadri & Chatterjee, Pradip K., 2011. "Thermodynamic analysis of hydrogen rich synthetic gas generation from fluidized bed gasification of rice husk," Energy, Elsevier, vol. 36(7), pages 4063-4071.
    7. Ngo, Son Ich & Nguyen, Thanh D.B. & Lim, Young-Il & Song, Byung-Ho & Lee, Uen-Do & Choi, Young-Tai & Song, Jae-Hun, 2011. "Performance evaluation for dual circulating fluidized-bed steam gasifier of biomass using quasi-equilibrium three-stage gasification model," Applied Energy, Elsevier, vol. 88(12), pages 5208-5220.
    8. María Pilar González-Vázquez & Roberto García & Covadonga Pevida & Fernando Rubiera, 2017. "Optimization of a Bubbling Fluidized Bed Plant for Low-Temperature Gasification of Biomass," Energies, MDPI, vol. 10(3), pages 1-16, March.
    9. van der Heijden, Harro & Ptasinski, Krzysztof J., 2012. "Exergy analysis of thermochemical ethanol production via biomass gasification and catalytic synthesis," Energy, Elsevier, vol. 46(1), pages 200-210.
    10. Hou, Rui & Zhang, Nachuan & Gao, Wei & Chen, Kang & Liu, Yongqiu, 2023. "Thermodynamic, environmental, and exergoeconomic feasibility analyses and optimization of biomass gasifier-solid oxide fuel cell boosting a doable-flash binary geothermal cycle; a novel trigeneration ," Energy, Elsevier, vol. 265(C).
    11. Jiang, Jianrong & Feng, Xiao, 2019. "Energy optimization of ammonia synthesis processes based on oxygen purity under different purification technologies," Energy, Elsevier, vol. 185(C), pages 819-828.
    12. Pérez, Nestor Proenza & Pedroso, Daniel Travieso & Machin, Einara Blanco & Antunes, Julio Santana & Tuna, Celso Eduardo & Silveira, José Luz, 2019. "Geometrical characteristics of sugarcane bagasse for being used as fuel in fluidized bed technologies," Renewable Energy, Elsevier, vol. 143(C), pages 1210-1224.
    13. Mazzoni, Luca & Janajreh, Isam & Elagroudy, Sherien & Ghenai, Chaouki, 2020. "Modeling of plasma and entrained flow co-gasification of MSW and petroleum sludge," Energy, Elsevier, vol. 196(C).
    14. Ravaghi-Ardebili, Zohreh & Manenti, Flavio & Corbetta, Michele & Pirola, Carlo & Ranzi, Eliseo, 2015. "Biomass gasification using low-temperature solar-driven steam supply," Renewable Energy, Elsevier, vol. 74(C), pages 671-680.
    15. Mendiburu, Andrés Z. & Carvalho, João A. & Coronado, Christian J.R., 2014. "Thermochemical equilibrium modeling of biomass downdraft gasifier: Stoichiometric models," Energy, Elsevier, vol. 66(C), pages 189-201.
    16. Lopez-Urionabarrenechea, A. & de Marco, I. & Caballero, B.M. & Adrados, A. & Laresgoiti, M.F., 2012. "Empiric model for the prediction of packaging waste pyrolysis yields," Applied Energy, Elsevier, vol. 98(C), pages 524-532.
    17. La Villetta, M. & Costa, M. & Massarotti, N., 2017. "Modelling approaches to biomass gasification: A review with emphasis on the stoichiometric method," Renewable and Sustainable Energy Reviews, Elsevier, vol. 74(C), pages 71-88.
    18. Sérgio Ferreira & Eliseu Monteiro & Paulo Brito & Cândida Vilarinho, 2019. "A Holistic Review on Biomass Gasification Modified Equilibrium Models," Energies, MDPI, vol. 12(1), pages 1-31, January.
    19. Nadia Cerone & Francesco Zimbardi, 2018. "Gasification of Agroresidues for Syngas Production," Energies, MDPI, vol. 11(5), pages 1-18, May.
    20. Md Tanvir Alam & Se-Won Park & Sang-Yeop Lee & Yean-Ouk Jeong & Anthony De Girolamo & Yong-Chil Seo & Hang Seok Choi, 2020. "Co-Gasification of Treated Solid Recovered Fuel Residue by Using Minerals Bed and Biomass Waste Blends," Energies, MDPI, vol. 13(8), pages 1-16, April.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:79:y:2015:i:c:p:38-44. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.