IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v289y2024ics0360544223034400.html
   My bibliography  Save this article

Investigation of effect of cooling water characteristics on flue gas condensation along vertical tube heat exchanger

Author

Listed:
  • Poškas, Robertas
  • Sirvydas, Arūnas
  • Mingilaitė, Laura
  • Poškas, Povilas
  • Jouhara, Hussam

Abstract

Flue gas condensing heat exchangers obtain the highest thermal efficiency of power boilers through the recovery of sensible and latent heat of condensation from flue gases containing certain amount of water vapor. Many parameters influence the operation of economizers, among them the amount of water vapor in the flue gas and cooling water parameters. This paper presents experimental results obtained for various local parameters of vertical tube bundle economizer when the flue gas water vapor mass fraction is 6 % and 14 % and when different cooling water inlet flow rates and temperatures are applied. The results showed that the change in the water flow rate had negligible effect on variation of the local flue gas and cooling water temperature along heat exchanger. However, its effect on the condensate flux and the local Nusselt number was significant. The cooling water temperature and, especially, water vapor mass fraction had a great impact on the average Nu number, but the effect of the flue gas Re number was less evident. It was determined that there exists a ratio of cooling water to flue gas mass flow rate, where the operation of the economizer is optimal in terms heat transfer and condensation efficiency.

Suggested Citation

  • Poškas, Robertas & Sirvydas, Arūnas & Mingilaitė, Laura & Poškas, Povilas & Jouhara, Hussam, 2024. "Investigation of effect of cooling water characteristics on flue gas condensation along vertical tube heat exchanger," Energy, Elsevier, vol. 289(C).
    • Handle: RePEc:eee:energy:v:289:y:2024:i:c:s0360544223034400
    DOI: 10.1016/j.energy.2023.130046
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544223034400
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2023.130046?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Miliauskas, G. & Maziukienė, M. & Jouhara, H. & Poškas, R., 2019. "Investigation of mass and heat transfer transitional processes of water droplets in wet gas flow in the framework of energy recovery technologies for biofuel combustion and flue gas removal," Energy, Elsevier, vol. 173(C), pages 740-754.
    2. Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Ragaišis, Valdas & Paukštaitis, Linas & Jouhara, Hussam & Mingilaitė, Laura, 2022. "Experimental investigations of water droplet transient phase changes in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 256(C).
    3. Jonynas, Rolandas & Puida, Egidijus & Poškas, Robertas & Paukštaitis, Linas & Jouhara, Hussam & Gudzinskas, Juozas & Miliauskas, Gintautas & Lukoševičius, Valdas, 2020. "Renewables for district heating: The case of Lithuania," Energy, Elsevier, vol. 211(C).
    4. Jouhara, Hussam & Nieto, Nerea & Egilegor, Bakartxo & Zuazua, Josu & González, Eva & Yebra, Ignacio & Igesias, Alfredo & Delpech, Bertrand & Almahmoud, Sulaiman & Brough, Daniel & Malinauskaite, Jurgi, 2023. "Waste heat recovery solution based on a heat pipe heat exchanger for the aluminium die casting industry," Energy, Elsevier, vol. 266(C).
    5. Lund, Henrik & Østergaard, Poul Alberg & Nielsen, Tore Bach & Werner, Sven & Thorsen, Jan Eric & Gudmundsson, Oddgeir & Arabkoohsar, Ahmad & Mathiesen, Brian Vad, 2021. "Perspectives on fourth and fifth generation district heating," Energy, Elsevier, vol. 227(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Munćan, Vladimir & Mujan, Igor & Macura, Dušan & Anđelković, Aleksandar S., 2024. "The state of district heating and cooling in Europe - A literature-based assessment," Energy, Elsevier, vol. 304(C).
    2. Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Poškas, Povilas & Balčius, Algimantas & Jouhara, Hussam, 2022. "The modeling of transient phase changes of water droplets in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 257(C).
    3. Miliauskas, Gintautas & Maziukienė, Monika & Poškas, Robertas & Jouhara, Hussam, 2024. "Peculiarities of thermal and energy state variation in phase change regimes of water droplets in radiating biofuel flue gas flow," Energy, Elsevier, vol. 307(C).
    4. Steinegger, Josef & Hammer, Andreas & Wallner, Stefan & Kienberger, Thomas, 2024. "Revolutionizing heat distribution: A method for harnessing industrial waste heat with supra-regional district heating networks," Applied Energy, Elsevier, vol. 372(C).
    5. Guo, Yurun & Wang, Shugang & Wang, Jihong & Zhang, Tengfei & Ma, Zhenjun & Jiang, Shuang, 2024. "Key district heating technologies for building energy flexibility: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 189(PB).
    6. Li, Xiang & Yilmaz, Selin & Patel, Martin K. & Chambers, Jonathan, 2023. "Techno-economic analysis of fifth-generation district heating and cooling combined with seasonal borehole thermal energy storage," Energy, Elsevier, vol. 285(C).
    7. Linden, Jules & O’Donoghue, Cathal & Sologon, Denisa M., 2024. "The many faces of carbon tax regressivity—Why carbon taxes are not always regressive for the same reason," Energy Policy, Elsevier, vol. 192(C).
    8. Buonomano, A. & Forzano, C. & Mongibello, L. & Palombo, A. & Russo, G., 2024. "Optimising low-temperature district heating networks: A simulation-based approach with experimental verification," Energy, Elsevier, vol. 304(C).
    9. Lin, Zi & Liu, Xiaolei & Lao, Liyun & Liu, Hengxu, 2020. "Prediction of two-phase flow patterns in upward inclined pipes via deep learning," Energy, Elsevier, vol. 210(C).
    10. Yi Ding & Qiang Guo & Wenyuan Guo & Wenxiao Chu & Qiuwang Wang, 2024. "Review of Recent Applications of Heat Pipe Heat Exchanger Use for Waste Heat Recovery," Energies, MDPI, vol. 17(11), pages 1-28, May.
    11. Sun, Chunhua & Liu, Yiting & Cao, Shanshan & Chen, Jiali & Xia, Guoqiang & Wu, Xiangdong, 2022. "Identification of control regularity of heating stations based on cross-correlation function dynamic time delay method," Energy, Elsevier, vol. 246(C).
    12. Qin, Qiwei & Gosselin, Louis, 2024. "Community-based transactive energy market concept for 5th generation district heating and cooling through distributed optimization," Applied Energy, Elsevier, vol. 371(C).
    13. Dénarié, A. & Aprile, M. & Motta, M., 2023. "Dynamical modelling and experimental validation of a fast and accurate district heating thermo-hydraulic modular simulation tool," Energy, Elsevier, vol. 282(C).
    14. Ayou, Dereje S. & Wardhana, Muhammad Fa'iq Vidi & Coronas, Alberto, 2023. "Performance analysis of a reversible water/LiBr absorption heat pump connected to district heating network in warm and cold climates," Energy, Elsevier, vol. 268(C).
    15. Sayed, Enas Taha & Alami, Abdul Hai & Abdelkareem, Mohammad Ali & Wilberforce, Tabbi & Kamarudin, Siti Kartom & Olabi, A.G., 2024. "Real direct urea fuel Fell operation using standalone Ni-based metal-organic framework prepared by ball mill at room temperature," Energy, Elsevier, vol. 305(C).
    16. Erica Corradi & Mosè Rossi & Alice Mugnini & Anam Nadeem & Gabriele Comodi & Alessia Arteconi & Danilo Salvi, 2021. "Energy, Environmental, and Economic Analyses of a District Heating (DH) Network from Both Thermal Plant and End-Users’ Prospective: An Italian Case Study," Energies, MDPI, vol. 14(22), pages 1-25, November.
    17. Gintautas Miliauskas & Egidijus Puida & Robertas Poškas & Povilas Poškas, 2021. "The Influence of Droplet Dispersity on Droplet Vaporization in the High-Temperature Wet Gas Flow in the Case of Combined Heating," Sustainability, MDPI, vol. 13(7), pages 1-24, March.
    18. Hirsch, Hauke & Nicolai, Andreas, 2022. "An efficient numerical solution method for detailed modelling of large 5th generation district heating and cooling networks," Energy, Elsevier, vol. 255(C).
    19. Mengting Jiang & Camilo Rindt & David M. J. Smeulders, 2022. "Optimal Planning of Future District Heating Systems—A Review," Energies, MDPI, vol. 15(19), pages 1-38, September.
    20. Boghetti, Roberto & Kämpf, Jérôme H., 2024. "Verification of an open-source Python library for the simulation of district heating networks with complex topologies," Energy, Elsevier, vol. 290(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:289:y:2024:i:c:s0360544223034400. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.