IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v257y2022ics036054422201622x.html
   My bibliography  Save this article

The modeling of transient phase changes of water droplets in flue gas flow in the range of temperatures characteristic of condensing economizer technologies

Author

Listed:
  • Miliauskas, Gintautas
  • Puida, Egidijus
  • Poškas, Robertas
  • Poškas, Povilas
  • Balčius, Algimantas
  • Jouhara, Hussam

Abstract

Heat transfer and phase change processes of water droplets in humid air flow were investigated by performing experiments and numerical simulations of heat recovery from biofuel exhaust gas at 40–250 °C, which is characteristic for condensing heat exchangers. Compared to the experiments, the numerical investigation was performed within a wider range of boundary conditions considering droplet dispersity and flue gas parameters. The reliability of the simulation was justified through the coincidence between the calculated temperature of the equilibrium evaporation of droplets (convection heat transfer) in humid air and the wet-bulb thermometer temperature. In case of droplet combined heating (radiation and convection), the methodology was justified by coincidence between the calculated equilibrium evaporation velocity and experimental results obtained by other authors. When the temperature of radiation source is lower than 150 °C, the vapor flows calculated at the surface of the droplets in equilibrium evaporation in the cases of combined heating and convective heat transfer differs about 0.1%, therefore, the radiation influence can be neglected. Based on the results obtained in the investigation of the droplet's phase changes, the work includes practical recommendations for technological water injection to ensure optimal heat recovery from wet exhaust gas in condensing economizers.

Suggested Citation

  • Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Poškas, Povilas & Balčius, Algimantas & Jouhara, Hussam, 2022. "The modeling of transient phase changes of water droplets in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 257(C).
    • Handle: RePEc:eee:energy:v:257:y:2022:i:c:s036054422201622x
    DOI: 10.1016/j.energy.2022.124719
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S036054422201622X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2022.124719?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Men, Yiyu & Liu, Xiaohua & Zhang, Tao, 2020. "Analytical solutions of heat and mass transfer process in combined gas-water heat exchanger applied for waste heat recovery," Energy, Elsevier, vol. 206(C).
    2. Miliauskas, G. & Maziukienė, M. & Jouhara, H. & Poškas, R., 2019. "Investigation of mass and heat transfer transitional processes of water droplets in wet gas flow in the framework of energy recovery technologies for biofuel combustion and flue gas removal," Energy, Elsevier, vol. 173(C), pages 740-754.
    3. Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Ragaišis, Valdas & Paukštaitis, Linas & Jouhara, Hussam & Mingilaitė, Laura, 2022. "Experimental investigations of water droplet transient phase changes in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 256(C).
    4. Ijaodola, O.S. & El- Hassan, Zaki & Ogungbemi, E. & Khatib, F.N. & Wilberforce, Tabbi & Thompson, James & Olabi, A.G., 2019. "Energy efficiency improvements by investigating the water flooding management on proton exchange membrane fuel cell (PEMFC)," Energy, Elsevier, vol. 179(C), pages 246-267.
    5. Carton, J.G. & Lawlor, V. & Olabi, A.G. & Hochenauer, C. & Zauner, G., 2012. "Water droplet accumulation and motion in PEM (Proton Exchange Membrane) fuel cell mini-channels," Energy, Elsevier, vol. 39(1), pages 63-73.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Sterkhov, K.V. & Khokhlov, D.A. & Zaichenko, M.N., 2024. "Zero carbon emission CCGT power plant with integrated solid fuel gasification," Energy, Elsevier, vol. 294(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zhang, Xiaoqing & Yang, Jiapei & Ma, Xiao & Zhuge, Weilin & Shuai, Shijin, 2022. "Modelling and analysis on effects of penetration of microporous layer into gas diffusion layer in PEM fuel cells: Focusing on mass transport," Energy, Elsevier, vol. 254(PA).
    2. Poškas, Robertas & Sirvydas, Arūnas & Mingilaitė, Laura & Poškas, Povilas & Jouhara, Hussam, 2024. "Investigation of effect of cooling water characteristics on flue gas condensation along vertical tube heat exchanger," Energy, Elsevier, vol. 289(C).
    3. Antoine Bäumler & Jianwen Meng & Abdelmoudjib Benterki & Toufik Azib & Moussa Boukhnifer, 2023. "A System-Level Modeling of PEMFC Considering Degradation Aspect towards a Diagnosis Process," Energies, MDPI, vol. 16(14), pages 1-19, July.
    4. Rezk, Hegazy & Aly, Mokhtar & Fathy, Ahmed, 2021. "A novel strategy based on recent equilibrium optimizer to enhance the performance of PEM fuel cell system through optimized fuzzy logic MPPT," Energy, Elsevier, vol. 234(C).
    5. Yin, Yan & Li, Yu & Qin, Yanzhou & Li, Mengjie & Liu, Guokun & Zhang, Junfeng & Zhao, Jian, 2022. "Ex-situ experimental study on dynamic behaviors and detachment characteristics of liquid water in a transparent channel of PEMFC," Renewable Energy, Elsevier, vol. 187(C), pages 1037-1049.
    6. Miliauskas, Gintautas & Puida, Egidijus & Poškas, Robertas & Ragaišis, Valdas & Paukštaitis, Linas & Jouhara, Hussam & Mingilaitė, Laura, 2022. "Experimental investigations of water droplet transient phase changes in flue gas flow in the range of temperatures characteristic of condensing economizer technologies," Energy, Elsevier, vol. 256(C).
    7. Qin, Yanzhou & Guo, Qiaoyu & Chen, Rouxian & Zhuang, Yuan & Wang, Yulin, 2021. "Numerical investigation of water droplet impact on PEM fuel cell flow channel surface," Renewable Energy, Elsevier, vol. 168(C), pages 750-763.
    8. Abdin, Z. & Webb, C.J. & Gray, E.MacA., 2016. "PEM fuel cell model and simulation in Matlab–Simulink based on physical parameters," Energy, Elsevier, vol. 116(P1), pages 1131-1144.
    9. Parnian, Mohammad Javad & Rowshanzamir, Soosan & Gashoul, Fatemeh, 2017. "Comprehensive investigation of physicochemical and electrochemical properties of sulfonated poly (ether ether ketone) membranes with different degrees of sulfonation for proton exchange membrane fuel ," Energy, Elsevier, vol. 125(C), pages 614-628.
    10. Cha, Dowon & Yang, Wonseok & Kim, Yongchan, 2019. "Performance improvement of self-humidifying PEM fuel cells using water injection at various start-up conditions," Energy, Elsevier, vol. 183(C), pages 514-524.
    11. Asadollahi, Arash & Esmaeeli, Asghar, 2018. "Simulation of condensation and liquid break-up on a micro-object with upper and lower movable walls using Lattice Boltzmann Method," Physica A: Statistical Mechanics and its Applications, Elsevier, vol. 498(C), pages 33-49.
    12. Okur, Osman & İyigün Karadağ, Çiğdem & Boyacı San, Fatma Gül & Okumuş, Emin & Behmenyar, Gamze, 2013. "Optimization of parameters for hot-pressing manufacture of membrane electrode assembly for PEM (polymer electrolyte membrane fuel cells) fuel cell," Energy, Elsevier, vol. 57(C), pages 574-580.
    13. Salva, J. Antonio & Iranzo, Alfredo & Rosa, Felipe & Tapia, Elvira, 2016. "Validation of cell voltage and water content in a PEM (polymer electrolyte membrane) fuel cell model using neutron imaging for different operating conditions," Energy, Elsevier, vol. 101(C), pages 100-112.
    14. Yonghua Cai & Jingming Sun & Fan Wei & Ben Chen, 2022. "Effect of Baffle Dimensionless Size Factor on the Performance of Proton Exchange Membrane Fuel Cell," Energies, MDPI, vol. 15(10), pages 1-19, May.
    15. Abdollahzadeh, M. & Ribeirinha, P. & Boaventura, M. & Mendes, A., 2018. "Three-dimensional modeling of PEMFC with contaminated anode fuel," Energy, Elsevier, vol. 152(C), pages 939-959.
    16. Najmi, Aezid-Ul-Hassan & Anyanwu, Ikechukwu S. & Xie, Xu & Liu, Zhi & Jiao, Kui, 2021. "Experimental investigation and optimization of proton exchange membrane fuel cell using different flow fields," Energy, Elsevier, vol. 217(C).
    17. Dobersek, Danijela & Goricanec, Darko, 2014. "An experimentally evaluated magnetic device's efficiency for water-scale reduction on electric heaters," Energy, Elsevier, vol. 77(C), pages 271-278.
    18. Zhao, Kai & Tian, Zhenyu & Zhang, Jinrui & Lu, Buchu & Hao, Yong, 2023. "Methanol steam reforming reactor with fractal tree-shaped structures for photovoltaic–thermochemical hybrid power generation," Applied Energy, Elsevier, vol. 330(PB).
    19. Lu Zhang & Yongfeng Liu & Pucheng Pei & Xintong Liu & Long Wang & Yuan Wan, 2022. "Variation Characteristic Analysis of Water Content at the Flow Channel of Proton Exchange Membrane Fuel Cell," Energies, MDPI, vol. 15(9), pages 1-20, April.
    20. Jung, Chi-Young & Yi, Jae-You & Yi, Sung-Chul, 2014. "On the role of the silica-containing catalyst layer for proton exchange membrane fuel cells," Energy, Elsevier, vol. 68(C), pages 794-800.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:257:y:2022:i:c:s036054422201622x. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.