IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v205y2020ics0360544220309397.html
   My bibliography  Save this article

Integration of absorption refrigeration systems into rankine power cycles to reduce water consumption: An economic analysis

Author

Listed:
  • Ramírez, F. Javier
  • Salgado, R.
  • Almendros-Ibáñez, J.A.
  • Belmonte, J.F.
  • Molina, A.E.

Abstract

This work presents the economic modeling and analysis of a thermoelectric steam power plant (SPP) cooled with an air-cooled heat exchanger (ACHX) and using an absorption refrigeration system (ARS) as an intermediary, as discussed in Salgado et al., 2017. This novel configuration has the advantage of not consuming fresh water in the cooling system, which is of special interest in locations where water is scarce or expensive. Based on the thermodynamic analysis of this SPP configuration (considering three different power ranges: 5 MW, 50 MW, and 200 MW, and different ambient temperatures from 5°C to 40°C), economic and sensitivity analyses were conducted to determine the cost-effectiveness and profitability of the power plant. Finally, a comparative analysis was conducted to test the economic outcomes of the SPPs using the proposed ARS compared with conventional refrigeration devices based on water cooling and dry cooling technologies. The results show that conventional evaporative cooling towers are the best solution from an economic perspective. Nevertheless, in regions where water is not easily accessible, the proposed ARS achieves better economic outcomes than the conventional ACHX when the ambient temperature is beyond the range of 17.5°C–22.5°C, depending on the power rating of the plant.

Suggested Citation

  • Ramírez, F. Javier & Salgado, R. & Almendros-Ibáñez, J.A. & Belmonte, J.F. & Molina, A.E., 2020. "Integration of absorption refrigeration systems into rankine power cycles to reduce water consumption: An economic analysis," Energy, Elsevier, vol. 205(C).
    • Handle: RePEc:eee:energy:v:205:y:2020:i:c:s0360544220309397
    DOI: 10.1016/j.energy.2020.117832
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544220309397
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2020.117832?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Salgado, R. & Belmonte, J.F. & Almendros-Ibáñez, J.A. & Molina, A.E., 2017. "Integration of absorption refrigeration systems into Rankine power cycles to reduce water consumption: A thermodynamic analysis," Energy, Elsevier, vol. 119(C), pages 1084-1097.
    2. Pan, Chunjian & Vermaak, Natasha & Romero, Carlos & Neti, Sudhakar & Hoenig, Sean & Chen, Chien-Hua & Bonner, Richard, 2018. "Cost estimation and sensitivity analysis of a latent thermal energy storage system for supplementary cooling of air cooled condensers," Applied Energy, Elsevier, vol. 224(C), pages 52-68.
    3. Janghorban Esfahani, Iman & Kang, Yong Tae & Yoo, ChangKyoo, 2014. "A high efficient combined multi-effect evaporation–absorption heat pump and vapor-compression refrigeration part 1: Energy and economic modeling and analysis," Energy, Elsevier, vol. 75(C), pages 312-326.
    4. Usman, Muhammad & Imran, Muhammad & Yang, Youngmin & Lee, Dong Hyun & Park, Byung-Sik, 2017. "Thermo-economic comparison of air-cooled and cooling tower based Organic Rankine Cycle (ORC) with R245fa and R1233zde as candidate working fluids for different geographical climate conditions," Energy, Elsevier, vol. 123(C), pages 353-366.
    5. Xiong, Jie & Zhao, Haibo & Zhang, Chao & Zheng, Chuguang & Luh, Peter B., 2012. "Thermoeconomic operation optimization of a coal-fired power plant," Energy, Elsevier, vol. 42(1), pages 486-496.
    6. Zhang, Haitian & Feng, Xiao & Wang, Yufei, 2018. "Comparison and evaluation of air cooling and water cooling in resource consumption and economic performance," Energy, Elsevier, vol. 154(C), pages 157-167.
    7. Jiménez Navarro, Juan Pablo & Cejudo López, José Manuel & Connolly, David, 2017. "The effect of feed-in-tariff supporting schemes on the viability of a district heating and cooling production system," Energy, Elsevier, vol. 134(C), pages 438-448.
    8. Sanaye, Sepehr & Mohammadi Nasab, Amir, 2012. "Modeling and optimizing a CHP system for natural gas pressure reduction plant," Energy, Elsevier, vol. 40(1), pages 358-369.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Hasan, Alabas & Mugdadi, Basheer & Al-Nimr, Moh'd A. & Tashtoush, Bourhan, 2022. "Direct and indirect utilization of thermal energy for cooling generation: A comparative analysis," Energy, Elsevier, vol. 238(PC).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zhao, Ying-Kun & Lei, Biao & Wu, Yu-Ting & Zhi, Rui-Ping & Wang, Wei & Guo, Hang & Ma, Chong-Fang, 2018. "Experimental study on the net efficiency of an Organic Rankine Cycle with single screw expander in different seasons," Energy, Elsevier, vol. 165(PB), pages 769-775.
    2. Tieyu Gao & Changwei Liu, 2017. "Off-Design Performances of Subcritical and Supercritical Organic Rankine Cycles in Geothermal Power Systems under an Optimal Control Strategy," Energies, MDPI, vol. 10(8), pages 1-25, August.
    3. Aunedi, Marko & Pantaleo, Antonio Marco & Kuriyan, Kamal & Strbac, Goran & Shah, Nilay, 2020. "Modelling of national and local interactions between heat and electricity networks in low-carbon energy systems," Applied Energy, Elsevier, vol. 276(C).
    4. Petersen, Nils Hendrik & Arras, Maximilian & Wirsum, Manfred & Ma, Linwei, 2024. "Integration of large-scale heat pumps to assist sustainable water desalination and district cooling," Energy, Elsevier, vol. 289(C).
    5. Tian, Yafen & Xing, Ziwen & He, Zhilong & Wu, Huagen, 2017. "Modeling and performance analysis of twin-screw steam expander under fluctuating operating conditions in steam pipeline pressure energy recovery applications," Energy, Elsevier, vol. 141(C), pages 692-701.
    6. Van Erdeweghe, Sarah & Van Bael, Johan & Laenen, Ben & D’haeseleer, William, 2019. "Design and off-design optimization procedure for low-temperature geothermal organic Rankine cycles," Applied Energy, Elsevier, vol. 242(C), pages 716-731.
    7. Alvi, Jahan Zeb & Feng, Yongqiang & Wang, Qian & Imran, Muhammad & Pei, Gang, 2021. "Effect of phase change materials on the performance of direct vapor generation solar organic Rankine cycle system," Energy, Elsevier, vol. 223(C).
    8. Dorotić, Hrvoje & Ban, Marko & Pukšec, Tomislav & Duić, Neven, 2020. "Impact of wind penetration in electricity markets on optimal power-to-heat capacities in a local district heating system," Renewable and Sustainable Energy Reviews, Elsevier, vol. 132(C).
    9. Pietro Catrini & Tancredi Testasecca & Alessandro Buscemi & Antonio Piacentino, 2022. "Exergoeconomics as a Cost-Accounting Method in Thermal Grids with the Presence of Renewable Energy Producers," Sustainability, MDPI, vol. 14(7), pages 1-27, March.
    10. Kabalina, Natalia & Costa, Mário & Yang, Weihong & Martin, Andrew, 2017. "Energy and economic assessment of a polygeneration district heating and cooling system based on gasification of refuse derived fuels," Energy, Elsevier, vol. 137(C), pages 696-705.
    11. Muñoz, Marta & Rovira, Antonio & Sánchez, Consuelo & Montes, María José, 2017. "Off-design analysis of a Hybrid Rankine-Brayton cycle used as the power block of a solar thermal power plant," Energy, Elsevier, vol. 134(C), pages 369-381.
    12. Baghsheikhi, Mostafa & Sayyaadi, Hoseyn, 2016. "Real-time exergoeconomic optimization of a steam power plant using a soft computing-fuzzy inference system," Energy, Elsevier, vol. 114(C), pages 868-884.
    13. Abdulwahid, Alhasan Ali & Zhao, Hongxia & Wang, Zheng & Liu, Guangdi & Khalil, Essam E & Lai, Yanhua & Han, Jitian, 2022. "Thermo-economic comparison of two models of combined transcritical CO2 refrigeration and multi-effect desalination system," Applied Energy, Elsevier, vol. 308(C).
    14. Ioannis E. Kosmadakis & Costas Elmasides & Dimitrios Eleftheriou & Konstantinos P. Tsagarakis, 2019. "A Techno-Economic Analysis of a PV-Battery System in Greece," Energies, MDPI, vol. 12(7), pages 1-14, April.
    15. Oh, Saesin & Kim, Sang-Kee, 2022. "Impact of heat price regulation on the optimal district heating production mix and its policy implications," Energy, Elsevier, vol. 239(PD).
    16. Guoqiang Li & Yuting Wu & Yeqiang Zhang & Ruiping Zhi & Jingfu Wang & Chongfang Ma, 2016. "Performance Study on a Single-Screw Expander for a Small-Scale Pressure Recovery System," Energies, MDPI, vol. 10(1), pages 1-14, December.
    17. Chen, Hao & Zhao, Li & Cong, Haifeng & Li, Xingang, 2022. "Synthesis of waste heat recovery using solar organic Rankine cycle in the separation of benzene/toluene/p-xylene process," Energy, Elsevier, vol. 255(C).
    18. Agudelo, Andrés & Valero, Antonio & Torres, César, 2012. "Allocation of waste cost in thermoeconomic analysis," Energy, Elsevier, vol. 45(1), pages 634-643.
    19. Carapellucci, Roberto & Giordano, Lorena, 2013. "A comparison between exergetic and economic criteria for optimizing the heat recovery steam generators of gas-steam power plants," Energy, Elsevier, vol. 58(C), pages 458-472.
    20. Baofeng Yao & Xu Ping & Hongguang Zhang, 2021. "Dynamic Response Characteristics Analysis and Energy, Exergy, and Economic (3E) Evaluation of Dual Loop Organic Rankine Cycle (DORC) for CNG Engine Waste Heat Recovery," Energies, MDPI, vol. 14(19), pages 1-32, September.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:205:y:2020:i:c:s0360544220309397. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.