IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v163y2018icp533-545.html
   My bibliography  Save this article

Cost-effective, low thermo-chemo disperser pretreatment for biogas production potential of marine macroalgae Chaetomorpha antennina

Author

Listed:
  • Tamilarasan, K.
  • Kavitha, S.
  • Selvam, Ammaiyappan
  • Rajesh Banu, J.
  • Yeom, Ick Tae
  • Nguyen, Dinh Duc
  • Saratale, Ganesh Dattatraya

Abstract

In this study, a novel attempt has been made to generate energy-efficient biomethane from marine macroalgae (Chaetomorpha antennina) by coupling thermochemical liquefaction with a disperser (thermo-chemo disperser (TCD) liquefaction). A temperature of (80 °C), pH 11 and disperser g-force of 1613 g were considered optimal parameters for effective solubilization and energy-efficient methane generation. This combinative liquefaction considerably reduced the treatment time and specific energy from 60 to 15 min and 6294 to 800 kJ/kg TS. The highest volatile fatty acids (VFA) accumulation of 890 mg/L was recorded in TCD compared to a thermo disperser (TD) (750 mg/L) and disperser (D) (322 mg/L) during anaerobic fermentation. TCD enhances the methane production potential of macroalgal biomass and a higher methane production of 215 mL/g VS was achieved for TCD compared to TD (149 mL/g VS) and D samples (100 mL/g VS), respectively. Cost analysis confirmed the field applicability of TCD liquefaction with a net profit of 90 USD/ton of marine macroalgae. A high energy ratio of 1.5 was achieved with the proposed mode of pretreatment (TCD) compared to TD (0.95) and D (0.28) pretreatment. Therefore, C. antennina is considered a suitable feedstock for methane generation.

Suggested Citation

  • Tamilarasan, K. & Kavitha, S. & Selvam, Ammaiyappan & Rajesh Banu, J. & Yeom, Ick Tae & Nguyen, Dinh Duc & Saratale, Ganesh Dattatraya, 2018. "Cost-effective, low thermo-chemo disperser pretreatment for biogas production potential of marine macroalgae Chaetomorpha antennina," Energy, Elsevier, vol. 163(C), pages 533-545.
    • Handle: RePEc:eee:energy:v:163:y:2018:i:c:p:533-545
    DOI: 10.1016/j.energy.2018.08.147
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544218316839
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2018.08.147?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Montingelli, M.E. & Benyounis, K.Y. & Quilty, B. & Stokes, J. & Olabi, A.G., 2017. "Influence of mechanical pretreatment and organic concentration of Irish brown seaweed for methane production," Energy, Elsevier, vol. 118(C), pages 1079-1089.
    2. Tedesco, S. & Marrero Barroso, T. & Olabi, A.G., 2014. "Optimization of mechanical pre-treatment of Laminariaceae spp. biomass-derived biogas," Renewable Energy, Elsevier, vol. 62(C), pages 527-534.
    3. Rodriguez, C. & Alaswad, A. & El-Hassan, Z. & Olabi, A.G., 2018. "Improvement of methane production from P. canaliculata through mechanical pretreatment," Renewable Energy, Elsevier, vol. 119(C), pages 73-78.
    4. Tedesco, Silvia & Mac Lochlainn, Dubhaltach & Olabi, Abdul Ghani, 2014. "Particle size reduction optimization of Laminaria spp. biomass for enhanced methane production," Energy, Elsevier, vol. 76(C), pages 857-862.
    5. Tedesco, S. & Benyounis, K.Y. & Olabi, A.G., 2013. "Mechanical pretreatment effects on macroalgae-derived biogas production in co-digestion with sludge in Ireland," Energy, Elsevier, vol. 61(C), pages 27-33.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Shabarish Shankaran & Tamilarasan Karuppiah & Rajesh Banu Jeyakumar & Godvin Sharmila Vincent, 2023. "Statistical Optimization of Chemo Sonic Liquefaction in Macroalgae for Biohydrogen Generation—An Energy-Effective Approach," Energies, MDPI, vol. 16(7), pages 1-15, March.
    2. Shweta & Sergio C. Capareda & Baldev Raj Kamboj & Kamla Malik & Karmal Singh & Dalip Kumar Bhisnoi & Sandeep Arya, 2024. "Biomass Resources and Biofuel Technologies: A Focus on Indian Development," Energies, MDPI, vol. 17(2), pages 1-27, January.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Kouhgardi, Esmaeil & Zendehboudi, Sohrab & Mohammadzadeh, Omid & Lohi, Ali & Chatzis, Ioannis, 2023. "Current status and future prospects of biofuel production from brown algae in North America: Progress and challenges," Renewable and Sustainable Energy Reviews, Elsevier, vol. 172(C).
    2. Intaramas, Kanpichcha & Jonglertjunya, Woranart & Laosiripojana, Navadol & Sakdaronnarong, Chularat, 2018. "Selective conversion of cassava mash to glucose using solid acid catalysts by sequential solid state mixed-milling reaction and thermo-hydrolysis," Energy, Elsevier, vol. 149(C), pages 837-847.
    3. Tedesco, S. & Daniels, S., 2018. "Optimisation of biogas generation from brown seaweed residues: Compositional and geographical parameters affecting the viability of a biorefinery concept," Applied Energy, Elsevier, vol. 228(C), pages 712-723.
    4. Tabassum, Muhammad Rizwan & Xia, Ao & Murphy, Jerry D., 2017. "Comparison of pre-treatments to reduce salinity and enhance biomethane yields of Laminaria digitata harvested in different seasons," Energy, Elsevier, vol. 140(P1), pages 546-551.
    5. Rodriguez, C. & Alaswad, A. & El-Hassan, Z. & Olabi, A.G., 2018. "Improvement of methane production from P. canaliculata through mechanical pretreatment," Renewable Energy, Elsevier, vol. 119(C), pages 73-78.
    6. Papurello, Davide & Lanzini, Andrea & Tognana, Lorenzo & Silvestri, Silvia & Santarelli, Massimo, 2015. "Waste to energy: Exploitation of biogas from organic waste in a 500 Wel solid oxide fuel cell (SOFC) stack," Energy, Elsevier, vol. 85(C), pages 145-158.
    7. Wang, Hanxi & Xu, Jianling & Sheng, Lianxi & Liu, Xuejun, 2018. "Effect of addition of biogas slurry for anaerobic fermentation of deer manure on biogas production," Energy, Elsevier, vol. 165(PB), pages 411-418.
    8. Nizami, A.S. & Ouda, O.K.M. & Rehan, M. & El-Maghraby, A.M.O. & Gardy, J. & Hassanpour, A. & Kumar, S. & Ismail, I.M.I., 2016. "The potential of Saudi Arabian natural zeolites in energy recovery technologies," Energy, Elsevier, vol. 108(C), pages 162-171.
    9. Montingelli, Maria E. & Benyounis, Khaled Y. & Quilty, Brid & Stokes, Joseph & Olabi, Abdul G., 2016. "Optimisation of biogas production from the macroalgae Laminaria sp. at different periods of harvesting in Ireland," Applied Energy, Elsevier, vol. 177(C), pages 671-682.
    10. El Hage, Hicham & Herez, Amal & Ramadan, Mohamad & Bazzi, Hassan & Khaled, Mahmoud, 2018. "An investigation on solar drying: A review with economic and environmental assessment," Energy, Elsevier, vol. 157(C), pages 815-829.
    11. Yiru Zhao & Nathalie Bourgougnon & Jean-Louis Lanoisellé & Thomas Lendormi, 2022. "Biofuel Production from Seaweeds: A Comprehensive Review," Energies, MDPI, vol. 15(24), pages 1-34, December.
    12. Song, Minkyung & Duc Pham, Hong & Seon, Jiyun & Chul Woo, Hee, 2015. "Marine brown algae: A conundrum answer for sustainable biofuels production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 50(C), pages 782-792.
    13. Alvydas Zagorskis & Akvilė Gotovskienė & Vladimir Monin, 2023. "Quality Assessment of Biogas-Producing Macroalgae from Azov Sea and Šventoji River," Sustainability, MDPI, vol. 15(19), pages 1-17, October.
    14. Montingelli, M.E. & Tedesco, S. & Olabi, A.G., 2015. "Biogas production from algal biomass: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 43(C), pages 961-972.
    15. Nassef, Ahmed M. & Olabi, A.G. & Rodriguez, Cristina & Abdelkareem, Mohammad Ali & Rezk, Hegazy, 2021. "Optimal operating parameter determination and modeling to enhance methane production from macroalgae," Renewable Energy, Elsevier, vol. 163(C), pages 2190-2197.
    16. Zeng, Xianhai & Guo, Xiaoyi & Su, Gaomin & Danquah, Michael K. & Zhang, Shiduo & Lu, Yinghua & Sun, Yong & Lin, Lu, 2015. "Bioprocess considerations for microalgal-based wastewater treatment and biomass production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 42(C), pages 1385-1392.
    17. Budzianowski, Wojciech M., 2016. "A review of potential innovations for production, conditioning and utilization of biogas with multiple-criteria assessment," Renewable and Sustainable Energy Reviews, Elsevier, vol. 54(C), pages 1148-1171.
    18. Ekpeni, Leonard E.N. & Benyounis, K.Y. & Nkem-Ekpeni, Fehintola F. & Stokes, J. & Olabi, A.G., 2015. "Underlying factors to consider in improving energy yield from biomass source through yeast use on high-pressure homogenizer (hph)," Energy, Elsevier, vol. 81(C), pages 74-83.
    19. Alaswad, A. & Dassisti, M. & Prescott, T. & Olabi, A.G., 2015. "Technologies and developments of third generation biofuel production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 51(C), pages 1446-1460.
    20. Rodriguez, Cristina & Alaswad, Abed & El-Hassan, Zaki & Olabi, Abdul G., 2018. "Waste paper and macroalgae co-digestion effect on methane production," Energy, Elsevier, vol. 154(C), pages 119-125.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:163:y:2018:i:c:p:533-545. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.