IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v376y2024ipbs0306261924015678.html
   My bibliography  Save this article

An innovative sustainable multi-generation energy system (electricity, heat, cold, and potable water) based on green hydrogen-fueled engine and dryer

Author

Listed:
  • Kheir Abadi, Majid
  • Ebrahimi-Moghadam, Amir

Abstract

Increasing renewables' portion in energy matrix around the world has made the scientists to propose innovative techniques for recovering the available waste heat of energy systems to produce excess energies in the Waste-to-X framework. This study proposes a green sustainable multi-generation energy system (MES), producing power, heat, cold, and potable water, driven by a hydrogen-fueled gas engine. The engine's heating potential is recovered to run some bottoming systems comprising proton exchange membrane electrolyzer (PEME), absorption/electrical chiller cycles (ACC/ECC), organic Rankine cycle (ORC), dryer unit, heat pump cycle (HPC), and reverse osmosis desalination unit. The combination of ACC with dryer and HPC is an innovative idea which utilized to produce heating load in this study. A detailed sustainability evaluation framework (technical and eco-environment) is derived to approve performance of the MES. The construction feasibility of the MES in different climatic conditions is sought by considering 5 case study cities around the world. Afterwards, best working fluid of the ECC/HPC and ORC is selected and then the sensitivity of the MES performance to design variables is investigated trough a comprehensive parametric study. Results illustrated that the MES shows the best performance in the city of Willington in which the emission of 84.8 tons of CO2 is prevented annually which is equivalent to saving of 16,291.6 m3 natural gas. The working fluid selection outputs proved that considering R22 and R123 for ECC/HPC and ORC leads the best techno-economic performance. The sensitivity study demonstrated that the highest and lowest influence of the MES's techno-economic performance is related to the ECC evaporator and ORC turbine temperatures, respectively. So that, increasing ECC evaporator temperature led to a relative variation of 8.2%, 4.5%, and 7.5% in energy recovery factor, exergy efficiency, and levelized cost of productions, respectively.

Suggested Citation

  • Kheir Abadi, Majid & Ebrahimi-Moghadam, Amir, 2024. "An innovative sustainable multi-generation energy system (electricity, heat, cold, and potable water) based on green hydrogen-fueled engine and dryer," Applied Energy, Elsevier, vol. 376(PB).
    • Handle: RePEc:eee:appene:v:376:y:2024:i:pb:s0306261924015678
    DOI: 10.1016/j.apenergy.2024.124184
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261924015678
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2024.124184?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Zheng, Shanshan & Hai, Qing & Zhou, Xiao & Stanford, Russell J., 2024. "A novel multi-generation system for sustainable power, heating, cooling, freshwater, and methane production: Thermodynamic, economic, and environmental analysis," Energy, Elsevier, vol. 290(C).
    2. Kalogirou, Soteris, 2003. "The potential of solar industrial process heat applications," Applied Energy, Elsevier, vol. 76(4), pages 337-361, December.
    3. Hamid, Khalid & Sajjad, Uzair & Yang, Kai Shing & Wu, Shih-Kuo & Wang, Chi-Chuan, 2022. "Assessment of an energy efficient closed loop heat pump dryer for high moisture contents materials: An experimental investigation and AI based modelling," Energy, Elsevier, vol. 238(PB).
    4. Alirahmi, Seyed Mojtaba & Ebrahimi-Moghadam, Amir, 2022. "Comparative study, working fluid selection, and optimal design of three systems for electricity and freshwater based on solid oxide fuel cell mover cycle," Applied Energy, Elsevier, vol. 323(C).
    5. Shakibi, Hamid & Shokri, Afshar & Assareh, Ehsanolah & Yari, Mortaza & Lee, Moonyong, 2023. "Using machine learning approaches to model and optimize a combined solar/natural gas-based power and freshwater cogeneration system," Applied Energy, Elsevier, vol. 333(C).
    6. Luo, Lulin & Lu, Lidi & Shen, Xuelian & Chen, Jinhua & Pan, Yang & Wang, Yuchen & Luo, Qing, 2023. "Energy, exergy and economic analysis of an integrated ground source heat pump and anaerobic digestion system for Co-generation of heating, cooling and biogas," Energy, Elsevier, vol. 282(C).
    7. Cao, Yan & Dhahad, Hayder A. & Togun, Hussein & Hussen, Hasanen M. & Anqi, Ali E. & Farouk, Naeim & Issakhov, Alibek, 2021. "Feasibility investigation of a novel geothermal-based integrated energy conversion system: Modified specific exergy costing (M-SPECO) method and optimization," Renewable Energy, Elsevier, vol. 180(C), pages 1124-1147.
    8. Ahmadi, Samareh & Gharehghani, Ayat & Soltani, Mohammad Mohsen & Fakhari, Amir Hossein, 2022. "Design and evaluation of renewable energies-based multi-generation system for hydrogen production, freshwater and cooling," Renewable Energy, Elsevier, vol. 198(C), pages 916-935.
    9. Yu, F.W. & Chan, K.T., 2005. "Experimental determination of the energy efficiency of an air-cooled chiller under part load conditions," Energy, Elsevier, vol. 30(10), pages 1747-1758.
    10. Ebrahimi-Moghadam, Amir & Farzaneh-Gord, Mahmood, 2022. "Optimal operation of a multi-generation district energy hub based on electrical, heating, and cooling demands and hydrogen production," Applied Energy, Elsevier, vol. 309(C).
    11. Ju, Liwei & Liu, Li & Han, Yingzhu & Yang, Shenbo & Li, Gen & Lu, Xiaolong & Liu, Yi & Qiao, Huiting, 2023. "Robust Multi-objective optimal dispatching model for a novel island micro energy grid incorporating biomass waste energy conversion system, desalination and power-to-hydrogen devices," Applied Energy, Elsevier, vol. 343(C).
    12. Bal, Lalit M. & Satya, Santosh & Naik, S.N., 2010. "Solar dryer with thermal energy storage systems for drying agricultural food products: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(8), pages 2298-2314, October.
    13. Feng, Ye & Chen, Jinglong & Luo, Ji, 2024. "Life cycle cost analysis of power generation from underground coal gasification with carbon capture and storage (CCS) to measure the economic feasibility," Resources Policy, Elsevier, vol. 92(C).
    14. Hashemian, Nasim & Noorpoor, Alireza, 2022. "A geothermal-biomass powered multi-generation plant with freshwater and hydrogen generation options: Thermo-economic-environmental appraisals and multi-criteria optimization," Renewable Energy, Elsevier, vol. 198(C), pages 254-266.
    15. Zheng, Nan & Zhang, Hanfei & Duan, Liqiang & Wang, Qiushi & Bischi, Aldo & Desideri, Umberto, 2023. "Techno-economic analysis of a novel solar-driven PEMEC-SOFC-based multi-generation system coupled parabolic trough photovoltaic thermal collector and thermal energy storage," Applied Energy, Elsevier, vol. 331(C).
    16. Kheir Abadi, Majid & Davoodi, Vajihe & Deymi-Dashtebayaz, Mahdi & Ebrahimi-Moghadam, Amir, 2023. "Determining the best scenario for providing electrical, cooling, and hot water consuming of a building with utilizing a novel wind/solar-based hybrid system," Energy, Elsevier, vol. 273(C).
    17. Liu, Lintong & Zhai, Rongrong & Hu, Yangdi, 2023. "Multi-objective optimization with advanced exergy analysis of a wind-solar‑hydrogen multi-energy supply system," Applied Energy, Elsevier, vol. 348(C).
    18. Ahadi, Amir & Kang, Sang-Kyun & Lee, Jang-Ho, 2016. "A novel approach for optimal combinations of wind, PV, and energy storage system in diesel-free isolated communities," Applied Energy, Elsevier, vol. 170(C), pages 101-115.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Deymi-Dashtebayaz, Mahdi & Kheir Abadi, Majid & Asadi, Mostafa & Khutornaya, Julia & Sergienko, Olga, 2024. "Investigation of a new solar-wind energy-based heat pump dryer for food waste drying based on different weather conditions," Energy, Elsevier, vol. 290(C).
    2. Kheir Abadi, Majid & Davoodi, Vajihe & Deymi-Dashtebayaz, Mahdi & Ebrahimi-Moghadam, Amir, 2023. "Determining the best scenario for providing electrical, cooling, and hot water consuming of a building with utilizing a novel wind/solar-based hybrid system," Energy, Elsevier, vol. 273(C).
    3. Mehrenjani, Javad Rezazadeh & Gharehghani, Ayat & Ahmadi, Samareh & Powell, Kody M., 2023. "Dynamic simulation of a triple-mode multi-generation system assisted by heat recovery and solar energy storage modules: Techno-economic optimization using machine learning approaches," Applied Energy, Elsevier, vol. 348(C).
    4. Zhao, Lu & Hai, Qing & Mei, Junlun, 2024. "An integrated approach to green power, cooling, and freshwater production from geothermal and solar energy sources; case study of Jiangsu, China," Energy, Elsevier, vol. 305(C).
    5. Deymi-Dashtebayaz, Mahdi & Davoodi, Vajihe & Khutornaya, Julia & Sergienko, Olga, 2023. "Parametric analysis and multi-objective optimization of a heat pump dryer based on working conditions and using different refrigerants," Energy, Elsevier, vol. 284(C).
    6. Razmi, Amir Reza & Hanifi, Amir Reza & Shahbakhti, Mahdi, 2023. "Design, thermodynamic, and economic analyses of a green hydrogen storage concept based on solid oxide electrolyzer/fuel cells and heliostat solar field," Renewable Energy, Elsevier, vol. 215(C).
    7. Lv, Xuefei & Lv, Ying & Zhu, Yiping, 2023. "Multi-variable study and MOPSO-based multi-objective optimization of a novel cogeneration plant using biomass fuel and geothermal energy: A complementary hybrid design," Energy, Elsevier, vol. 270(C).
    8. Dou, Zhenhai & Zou, Yunhe & Mohebbi, Amir, 2024. "Design and multi-aspect analysis of a geothermal and biomass dual-source power, cooling, heating, and hybrid freshwater production system," Energy, Elsevier, vol. 293(C).
    9. Shakibi, Hamid & Faal, Mehrdad Yousefi & Assareh, Ehsanolah & Agarwal, Neha & Yari, Mortaza & Latifi, Seyed Ali & Ghodrat, Maryam & Lee, Moonyong, 2023. "Design and multi-objective optimization of a multi-generation system based on PEM electrolyzer, RO unit, absorption cooling system, and ORC utilizing machine learning approaches; a case study of Austr," Energy, Elsevier, vol. 278(C).
    10. Zheng, Nan & Wang, Qiushi & Ding, Xingqi & Zhang, Hanfei & Duan, Liqiang & Wang, Xiaomeng & Zhou, Yufei & Sun, Mingjia & Desideri, Umberto, 2024. "Techno-economic analysis of a novel solar-based polygeneration system integrated with vanadium redox flow battery and thermal energy storage considering robust source-load response," Applied Energy, Elsevier, vol. 376(PB).
    11. Fudholi, Ahmad & Sopian, Kamaruzzaman, 2019. "A review of solar air flat plate collector for drying application," Renewable and Sustainable Energy Reviews, Elsevier, vol. 102(C), pages 333-345.
    12. EL-Mesery, Hany S. & EL-Seesy, Ahmed I. & Hu, Zicheng & Li, Yang, 2022. "Recent developments in solar drying technology of food and agricultural products: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 157(C).
    13. Ding, Xingqi & Zhou, Yufei & Duan, Liqiang & Li, Da & Zheng, Nan, 2023. "Comprehensive performance investigation of a novel solar-assisted liquid air energy storage system with different operating modes in different seasons," Energy, Elsevier, vol. 284(C).
    14. Ehab AlShamaileh & Iessa Sabbe Moosa & Heba Al-Fayyad & Bashar Lahlouh & Hussein A. Kazem & Qusay Abu-Afifeh & Bety S. Al-Saqarat & Muayad Esaifan & Imad Hamadneh, 2022. "Performance Comparison and Light Reflectance of Al, Cu, and Fe Metals in Direct Contact Flat Solar Heating Systems," Energies, MDPI, vol. 15(23), pages 1-15, November.
    15. jia, Teng & Huang, Junpeng & Li, Rui & He, Peng & Dai, Yanjun, 2018. "Status and prospect of solar heat for industrial processes in China," Renewable and Sustainable Energy Reviews, Elsevier, vol. 90(C), pages 475-489.
    16. Behzadi, Amirmohammad & Duwig, Christophe & Ploskic, Adnan & Holmberg, Sture & Sadrizadeh, Sasan, 2024. "Application to novel smart techniques for decarbonization of commercial building heating and cooling through optimal energy management," Applied Energy, Elsevier, vol. 376(PA).
    17. Gao, Xianhui & Wang, Sheng & Sun, Ying & Zhai, Junyi & Chen, Nan & Zhang, Xiao-Ping, 2024. "Low-carbon energy scheduling for integrated energy systems considering offshore wind power hydrogen production and dynamic hydrogen doping strategy," Applied Energy, Elsevier, vol. 376(PA).
    18. Joshua Adeniyi Depiver & Sabuj Mallik, 2023. "An Empirical Study on Convective Drying of Ginger Rhizomes Leveraging Environmental Stress Chambers and Linear Heat Conduction Methodology," Agriculture, MDPI, vol. 13(7), pages 1-28, June.
    19. Farhang, Behzad & Ghaebi, Hadi & Naseri Gollo, Somayeh & Javani, Nader, 2024. "Thermo-economic analysis of an innovative multi-generation system based on ammonia synthesis," Renewable Energy, Elsevier, vol. 227(C).
    20. Uzair Sajjad & Imtiyaz Hussain & Muhammad Sultan & Sadaf Mehdi & Chi-Chuan Wang & Kashif Rasool & Sayed M. Saleh & Ashraf Y. Elnaggar & Enas E. Hussein, 2021. "Determining the Factors Affecting the Boiling Heat Transfer Coefficient of Sintered Coated Porous Surfaces," Sustainability, MDPI, vol. 13(22), pages 1-19, November.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:376:y:2024:i:pb:s0306261924015678. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.