IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v7y2014i11p7223-7244d42155.html
   My bibliography  Save this article

Naturally-Forced Slug Flow Expander for Application in a Waste-Heat Recovery Cycle

Author

Listed:
  • Ben De Witt

    (Department of Mechanical and Manufacturing Engineering, University of Calgary, 2500 University Dr. NW, Calgary, AB T2N 1N4, Canada)

  • Ron Hugo

    (Department of Mechanical and Manufacturing Engineering, University of Calgary, 2500 University Dr. NW, Calgary, AB T2N 1N4, Canada)

Abstract

This paper investigates a slug-flow expander (SFE) for conversion of high-pressure gas/vapor into kinetic energy of liquid slugs. The energy transfer from high-pressure to kinetic energy is quantified using thrust plate measurements. Non-dimensional thrust data is used to quantify performance by normalizing measured thrust by thrust for the same water flow rate at zero air flow rate. A total of 13 expander configurations are investigated and geometries with the shortest cavity length and the smallest exit diameter are found to result in the largest non-dimensional thrust increase. Results show that thrust augmentation increases with the initiation of slug flow in the SFE. The analysis performed on the normalized thrust readings suggested that as the water and air flow were increased to critical conditions, the liquid slugs produced by the SFE augmented the thrust measurements. The final performance evaluation was based on linear regression of the normalized thrust measurements where slug flow was generated for each SFE architecture. Greater magnitudes of the slope from the linear regression indicated the propensity of the SFE to augment thrust. This analysis confirmed that for the SFE configurations over the range of values investigated, the SFE increased thrust up to three times its original value at no air flow. Given the inherent multiphase nature of the slug-flow expander, application to systems involving expansion of wetting fluids (water as part of a waste-heat recovery system) or air with water droplet formation (as part of a compressed-air energy storage system) could be considered.

Suggested Citation

  • Ben De Witt & Ron Hugo, 2014. "Naturally-Forced Slug Flow Expander for Application in a Waste-Heat Recovery Cycle," Energies, MDPI, vol. 7(11), pages 1-22, November.
    • Handle: RePEc:gam:jeners:v:7:y:2014:i:11:p:7223-7244:d:42155
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/7/11/7223/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/7/11/7223/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Grazzini, Giuseppe & Milazzo, Adriano, 2008. "Thermodynamic analysis of CAES/TES systems for renewable energy plants," Renewable Energy, Elsevier, vol. 33(9), pages 1998-2006.
    2. Badr, O. & O'Callaghan, P. W. & Probert, S. D., 1990. "Rankine-cycle systems for harnessing power from low-grade energy sources," Applied Energy, Elsevier, vol. 36(4), pages 263-292.
    3. van der Linden, Septimus, 2006. "Bulk energy storage potential in the USA, current developments and future prospects," Energy, Elsevier, vol. 31(15), pages 3446-3457.
    4. Badr, O. & Naik, S. & O'Callaghan, P.W. & Probert, S.D., 1991. "Expansion machine for a low power-output steam Rankine-cycle engine," Applied Energy, Elsevier, vol. 39(2), pages 93-116.
    5. Declaye, Sébastien & Quoilin, Sylvain & Guillaume, Ludovic & Lemort, Vincent, 2013. "Experimental study on an open-drive scroll expander integrated into an ORC (Organic Rankine Cycle) system with R245fa as working fluid," Energy, Elsevier, vol. 55(C), pages 173-183.
    6. Cavallo, Alfred, 2007. "Controllable and affordable utility-scale electricity from intermittent wind resources and compressed air energy storage (CAES)," Energy, Elsevier, vol. 32(2), pages 120-127.
    7. Angelino, Gianfranco & Colonna di Paliano, Piero, 1998. "Multicomponent Working Fluids For Organic Rankine Cycles (ORCs)," Energy, Elsevier, vol. 23(6), pages 449-463.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ziviani, Davide & Beyene, Asfaw & Venturini, Mauro, 2014. "Advances and challenges in ORC systems modeling for low grade thermal energy recovery," Applied Energy, Elsevier, vol. 121(C), pages 79-95.
    2. Díaz-González, Francisco & Sumper, Andreas & Gomis-Bellmunt, Oriol & Villafáfila-Robles, Roberto, 2012. "A review of energy storage technologies for wind power applications," Renewable and Sustainable Energy Reviews, Elsevier, vol. 16(4), pages 2154-2171.
    3. Yamada, Noboru & Tominaga, Yoshihito & Yoshida, Takanori, 2014. "Demonstration of 10-Wp micro organic Rankine cycle generator for low-grade heat recovery," Energy, Elsevier, vol. 78(C), pages 806-813.
    4. He, Qing & Li, Guoqing & Lu, Chang & Du, Dongmei & Liu, Wenyi, 2019. "A compressed air energy storage system with variable pressure ratio and its operation control," Energy, Elsevier, vol. 169(C), pages 881-894.
    5. Jannelli, E. & Minutillo, M. & Lubrano Lavadera, A. & Falcucci, G., 2014. "A small-scale CAES (compressed air energy storage) system for stand-alone renewable energy power plant for a radio base station: A sizing-design methodology," Energy, Elsevier, vol. 78(C), pages 313-322.
    6. Chacartegui, R. & Sánchez, D. & Muñoz, J.M. & Sánchez, T., 2009. "Alternative ORC bottoming cycles FOR combined cycle power plants," Applied Energy, Elsevier, vol. 86(10), pages 2162-2170, October.
    7. Facci, Andrea L. & Sánchez, David & Jannelli, Elio & Ubertini, Stefano, 2015. "Trigenerative micro compressed air energy storage: Concept and thermodynamic assessment," Applied Energy, Elsevier, vol. 158(C), pages 243-254.
    8. Salgi, Georges & Lund, Henrik, 2008. "System behaviour of compressed-air energy-storage in Denmark with a high penetration of renewable energy sources," Applied Energy, Elsevier, vol. 85(4), pages 182-189, April.
    9. Zhou, Qian & Du, Dongmei & Lu, Chang & He, Qing & Liu, Wenyi, 2019. "A review of thermal energy storage in compressed air energy storage system," Energy, Elsevier, vol. 188(C).
    10. Jubeh, Naser M. & Najjar, Yousef S.H., 2012. "Power augmentation with CAES (compressed air energy storage) by air injection or supercharging makes environment greener," Energy, Elsevier, vol. 38(1), pages 228-235.
    11. Steven Lecompte & Sanne Lemmens & Henk Huisseune & Martijn Van den Broek & Michel De Paepe, 2015. "Multi-Objective Thermo-Economic Optimization Strategy for ORCs Applied to Subcritical and Transcritical Cycles for Waste Heat Recovery," Energies, MDPI, vol. 8(4), pages 1-28, April.
    12. Erren Yao & Huanran Wang & Long Liu & Guang Xi, 2014. "A Novel Constant-Pressure Pumped Hydro Combined with Compressed Air Energy Storage System," Energies, MDPI, vol. 8(1), pages 1-18, December.
    13. Drury, Easan & Denholm, Paul & Sioshansi, Ramteen, 2011. "The value of compressed air energy storage in energy and reserve markets," Energy, Elsevier, vol. 36(8), pages 4959-4973.
    14. Liu, Zhongyan & Guan, Hongwei & Shao, Jiawei & Jin, Xu & Su, Wei & Zhang, Hao & Li, Heng & Sun, Dahan & Wei, Tengfei, 2024. "Thermodynamic and advanced exergy analysis of a trans-critical CO2 energy storage system integrated with heat supply and solar energy," Energy, Elsevier, vol. 302(C).
    15. Aljundi, Isam H., 2011. "Effect of dry hydrocarbons and critical point temperature on the efficiencies of organic Rankine cycle," Renewable Energy, Elsevier, vol. 36(4), pages 1196-1202.
    16. Stefano Ubertini & Andrea Luigi Facci & Luca Andreassi, 2017. "Hybrid Hydrogen and Mechanical Distributed Energy Storage," Energies, MDPI, vol. 10(12), pages 1-16, December.
    17. Antweiler, Werner, 2021. "Microeconomic models of electricity storage: Price Forecasting, arbitrage limits, curtailment insurance, and transmission line utilization," Energy Economics, Elsevier, vol. 101(C).
    18. Dellicompagni, Pablo & Saravia, Luis & Altamirano, Martín & Franco, Judith, 2018. "Simulation and testing of a solar reciprocating steam engine," Energy, Elsevier, vol. 151(C), pages 662-674.
    19. Huanran Wang & Liqin Wang & Xinbing Wang & Erren Yao, 2013. "A Novel Pumped Hydro Combined with Compressed Air Energy Storage System," Energies, MDPI, vol. 6(3), pages 1-14, March.
    20. Bai, Hao & Luo, ShiHao & Zhao, Xijie & Zhao, Gen & Gao, Yang, 2022. "Comprehensive assessment of a green cogeneration system based on compressed air energy storage (CAES) and zeotropic mixtures," Energy, Elsevier, vol. 254(PA).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:7:y:2014:i:11:p:7223-7244:d:42155. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.