IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v18y2025i3p753-d1585194.html
   My bibliography  Save this article

Optimization of Biomass to Bio-Syntetic Natural Gas Production: Modeling and Assessment of the AIRE Project Plant Concept

Author

Listed:
  • Emanuele Di Bisceglie

    (Industrial Engineering Department, University of L’Aquila, 67100 L’Aquila, Italy)

  • Alessandro Antonio Papa

    (Industrial Engineering Department, University of L’Aquila, 67100 L’Aquila, Italy)

  • Armando Vitale

    (Industrial Engineering Department, University of L’Aquila, 67100 L’Aquila, Italy)

  • Umberto Pasqual Laverdura

    (ENEA C. R. Casaccia, 00123 Rome, Italy)

  • Andrea Di Carlo

    (Industrial Engineering Department, University of L’Aquila, 67100 L’Aquila, Italy)

  • Enrico Bocci

    (Department of Science Engineering, Guglielmo Marconi University, 00193 Rome, Italy)

Abstract

This study focuses on the modeling, simulation, and optimization of an integrated biomass gasification and methanation process to produce bio-synthetic natural gas (Bio-SNG) as part of the AIRE project. The process was simulated using Aspen Plus ® software (V14), incorporating experimental results from pilot-scale gasification setups. Key steps involved syngas production in a dual fluidized bed gasifier and its subsequent conversion to Bio-SNG in a methanation section. Heat integration strategies were implemented to enhance system results demonstrate that optimized heat recovery, achieved by utilizing exothermic methanation reactions to preheat gasification inputs, eliminates the need for auxiliary fuel in the gasification process. The optimized system achieved a thermal recovery rate of 80%, a cold gas efficiency of 79%, a Bio-SNG production rate of 0.4 Nm 3 /kg Biom , and a methane content of 85 vol.%. These optimizations reduced CO 2 emissions by 10% while increasing overall energy efficiency. This work highlights the potential of integrating biomass gasification and methanation processes with heat recovery for sustainable methane production. The findings provide a basis for scaling up the process and further exploring syngas utilization pathways to produce renewable energy carriers.

Suggested Citation

  • Emanuele Di Bisceglie & Alessandro Antonio Papa & Armando Vitale & Umberto Pasqual Laverdura & Andrea Di Carlo & Enrico Bocci, 2025. "Optimization of Biomass to Bio-Syntetic Natural Gas Production: Modeling and Assessment of the AIRE Project Plant Concept," Energies, MDPI, vol. 18(3), pages 1-23, February.
    • Handle: RePEc:gam:jeners:v:18:y:2025:i:3:p:753-:d:1585194
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/18/3/753/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/18/3/753/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Harjanne, Atte & Korhonen, Janne M., 2019. "Abandoning the concept of renewable energy," Energy Policy, Elsevier, vol. 127(C), pages 330-340.
    2. Johansson, Maria T., 2013. "Bio-synthetic natural gas as fuel in steel industry reheating furnaces – A case study of economic performance and effects on global CO2 emissions," Energy, Elsevier, vol. 57(C), pages 699-708.
    3. Colelli, Leonardo & Verdone, Nicola & Bassano, Claudia & Segneri, Valentina & Vilardi, Giorgio, 2024. "Optimization of Power to Gas system with cooled reactor for CO2 methanation: Start-up and shut-down tests with Ru-based and Ni-based kinetics," Energy, Elsevier, vol. 312(C).
    4. Reinhard Rauch & Jitka Hrbek & Hermann Hofbauer, 2014. "Biomass gasification for synthesis gas production and applications of the syngas," Wiley Interdisciplinary Reviews: Energy and Environment, Wiley Blackwell, vol. 3(4), pages 343-362, July.
    5. Lahijani, Pooya & Zainal, Zainal Alimuddin & Mohammadi, Maedeh & Mohamed, Abdul Rahman, 2015. "Conversion of the greenhouse gas CO2 to the fuel gas CO via the Boudouard reaction: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 41(C), pages 615-632.
    6. Armando Vitale & Alessandro Antonio Papa & Stefano Iannello & Erwin Ciro & Arda Hatunoglu & Valerio Corradetti & Nicola Rovelli & Pier Ugo Foscolo & Andrea Di Carlo, 2023. "Devolatilization of Polypropylene Particles in Fluidized Bed," Energies, MDPI, vol. 16(17), pages 1-20, August.
    7. Szymon Kuczyński & Mariusz Łaciak & Andrzej Olijnyk & Adam Szurlej & Tomasz Włodek, 2019. "Thermodynamic and Technical Issues of Hydrogen and Methane-Hydrogen Mixtures Pipeline Transmission," Energies, MDPI, vol. 12(3), pages 1-21, February.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. AlNouss, Ahmed & McKay, Gordon & Al-Ansari, Tareq, 2020. "Enhancing waste to hydrogen production through biomass feedstock blending: A techno-economic-environmental evaluation," Applied Energy, Elsevier, vol. 266(C).
    2. Lane, Blake & Kinnon, Michael Mac & Shaffer, Brendan & Samuelsen, Scott, 2022. "Deployment planning tool for environmentally sensitive heavy-duty vehicles and fueling infrastructure," Energy Policy, Elsevier, vol. 171(C).
    3. Jun Sheng Teh & Yew Heng Teoh & Heoy Geok How & Thanh Danh Le & Yeoh Jun Jie Jason & Huu Tho Nguyen & Dong Lin Loo, 2021. "The Potential of Sustainable Biomass Producer Gas as a Waste-to-Energy Alternative in Malaysia," Sustainability, MDPI, vol. 13(7), pages 1-31, April.
    4. Sérgio Castro Pereira & M. Filipa Ribeiro & Nuno Batalha & Marcelo Maciel Pereira, 2017. "Catalyst regeneration using CO 2 as reactant through reverse‐Boudouard reaction with coke," Greenhouse Gases: Science and Technology, Blackwell Publishing, vol. 7(5), pages 843-851, October.
    5. Donatella Barisano & Giuseppe Canneto & Francesco Nanna & Antonio Villone & Emanuele Fanelli & Cesare Freda & Massimiliano Grieco & Andrea Lotierzo & Giacinto Cornacchia & Giacobbe Braccio & Vera Marc, 2022. "Investigation of an Intensified Thermo-Chemical Experimental Set-Up for Hydrogen Production from Biomass: Gasification Process Integrated to a Portable Purification System—Part II," Energies, MDPI, vol. 15(13), pages 1-16, June.
    6. Stolecka, Katarzyna & Rusin, Andrzej, 2020. "Analysis of hazards related to syngas production and transport," Renewable Energy, Elsevier, vol. 146(C), pages 2535-2555.
    7. Mehdipour, Ramin & Garvey, Seamus & Baniamerian, Zahra & Cardenas, Bruno, 2024. "Ice source heat pump system for energy supply via gas pipelines – Part1: Performance analysis in residential units," Energy, Elsevier, vol. 309(C).
    8. Gabbrielli, Roberto & Barontini, Federica & Frigo, Stefano & Bressan, Luigi, 2022. "Numerical analysis of bio-methane production from biomass-sewage sludge oxy-steam gasification and methanation process," Applied Energy, Elsevier, vol. 307(C).
    9. Patuzzi, Francesco & Basso, Daniele & Vakalis, Stergios & Antolini, Daniele & Piazzi, Stefano & Benedetti, Vittoria & Cordioli, Eleonora & Baratieri, Marco, 2021. "State-of-the-art of small-scale biomass gasification systems: An extensive and unique monitoring review," Energy, Elsevier, vol. 223(C).
    10. Lech Nowicki & Dorota Siuta & Maciej Markowski, 2020. "Pyrolysis of Rapeseed Oil Press Cake and Steam Gasification of Solid Residues," Energies, MDPI, vol. 13(17), pages 1-12, August.
    11. Despina Vamvuka & George Tsagris & Christia Loulashi, 2023. "Co-Gasification Performance of Low-Quality Lignite with Woody Wastes Using Greenhouse Gas CO 2 —A TG–MS Study," Sustainability, MDPI, vol. 15(12), pages 1-12, June.
    12. Kuba, Matthias & Kraft, Stephan & Kirnbauer, Friedrich & Maierhans, Frank & Hofbauer, Hermann, 2018. "Influence of controlled handling of solid inorganic materials and design changes on the product gas quality in dual fluid bed gasification of woody biomass," Applied Energy, Elsevier, vol. 210(C), pages 230-240.
    13. Chen, Guan-Bang & Chang, Chung-Yu, 2024. "Co-gasification of waste shiitake substrate and waste polyethylene in a fluidized bed reactor under CO2/steam atmospheres," Energy, Elsevier, vol. 289(C).
    14. Fuquan Zhao & Fanlong Bai & Xinglong Liu & Zongwei Liu, 2022. "A Review on Renewable Energy Transition under China’s Carbon Neutrality Target," Sustainability, MDPI, vol. 14(22), pages 1-27, November.
    15. Gunarathne, Duleeka Sandamali & Mellin, Pelle & Yang, Weihong & Pettersson, Magnus & Ljunggren, Rolf, 2016. "Performance of an effectively integrated biomass multi-stage gasification system and a steel industry heat treatment furnace," Applied Energy, Elsevier, vol. 170(C), pages 353-361.
    16. Parisa Heidarnejad & Hadi Genceli & Nasim Hashemian & Mustafa Asker & Mohammad Al-Rawi, 2024. "Biomass-Fueled Organic Rankine Cycles: State of the Art and Future Trends," Energies, MDPI, vol. 17(15), pages 1-30, August.
    17. Mohammad Fazle Rabbi & József Popp & Domicián Máté & Sándor Kovács, 2022. "Energy Security and Energy Transition to Achieve Carbon Neutrality," Energies, MDPI, vol. 15(21), pages 1-18, October.
    18. Yao, Xiwen & Liu, Qinghua & Kang, Zijian & An, Zhixing & Zhou, Haodong & Xu, Kaili, 2023. "Quantitative study on thermal conversion behaviours and gas emission properties of biomass in nitrogen and in CO2/N2 mixtures by TGA/DTG and a fixed-bed tube furnace," Energy, Elsevier, vol. 270(C).
    19. Park, Jonghyun & Yim, Jun Ho & Cho, Seong-Heon & Jung, Sungyup & Tsang, Yiu Fai & Chen, Wei-Hsin & Jeon, Young Jae & Kwon, Eilhann E., 2024. "A virtuous cycle for thermal treatment of polyvinyl chloride and fermentation of lignocellulosic biomass," Applied Energy, Elsevier, vol. 362(C).
    20. Natalia Duarte Forero & Donovan Arango Barrios & Jorge Duarte Forero, 2019. "Overview of Potential Use of Hydroxyl and Hydrogen as an Alternative Fuel in Colombia," International Journal of Energy Economics and Policy, Econjournals, vol. 9(6), pages 525-534.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:18:y:2025:i:3:p:753-:d:1585194. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.