IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i19p6837-d1248808.html
   My bibliography  Save this article

Retrofit of a 600 MW Down-Fired Pulverized-Coal Furnace for Low NOx Emission

Author

Listed:
  • Tao Liu

    (State Key Laboratory of Low-Carbon Smart Coal-Fired Power Generation and Ultra-Clean Emission, Nanjing 210023, China
    China Energy Science and Technology Research Institute Co., Ltd., Nanjing 210023, China)

  • Sheng Wang

    (State Key Laboratory of Low-Carbon Smart Coal-Fired Power Generation and Ultra-Clean Emission, Nanjing 210023, China
    China Energy Science and Technology Research Institute Co., Ltd., Nanjing 210023, China)

  • Ziming Wei

    (State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China)

  • Jie Yu

    (State Key Laboratory of Coal Combustion, Huazhong University of Science and Technology, Wuhan 430074, China)

Abstract

Aiming at solving the problem of high NOx emissions of a down-fired boiler, a new combustion system has been proposed by means of the numerical simulation using Ansys Fluent. The coal-lean stream (tertiary air), which was originally mixed with a separated overfired air (SOFA) stream on the front and rear walls of the upper furnace, was relocated to the lower zone of the furnace after retrofit. The secondary-air slots were transformed into a new annular port type, which was injected into the furnace with a down-tilt angle to increase the residence time of the coal stream. Furthermore, the effect of secondary air distribution and velocity of coal stream on performance was studied. After retrofitting the combustion system, the NO emissions were effectively controlled, decreasing from 906 mg Nm −3 to 576 mg Nm −3 , but the carbon content of fly ash increased from 2.46% to 5.78%. Aiming at decreasing the carbon content of fly ash, the effect of coal/primary air velocity on the arch was studied. Less carbon content in fly ash can be observed for the lower arch airflow velocity. The results showed that the NO emissions can be controlled below 595 mg Nm −3 , and the carbon content of fly ash was reduced to 3.39% when the velocity was decreased to 18 m s −1 .

Suggested Citation

  • Tao Liu & Sheng Wang & Ziming Wei & Jie Yu, 2023. "Retrofit of a 600 MW Down-Fired Pulverized-Coal Furnace for Low NOx Emission," Energies, MDPI, vol. 16(19), pages 1-16, September.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:19:p:6837-:d:1248808
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/19/6837/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/19/6837/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Choi, Minsung & Park, Yeseul & Li, Xinzhuo & Kim, Kibeom & Sung, Yonmo & Hwang, Taegam & Choi, Gyungmin, 2021. "Numerical evaluation of pulverized coal swirling flames and NOx emissions in a coal-fired boiler: Effects of co- and counter-swirling flames and coal injection modes," Energy, Elsevier, vol. 217(C).
    2. Wang, Qingxiang & Chen, Zhichao & Han, Hui & Zeng, Lingyan & Li, Zhengqi, 2019. "Experimental characterization of anthracite combustion and NOx emission for a 300-MWe down-fired boiler with a novel combustion system: Influence of primary and vent air distributions," Applied Energy, Elsevier, vol. 238(C), pages 1551-1562.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zeng, Guang & Zhou, Anqi & Fu, Jinming & Ji, Yang, 2022. "Experimental and numerical investigations on NOx formation and reduction mechanisms of pulverized-coal stereo-staged combustion," Energy, Elsevier, vol. 261(PB).
    2. Li, Xinzhuo & Choi, Minsung & Jung, Chanho & Park, Yeseul & Choi, Gyungmin, 2022. "Effects of the staging position and air−LPG mixing ratio on the combustion and emission characteristics of coal and gas co-firing," Energy, Elsevier, vol. 254(PB).
    3. Chen, Zhichao & Qiao, Yanyu & Guan, Shuo & Wang, Zhenwang & Zheng, Yu & Zeng, Lingyan & Li, Zhengqi, 2022. "Effect of inner and outer secondary air ratios on ignition, C and N conversion process of pulverized coal in swirl burner under sub-stoichiometric ratio," Energy, Elsevier, vol. 239(PD).
    4. Wang, Qingxiang & Chen, Zhichao & Li, Liankai & Zeng, Lingyan & Li, Zhengqi, 2020. "Achievement in ultra-low-load combustion stability for an anthracite- and down-fired boiler after applying novel swirl burners: From laboratory experiments to industrial applications," Energy, Elsevier, vol. 192(C).
    5. Qiao, Yanyu & Li, Song & Jing, Xinjing & Chen, Zhichao & Fan, Subo & Li, Zhengqi, 2022. "Combustion and NOx formation characteristics from a 330 MWe retrofitted anthracite-fired utility boiler with swirl burner under deeply-staged-combustion," Energy, Elsevier, vol. 258(C).
    6. Rahimi, Sajjad & Mazaheri, Kiumars & Alipoor, Alireza & Mohammadpour, Amirreza, 2023. "The effect of hydrogen addition on methane-air flame in a stratified swirl burner," Energy, Elsevier, vol. 265(C).
    7. Yuan, Zhenhua & Chen, Zhichao & Zhang, Bo & Gao, Xuelin & Li, Jiawei & Qiao, Yanyu & Li, Zhengqi, 2023. "Study on the slagging trends of the pre-combustion chamber in industrial pulverized coal boiler under different excess air coefficients by CFD numerical simulation," Energy, Elsevier, vol. 264(C).
    8. Mohammadpour, Mohammadreza & Ashjaee, Mehdi & Houshfar, Ehsan, 2022. "Thermal performance and heat transfer characteristics analyses of oxy-biogas combustion in a swirl stabilized boiler under various oxidizing environments," Energy, Elsevier, vol. 261(PA).
    9. Zeng, Guang & Xu, Mingchen & Tu, Yaojie & Li, Zhenwei & Cai, Yongtie & Zheng, Zhimin & Tay, Kunlin & Yang, Wenming, 2020. "Influences of initial coal concentration on ignition behaviors of low-NOx bias combustion technology," Applied Energy, Elsevier, vol. 278(C).
    10. Askarova, Aliya & Georgiev, Aleksandar & Bolegenova, Saltanat & Beketayeva, Meruyert & Maximov, Valeriyu & Bolegenova, Symbat, 2022. "Computational modeling of pollutants in furnaces of pulverized coal boilers of the republic of Kazakhstan," Energy, Elsevier, vol. 258(C).
    11. Yuan, Zhenhua & Chen, Zhichao & Bian, Liguo & Wu, Xiaolan & Zhang, Bo & Li, Jiawei & Qiao, Yanyu & Li, Zhengqi, 2023. "Influence of blade angle in the outer secondary air for swirl burner on the flow, combustion, and slagging characteristics in the pre-combustion chamber under the air-staged condition," Energy, Elsevier, vol. 275(C).
    12. Choi, Minsung & Park, Yeseul & Li, Xinzhuo & Kim, Kibeom & Sung, Yonmo & Hwang, Taegam & Choi, Gyungmin, 2021. "Numerical evaluation of pulverized coal swirling flames and NOx emissions in a coal-fired boiler: Effects of co- and counter-swirling flames and coal injection modes," Energy, Elsevier, vol. 217(C).
    13. Choi, Minsung & Park, Yeseul & Deng, Kaiwen & Li, Xinzhuo & Kim, Kibeom & Sung, Yonmo & Hwang, Taegam & Choi, Gyungmin, 2022. "Effects of exhaust tube vortex on the in-furnace phenomena in a swirl-stabilized pulverized coal flame," Energy, Elsevier, vol. 239(PE).
    14. Choi, Minsung & Kim, Kibeom & Li, Xinzhuo & Deng, Kaiwen & Park, Yeseul & Seo, Minseok & Sung, Yonmo & Choi, Gyungmin, 2020. "Strategic combustion technology with exhaust tube vortex flame: Combined effect of biomass co-firing and air-staged combustion on combustion characteristics and ash deposition," Energy, Elsevier, vol. 203(C).
    15. Liu, Mingyu & Chen, Sheng & Zhu, Hongwei & Zhou, Zijian & Xu, Jingying, 2023. "Numerical investigation of ammonia/coal co-combustion in a low NOx swirl burner," Energy, Elsevier, vol. 282(C).
    16. Yan, Rong & Chen, Zhichao & Zheng, Yu & Yuan, Linxuan & Zeng, Lingyan & Li, Zhengqi, 2021. "Influence of inner and outer secondary air ratio on flow and combustion characteristics of a swirl burner in a 29 MW pulverized coal boiler," Energy, Elsevier, vol. 237(C).
    17. Luo, Jianghui & Zou, Chun & He, Yizhuo & Jing, Huixiang & Cheng, Sizhe, 2019. "The characteristics and mechanism of NO formation during pyridine oxidation in O2/N2 and O2/CO2 atmospheres," Energy, Elsevier, vol. 187(C).
    18. Wang, Hongshuai & Ouyang, Ziqu & Ding, Hongliang & Su, Kun & Zhang, Jinyang & Hu, Yujie, 2024. "Experimental study on the flexible peak shaving with pulverized coal self-preheating technology under load variability," Energy, Elsevier, vol. 289(C).
    19. Choi, Minsung & Hwang, Taegam & Park, Yeseul & Li, Xinzhuo & Kim, Junsung & Kim, Kibeom & Sung, Yonmo & Choi, Gyungmin, 2023. "Numerical evaluation of the effect of swirl configuration and fuel-rich environment on combustion and emission characteristics in a coal-fired boiler," Energy, Elsevier, vol. 268(C).
    20. Li, Xiaoguang & Zeng, Lingyan & Zhang, Ning & Zhang, Xin & Song, Minhang & Chen, Zhichao & Li, Zhengqi, 2022. "Effects of the gas/particle flow and combustion characteristics on water-wall temperature and energy conversion in a supercritical down-fired boiler at different secondary-air distributions," Energy, Elsevier, vol. 238(PC).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:19:p:6837-:d:1248808. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.