IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v11y2018i6p1448-d150587.html
   My bibliography  Save this article

Electrical Properties of Polyethylene/Polypropylene Compounds for High-Voltage Insulation

Author

Listed:
  • Sameh Ziad Ahmed Dabbak

    (Department of Electrical Engineering, Faculty of Engineering, University of Malaya, Kuala Lumpur 50603, Malaysia)

  • Hazlee Azil Illias

    (Department of Electrical Engineering, Faculty of Engineering, University of Malaya, Kuala Lumpur 50603, Malaysia)

  • Bee Chin Ang

    (Department of Chemical Engineering, Faculty of Engineering, University of Malaya, Kuala Lumpur 50603, Malaysia)

  • Nurul Ain Abdul Latiff

    (Department of Electrical Engineering, Faculty of Engineering, University of Malaya, Kuala Lumpur 50603, Malaysia)

  • Mohamad Zul Hilmey Makmud

    (Department of Electrical Engineering, Faculty of Engineering, University of Malaya, Kuala Lumpur 50603, Malaysia
    Complex of Science and Technology, Faculty of Science and Natural Resources, University Malaysia Sabah, Kota Kinabalu 88400, Malaysia)

Abstract

In high-voltage insulation systems, the most commonly used material is polymeric material because of its high dielectric strength, high resistivity, and low dielectric loss in addition to good chemical and mechanical properties. In this work, various polymer compounds were prepared, consisting of low-density polyethylene (LDPE), high-density polyethylene (HDPE), polypropylene (PP), HDPE/PP, and LDPE/PP polymer blends. The relative permittivity and breakdown strength of each sample types were evaluated. In order to determine the physical properties of the prepared samples, the samples were also characterized using differential scanning calorimetry (DSC). The results showed that the dielectric constant of PP increased with the increase of HDPE and LDPE content. The breakdown measurement data for all samples were analyzed using the cumulative probability plot of Weibull distribution. From the acquired results, it was found that the dielectric strengths of LDPE and HDPE were higher than that of PP. Consequently, the addition of LDPE and HDPE to PP increased the breakdown strength of PP, but a variation in the weight ratio (30%, 50% and 70%) did not change significantly the breakdown strength. The DSC measurements showed two exothermic crystallization peaks representing two crystalline phases. In addition, the DSC results showed that the blended samples were physically bonded, and no co-crystallization occurred in the produced blends.

Suggested Citation

  • Sameh Ziad Ahmed Dabbak & Hazlee Azil Illias & Bee Chin Ang & Nurul Ain Abdul Latiff & Mohamad Zul Hilmey Makmud, 2018. "Electrical Properties of Polyethylene/Polypropylene Compounds for High-Voltage Insulation," Energies, MDPI, vol. 11(6), pages 1-13, June.
    • Handle: RePEc:gam:jeners:v:11:y:2018:i:6:p:1448-:d:150587
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/11/6/1448/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/11/6/1448/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Jiefeng Liu & Hanbo Zheng & Yiyi Zhang & Hua Wei & Ruijin Liao, 2017. "Grey Relational Analysis for Insulation Condition Assessment of Power Transformers Based Upon Conventional Dielectric Response Measurement," Energies, MDPI, vol. 10(10), pages 1-16, October.
    2. M. Z. H. Makmud & H. A. Illias & C. Y. Chee & M. S. Sarjadi, 2018. "Influence of Conductive and Semi-Conductive Nanoparticles on the Dielectric Response of Natural Ester-Based Nanofluid Insulation," Energies, MDPI, vol. 11(2), pages 1-12, February.
    3. Xiaoxing Zhang & Hao Wen & Xiaoyu Chen & Yunjian Wu & Song Xiao, 2017. "Study on the Thermal and Dielectric Properties of SrTiO 3 /Epoxy Nanocomposites," Energies, MDPI, vol. 10(5), pages 1-14, May.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Antonino Imburgia & Pietro Romano & George Chen & Giuseppe Rizzo & Eleonora Riva Sanseverino & Fabio Viola & Guido Ala, 2019. "The Industrial Applicability of PEA Space Charge Measurements, for Performance Optimization of HVDC Power Cables," Energies, MDPI, vol. 12(21), pages 1-13, November.
    2. Siti Sarah Junian & Mohamad Zul Hilmey Makmud & Zuhair Jamain & Khairatun Najwa Mohd Amin & Jedol Dayou & Hazlee Azil Illias, 2021. "Effect of Rice Husk Filler on the Structural and Dielectric Properties of Palm Oil as an Electrical Insulation Material," Energies, MDPI, vol. 14(16), pages 1-11, August.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hanbo Zheng & Jiefeng Liu & Yiyi Zhang & Yijie Ma & Yang Shen & Xiaochen Zhen & Zilai Chen, 2018. "Effectiveness Analysis and Temperature Effect Mechanism on Chemical and Electrical-Based Transformer Insulation Diagnostic Parameters Obtained from PDC Data," Energies, MDPI, vol. 11(1), pages 1-17, January.
    2. Yucui Xue & Wenmin Guo & Yunlong Sun & Zhonghua Li & Yongsen Han & Hongxu Jia, 2023. "Study on Nonlinear Dielectric Properties of Micro Silica," Energies, MDPI, vol. 16(5), pages 1-12, March.
    3. Pawel Rozga & Abderrahmane Beroual & Piotr Przybylek & Maciej Jaroszewski & Konrad Strzelecki, 2020. "A Review on Synthetic Ester Liquids for Transformer Applications," Energies, MDPI, vol. 13(23), pages 1-33, December.
    4. Jiake Fang & Hanbo Zheng & Jiefeng Liu & Junhui Zhao & Yiyi Zhang & Ke Wang, 2018. "A Transformer Fault Diagnosis Model Using an Optimal Hybrid Dissolved Gas Analysis Features Subset with Improved Social Group Optimization-Support Vector Machine Classifier," Energies, MDPI, vol. 11(8), pages 1-18, July.
    5. Zhilin Lyu & Qing Wei & Yiyi Zhang & Junhui Zhao & Emad Manla, 2018. "Adaptive Virtual Impedance Droop Control Based on Consensus Control of Reactive Current," Energies, MDPI, vol. 11(7), pages 1-17, July.
    6. Samson Okikiola Oparanti & Ungarala Mohan Rao & Issouf Fofana, 2022. "Natural Esters for Green Transformers: Challenges and Keys for Improved Serviceability," Energies, MDPI, vol. 16(1), pages 1-23, December.
    7. Siti Sarah Junian & Mohamad Zul Hilmey Makmud & Zuhair Jamain & Khairatun Najwa Mohd Amin & Jedol Dayou & Hazlee Azil Illias, 2021. "Effect of Rice Husk Filler on the Structural and Dielectric Properties of Palm Oil as an Electrical Insulation Material," Energies, MDPI, vol. 14(16), pages 1-11, August.
    8. Yiyi Zhang & Jiefeng Liu & Hanbo Zheng & Hua Wei & Ruijin Liao, 2017. "Study on Quantitative Correlations between the Ageing Condition of Transformer Cellulose Insulation and the Large Time Constant Obtained from the Extended Debye Model," Energies, MDPI, vol. 10(11), pages 1-17, November.
    9. Usama Khaled & Abderrahmane Beroual, 2018. "AC Dielectric Strength of Mineral Oil-Based Fe 3 O 4 and Al 2 O 3 Nanofluids," Energies, MDPI, vol. 11(12), pages 1-13, December.
    10. Usama Khaled & Abderrahmane Beroual, 2018. "The Effect of Electronic Scavenger Additives on the AC Dielectric Strength of Transformer Mineral Oil," Energies, MDPI, vol. 11(10), pages 1-12, September.
    11. Fenglan Tian & Zhongzhao Jing & Huan Zhao & Enze Zhang & Jiefeng Liu, 2019. "A Synthetic Condition Assessment Model for Power Transformers Using the Fuzzy Evidence Fusion Method," Energies, MDPI, vol. 12(5), pages 1-17, March.
    12. Lefeng Cheng & Tao Yu, 2018. "Dissolved Gas Analysis Principle-Based Intelligent Approaches to Fault Diagnosis and Decision Making for Large Oil-Immersed Power Transformers: A Survey," Energies, MDPI, vol. 11(4), pages 1-69, April.
    13. Minghui Ou & Hua Wei & Yiyi Zhang & Jiancheng Tan, 2019. "A Dynamic Adam Based Deep Neural Network for Fault Diagnosis of Oil-Immersed Power Transformers," Energies, MDPI, vol. 12(6), pages 1-16, March.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:11:y:2018:i:6:p:1448-:d:150587. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.