IDEAS home Printed from https://ideas.repec.org/a/gam/jcltec/v4y2022i4p61-1000d939246.html
   My bibliography  Save this article

Advanced Electric Battery Power Storage for Motors through the Use of Differential Gears and High Torque for Recirculating Power Generation

Author

Listed:
  • Wenich Vattanapuripakorn

    (Department of Mechanical Engineering, Faculty of Engineering, Mahasarakam University, Maha Sarakham 44150, Thailand)

  • Sathapon Sonsupap

    (Department of Mechanical Engineering, Faculty of Engineering, Mahasarakam University, Maha Sarakham 44150, Thailand)

  • Khomson Khannam

    (Department of Mechanical Engineering, Faculty of Engineering, Mahasarakam University, Maha Sarakham 44150, Thailand)

  • Natthakrit Bamrungwong

    (School of Engineering, University of the Thai Chamber of Commerce, Dindaeng District, Bangkok 10400, Thailand)

  • Prachakon Kaewkhiaw

    (Department of Maritime Engineering, Faculty of International Maritime Studies, Kasetsart University Sriracha Campus, Chon Buri 20230, Thailand)

  • Jiradanai Sarasamkan

    (Department of Radiology, Faculty of Medicine, Khon Kaen University, Khon Kaen 40002, Thailand)

  • Bopit Bubphachot

    (Heat Pipe and Thermal Tools Design Research Unit (HTDR), Faculty of Engineering, Mahasarakam University, Maha Sarakham 44150, Thailand)

Abstract

Electricity has become one of the most important factors contributing to both the livelihoods of individuals and global economic development. Most electricity generation is still derived from burning fossil fuels that contribute to environmental degradation. The aim of this research, through innovative design, was to create clean circular technology through the utilization of electronic devices that control and send optimally timed commands to two 72-volt batteries (DC) that store and distribute energy. This new form of electric power generation was adapted to be used with a three-way differential gear system. The speed of transmission was adjusted, and shaft rotation was connected to a 7.5 kw/h DC power motor with two 15 kw/h alternators in three phases to generate high torque power at the desired rate of 3000 RPM and electricity. The first set of alternators generated the electrical energy to be distributed. The circuit system of battery set one was used for storage and slowly fed to the motor, which was kept continuously running for hours. The second alternator distributed the generated voltage to the secondary battery, which stored backup power and provided the main power to the grid. This system is especially appealing for those looking to improve energy efficiency and contribute to the green economy, as this system can be applied to power charging stations for electric vehicles or used as a backup power source for buildings.

Suggested Citation

  • Wenich Vattanapuripakorn & Sathapon Sonsupap & Khomson Khannam & Natthakrit Bamrungwong & Prachakon Kaewkhiaw & Jiradanai Sarasamkan & Bopit Bubphachot, 2022. "Advanced Electric Battery Power Storage for Motors through the Use of Differential Gears and High Torque for Recirculating Power Generation," Clean Technol., MDPI, vol. 4(4), pages 1-14, October.
    • Handle: RePEc:gam:jcltec:v:4:y:2022:i:4:p:61-1000:d:939246
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/2571-8797/4/4/61/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/2571-8797/4/4/61/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Valeria Castellucci & Johan Abrahamsson & Tobias Kamf & Rafael Waters, 2015. "Nearshore Tests of the Tidal Compensation System for Point-Absorbing Wave Energy Converters," Energies, MDPI, vol. 8(4), pages 1-20, April.
    2. Fuad Un-Noor & Sanjeevikumar Padmanaban & Lucian Mihet-Popa & Mohammad Nurunnabi Mollah & Eklas Hossain, 2017. "A Comprehensive Study of Key Electric Vehicle (EV) Components, Technologies, Challenges, Impacts, and Future Direction of Development," Energies, MDPI, vol. 10(8), pages 1-84, August.
    3. Michele De Santis & Sandro Agnelli & Fabrizio Patanè & Oliviero Giannini & Gino Bella, 2018. "Experimental Study for the Assessment of the Measurement Uncertainty Associated with Electric Powertrain Efficiency Using the Back-to-Back Direct Method," Energies, MDPI, vol. 11(12), pages 1-19, December.
    4. Bowen Zhang & Zaixin Song & Fei Zhao & Chunhua Liu, 2022. "Overview of Propulsion Systems for Unmanned Aerial Vehicles," Energies, MDPI, vol. 15(2), pages 1-25, January.
    5. Mohammadreza Gholikhani & Seyed Amid Tahami & Mohammadreza Khalili & Samer Dessouky, 2019. "Electromagnetic Energy Harvesting Technology: Key to Sustainability in Transportation Systems," Sustainability, MDPI, vol. 11(18), pages 1-18, September.
    6. Hyung-Seok Park & Hong-Jun Heo & Bum-Seog Choi & Kyung Chun Kim & Jang-Mok Kim, 2019. "Speed Control for Turbine-Generator of ORC Power Generation System and Experimental Implementation," Energies, MDPI, vol. 12(2), pages 1-13, January.
    7. Giacomo Russo & Antonio Morandi, 2022. "A Numerical Study on the Energization of the Field Coils of a Full-Size Wind Turbine with Different Types of Flux Pumps," Energies, MDPI, vol. 15(15), pages 1-18, July.
    8. Wen Ji & Fei Ni & Dinggang Gao & Shihui Luo & Qichao Lv & Dongyuan Lv, 2021. "Electromagnetic Design of High-Power and High-Speed Permanent Magnet Synchronous Motor Considering Loss Characteristics," Energies, MDPI, vol. 14(12), pages 1-19, June.
    9. Shaopeng Wu & Jinyang Zhou & Xinmiao Zhang & Jiaqiang Yu, 2022. "Design and Research on High Power Density Motor of Integrated Motor Drive System for Electric Vehicles," Energies, MDPI, vol. 15(10), pages 1-23, May.
    10. Carlos Vargas-Salgado & César Berna-Escriche & Alberto Escrivá-Castells & Dácil Díaz-Bello, 2022. "Optimization of All-Renewable Generation Mix According to Different Demand Response Scenarios to Cover All the Electricity Demand Forecast by 2040: The Case of the Grand Canary Island," Sustainability, MDPI, vol. 14(3), pages 1-29, February.
    11. Ruifeng Zhang & Bizhong Xia & Baohua Li & Yongzhi Lai & Weiwei Zheng & Huawen Wang & Wei Wang & Mingwang Wang, 2018. "Study on the Characteristics of a High Capacity Nickel Manganese Cobalt Oxide (NMC) Lithium-Ion Battery—An Experimental Investigation," Energies, MDPI, vol. 11(9), pages 1-20, August.
    12. Olabi, A.G. & Onumaegbu, C. & Wilberforce, Tabbi & Ramadan, Mohamad & Abdelkareem, Mohammad Ali & Al – Alami, Abdul Hai, 2021. "Critical review of energy storage systems," Energy, Elsevier, vol. 214(C).
    13. Abdul Ghani Olabi & Tabbi Wilberforce & Mohammad Ali Abdelkareem & Mohamad Ramadan, 2021. "Critical Review of Flywheel Energy Storage System," Energies, MDPI, vol. 14(8), pages 1-33, April.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ameen, Muhammad Tahir & Ma, Zhiwei & Smallbone, Andrew & Norman, Rose & Roskilly, Anthony Paul, 2023. "Demonstration system of pumped heat energy storage (PHES) and its round-trip efficiency," Applied Energy, Elsevier, vol. 333(C).
    2. Toufani, Parinaz & Nadar, Emre & Kocaman, Ayse Selin, 2022. "Short-term assessment of pumped hydro energy storage configurations: Up, down, or closed?," Renewable Energy, Elsevier, vol. 201(P1), pages 1086-1095.
    3. Herc, Luka & Pfeifer, Antun & Duić, Neven & Wang, Fei, 2022. "Economic viability of flexibility options for smart energy systems with high penetration of renewable energy," Energy, Elsevier, vol. 252(C).
    4. Savolainen, Rebecka & Lahdelma, Risto, 2022. "Optimization of renewable energy for buildings with energy storages and 15-minute power balance," Energy, Elsevier, vol. 243(C).
    5. Lopez-Ruiz, G. & Alava, I. & Blanco, J.M., 2021. "Study on the feasibility of the micromix combustion principle in low NOx H2 burners for domestic and industrial boilers: A numerical approach," Energy, Elsevier, vol. 236(C).
    6. Hilario J. Torres-Herrera & Alexis Lozano-Medina, 2021. "Methodological Proposal for the Assessment Potential of Pumped Hydropower Energy Storage: Case of Gran Canaria Island," Energies, MDPI, vol. 14(12), pages 1-27, June.
    7. Li, Jing & Zuo, Wei & E, Jiaqiang & Zhang, Yuntian & Li, Qingqing & Sun, Ke & Zhou, Kun & Zhang, Guangde, 2022. "Multi-objective optimization of mini U-channel cold plate with SiO2 nanofluid by RSM and NSGA-II," Energy, Elsevier, vol. 242(C).
    8. Alammar, Ahmed A. & Rezk, Ahmed & Alaswad, Abed & Fernando, Julia & Olabi, A.G. & Decker, Stephanie & Ruhumuliza, Joseph & Gasana, Quénan, 2022. "The technical, economic, and environmental feasibility of a bioheat-driven adsorption cooling system for food cold storing: A case study of Rwanda," Energy, Elsevier, vol. 258(C).
    9. Zhu, Lingfeng & Wang, Yinshun & Guo, Yuetong & Liu, Wei & Hu, Chengyang, 2023. "Current decay and compensation of a closed-loop HTS magnet in non-uniform magnetic fields based on electro-magneto-thermal semi-analytical analysis," Energy, Elsevier, vol. 277(C).
    10. Abdul Ghani Olabi & Enas Taha Sayed & Tabbi Wilberforce & Aisha Jamal & Abdul Hai Alami & Khaled Elsaid & Shek Mohammod Atiqure Rahman & Sheikh Khaleduzzaman Shah & Mohammad Ali Abdelkareem, 2021. "Metal-Air Batteries—A Review," Energies, MDPI, vol. 14(21), pages 1-46, November.
    11. He, Yi & Guo, Su & Zhou, Jianxu & Ye, Jilei & Huang, Jing & Zheng, Kun & Du, Xinru, 2022. "Multi-objective planning-operation co-optimization of renewable energy system with hybrid energy storages," Renewable Energy, Elsevier, vol. 184(C), pages 776-790.
    12. Maria M. Symeonidou & Effrosyni Giama & Agis M. Papadopoulos, 2021. "Life Cycle Assessment for Supporting Dimensioning Battery Storage Systems in Micro-Grids for Residential Applications," Energies, MDPI, vol. 14(19), pages 1-16, September.
    13. Yan, Lisen & Peng, Jun & Gao, Dianzhu & Wu, Yue & Liu, Yongjie & Li, Heng & Liu, Weirong & Huang, Zhiwu, 2022. "A hybrid method with cascaded structure for early-stage remaining useful life prediction of lithium-ion battery," Energy, Elsevier, vol. 243(C).
    14. Maria Symeonidou & Agis M. Papadopoulos, 2022. "Selection and Dimensioning of Energy Storage Systems for Standalone Communities: A Review," Energies, MDPI, vol. 15(22), pages 1-28, November.
    15. Yang, Ping & Ling, Weihao & Tian, Ke & Zeng, Min & Wang, Qiuwang, 2023. "Flow distribution and heat transfer performance of two-phase flow in parallel flow heat exchange system," Energy, Elsevier, vol. 270(C).
    16. Hongjin Hu & Haoze Wang & Kun Liu & Jingbo Wei & Xiangjie Shen, 2022. "A Simplified Space Vector Pulse Width Modulation Algorithm of a High-Speed Permanent Magnet Synchronous Machine Drive for a Flywheel Energy Storage System," Energies, MDPI, vol. 15(11), pages 1-21, June.
    17. Zhao, Pan & Gou, Feifei & Xu, Wenpan & Shi, Honghui & Wang, Jiangfeng, 2023. "Energy, exergy, economic and environmental (4E) analyses of an integrated system based on CH-CAES and electrical boiler for wind power penetration and CHP unit heat-power decoupling in wind enrichment," Energy, Elsevier, vol. 263(PC).
    18. Zhang, Wen-Yi & Chen, Yue & Wang, Yi & Xu, Yunjian, 2023. "Equilibrium analysis of a peer-to-peer energy trading market with shared energy storage in a power transmission grid," Energy, Elsevier, vol. 274(C).
    19. Osmani, Khaled & Haddad, Ahmad & Lemenand, Thierry & Castanier, Bruno & Ramadan, Mohamad, 2021. "An investigation on maximum power extraction algorithms from PV systems with corresponding DC-DC converters," Energy, Elsevier, vol. 224(C).
    20. Rashad, Magdi & Żabnieńska-Góra, Alina & Norman, Les & Jouhara, Hussam, 2022. "Analysis of energy demand in a residential building using TRNSYS," Energy, Elsevier, vol. 254(PB).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jcltec:v:4:y:2022:i:4:p:61-1000:d:939246. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.