IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v227y2024ics096014812400613x.html
   My bibliography  Save this article

Experimental study on dynamic power generation of three ORC-based cycle configurations under different heat source/sink conditions

Author

Listed:
  • Li, Tailu
  • Qiao, Yuwen
  • Wang, Zeyu
  • Zhang, Yao
  • Gao, Xiang
  • Yuan, Ye

Abstract

Organic Rankine cycle (ORC) is used for geothermal power generation, and other two derived cycle configurations, parallel double-stage organic Rankine cycle (PDORC) and organic Rankine flash cycle (ORFC), have been proposed to improve the geothermal power generation performance. However, no experimental comparison have been done before. An experimental device that can switch between three cycles was designed and constructed to compare the power generation performance of three cycles. The operational performance of the three cycles at different heat source and heat sink temperatures are analyzed in this paper. The results show that under the heat source temperature of 90 °C and heat sink temperature of 15 °C, the output power of ORFC is 876.59 W, which is higher than that of the PDORC and ORFC. Moreover, the exergetic efficiency is greater than other two cycles due to the smallest irreversible loss of ORFC. The exergetic efficiencies of the ORC, PDORC and ORFC are 31.87 %, 31.32 % and 34.79 %, respectively. The increase of heat sink temperature is beneficial for the isentropic efficiency of the expander, but not conducive to power generation performance and energy utilization. PDORC and ORFC promote the effective utilization of heat source, outputting more power but with a lower efficiency.

Suggested Citation

  • Li, Tailu & Qiao, Yuwen & Wang, Zeyu & Zhang, Yao & Gao, Xiang & Yuan, Ye, 2024. "Experimental study on dynamic power generation of three ORC-based cycle configurations under different heat source/sink conditions," Renewable Energy, Elsevier, vol. 227(C).
    • Handle: RePEc:eee:renene:v:227:y:2024:i:c:s096014812400613x
    DOI: 10.1016/j.renene.2024.120548
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S096014812400613X
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2024.120548?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Zhang, Xuanang & Wang, Xuan & Cai, Jinwen & He, Zhaoxian & Tian, Hua & Shu, Gequn & Shi, Lingfeng, 2022. "Experimental study on operating parameters matching characteristic of the organic Rankine cycle for engine waste heat recovery," Energy, Elsevier, vol. 244(PA).
    2. Meng, Dongyu & Liu, Qiang & Ji, Zhongli, 2022. "Effects of two-phase expander on the thermoeconomics of organic double-flash cycles for geothermal power generation," Energy, Elsevier, vol. 239(PD).
    3. Galloni, E. & Fontana, G. & Staccone, S., 2015. "Design and experimental analysis of a mini ORC (organic Rankine cycle) power plant based on R245fa working fluid," Energy, Elsevier, vol. 90(P1), pages 768-775.
    4. Pang, Kuo-Cheng & Chen, Shih-Chi & Hung, Tzu-Chen & Feng, Yong-Qiang & Yang, Shih-Cheng & Wong, Kin-Wah & Lin, Jaw-Ren, 2017. "Experimental study on organic Rankine cycle utilizing R245fa, R123 and their mixtures to investigate the maximum power generation from low-grade heat," Energy, Elsevier, vol. 133(C), pages 636-651.
    5. Li, Yung-Ming & Hung, Tzu-Chen & Wu, Chia-Jung & Su, Ting-Ying & Xi, Huan & Wang, Chi-Chuan, 2021. "Experimental investigation of 3-kW organic Rankine cycle (ORC) system subject to heat source conditions: A new appraisal for assessment," Energy, Elsevier, vol. 217(C).
    6. Tailu Li & Zeyu Wang & Jingyi Wang & Xiang Gao, 2023. "Dynamic Performance of Organic Rankine Cycle Driven by Fluctuant Industrial Waste Heat for Building Power Supply," Energies, MDPI, vol. 16(2), pages 1-24, January.
    7. Feng, Yong-qiang & Wang, Yu & Yao, Lin & Xu, Jing-wei & Zhang, Fei-yang & He, Zhi-xia & Wang, Qian & Ma, Jian-long, 2023. "Parametric analysis and thermal-economical optimization of a parallel dual pressure evaporation and two stage regenerative organic Rankine cycle using mixture working fluids," Energy, Elsevier, vol. 263(PA).
    8. Liu, Qiang & Duan, Yuanyuan & Yang, Zhen, 2013. "Performance analyses of geothermal organic Rankine cycles with selected hydrocarbon working fluids," Energy, Elsevier, vol. 63(C), pages 123-132.
    9. Wang, Lingbao & Bu, Xianbiao & Li, Huashan, 2020. "Multi-objective optimization and off-design evaluation of organic rankine cycle (ORC) for low-grade waste heat recovery," Energy, Elsevier, vol. 203(C).
    10. Li, Tailu & Zhu, Jialing & Hu, Kaiyong & Kang, Zhenhua & Zhang, Wei, 2014. "Implementation of PDORC (parallel double-evaporator organic Rankine cycle) to enhance power output in oilfield," Energy, Elsevier, vol. 68(C), pages 680-687.
    11. Hsieh, Jui-Ching & Chen, Yen-Hsun & Hsieh, Yi-Chi, 2023. "Experimental study of an organic Rankine cycle with a variable-rotational-speed scroll expander at various heat source temperatures," Energy, Elsevier, vol. 270(C).
    12. Dingbang, Cang & Cang, Chen & Qing, Chen & Lili, Sui & Caiyun, Cui, 2021. "Does new energy consumption conducive to controlling fossil energy consumption and carbon emissions?-Evidence from China," Resources Policy, Elsevier, vol. 74(C).
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Hsieh, Jui-Ching & Chen, Yen-Hsun & Hsieh, Yi-Chi, 2023. "Experimental study of an organic Rankine cycle with a variable-rotational-speed scroll expander at various heat source temperatures," Energy, Elsevier, vol. 270(C).
    2. Li, Jian & Liu, Qiang & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen & Di, Jiawei, 2017. "Optimized liquid-separated thermodynamic states for working fluids of organic Rankine cycles with liquid-separated condensation," Energy, Elsevier, vol. 141(C), pages 652-660.
    3. Li, Jian & Ge, Zhong & Duan, Yuanyuan & Yang, Zhen & Liu, Qiang, 2018. "Parametric optimization and thermodynamic performance comparison of single-pressure and dual-pressure evaporation organic Rankine cycles," Applied Energy, Elsevier, vol. 217(C), pages 409-421.
    4. Fahad Awjah Almehmadi & H. F. Elattar & A. Fouda & Saeed Alqaed & Jawed Mustafa & Mathkar A. Alharthi & H. A. Refaey, 2022. "Energy Performance Assessment of a Novel Solar Poly-Generation System Using Various ORC Working Fluids in Residential Buildings," Energies, MDPI, vol. 15(21), pages 1-25, November.
    5. Zhang, Xuanang & Wang, Xuan & Cai, Jinwen & Wang, Rui & Bian, Xingyan & He, Zhaoxian & Tian, Hua & Shu, Gequn, 2023. "Operation strategy of a multi-mode Organic Rankine cycle system for waste heat recovery from engine cooling water," Energy, Elsevier, vol. 263(PE).
    6. Liu, Liuchen & Zhu, Tong & Wang, Tiantian & Gao, Naiping, 2019. "Experimental investigation on the effect of working fluid charge in a small-scale Organic Rankine Cycle under off-design conditions," Energy, Elsevier, vol. 174(C), pages 664-677.
    7. Feng, Yong-Qiang & Zhang, Qiang & Xu, Kang-Jing & Wang, Chun-Ming & He, Zhi-Xia & Hung, Tzu-Chen, 2023. "Operation characteristics and performance prediction of a 3 kW organic Rankine cycle (ORC) with automatic control system based on machine learning methodology," Energy, Elsevier, vol. 263(PC).
    8. Meng, Dongyu & Liu, Qiang & Ji, Zhongli, 2022. "Effects of two-phase expander on the thermoeconomics of organic double-flash cycles for geothermal power generation," Energy, Elsevier, vol. 239(PD).
    9. Wang, Zhiqi & Pan, Huihui & Xia, Xiaoxia & Xie, Baoqi & Peng, Deqi & Yang, Huya, 2022. "Experimental investigation on steady and dynamic performance of organic Rankine cycle with R245fa/R141b under different cooling and expander speed conditions," Energy, Elsevier, vol. 241(C).
    10. Ayub, Mohammad & Mitsos, Alexander & Ghasemi, Hadi, 2015. "Thermo-economic analysis of a hybrid solar-binary geothermal power plant," Energy, Elsevier, vol. 87(C), pages 326-335.
    11. Zhang, Xuanang & Wang, Xuan & Cai, Jinwen & He, Zhaoxian & Tian, Hua & Shu, Gequn & Shi, Lingfeng, 2022. "Experimental study on operating parameters matching characteristic of the organic Rankine cycle for engine waste heat recovery," Energy, Elsevier, vol. 244(PA).
    12. Zhao, Ying-Kun & Lei, Biao & Wu, Yu-Ting & Zhi, Rui-Ping & Wang, Wei & Guo, Hang & Ma, Chong-Fang, 2018. "Experimental study on the net efficiency of an Organic Rankine Cycle with single screw expander in different seasons," Energy, Elsevier, vol. 165(PB), pages 769-775.
    13. Yugang He & Chunlei Wang, 2022. "Does Buddhist Tourism Successfully Result in Local Sustainable Development?," Sustainability, MDPI, vol. 14(6), pages 1-15, March.
    14. Tieyu Gao & Changwei Liu, 2017. "Off-Design Performances of Subcritical and Supercritical Organic Rankine Cycles in Geothermal Power Systems under an Optimal Control Strategy," Energies, MDPI, vol. 10(8), pages 1-25, August.
    15. Tera, Ibrahim & Zhang, Shengan & Liu, Guilian, 2024. "A conceptual hydrogen, heat and power polygeneration system based on biomass gasification, SOFC and waste heat recovery units: Energy, exergy, economic and emergy (4E) assessment," Energy, Elsevier, vol. 295(C).
    16. Moradi, Ramin & Habib, Emanuele & Bocci, Enrico & Cioccolanti, Luca, 2020. "Investigation on the use of a novel regenerative flow turbine in a micro-scale Organic Rankine Cycle unit," Energy, Elsevier, vol. 210(C).
    17. Campana, Claudio & Cioccolanti, Luca & Renzi, Massimiliano & Caresana, Flavio, 2019. "Experimental analysis of a small-scale scroll expander for low-temperature waste heat recovery in Organic Rankine Cycle," Energy, Elsevier, vol. 187(C).
    18. Xi, Huan & Zhang, Honghu & He, Ya-Ling & Huang, Zuohua, 2019. "Sensitivity analysis of operation parameters on the system performance of organic rankine cycle system using orthogonal experiment," Energy, Elsevier, vol. 172(C), pages 435-442.
    19. Lisheng Pan & Huaixin Wang, 2019. "Experimental Investigation on Performance of an Organic Rankine Cycle System Integrated with a Radial Flow Turbine," Energies, MDPI, vol. 12(4), pages 1-20, February.
    20. Ghasemi, Hadi & Sheu, Elysia & Tizzanini, Alessio & Paci, Marco & Mitsos, Alexander, 2014. "Hybrid solar–geothermal power generation: Optimal retrofitting," Applied Energy, Elsevier, vol. 131(C), pages 158-170.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:227:y:2024:i:c:s096014812400613x. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.