IDEAS home Printed from https://ideas.repec.org/a/eee/renene/v165y2021ip1p288-300.html
   My bibliography  Save this article

Spike-type disturbances due to inlet distortion in a centrifugal pump

Author

Listed:
  • Cao, Puyu
  • Zhu, Rui
  • Yin, Gang

Abstract

An inlet elbow installed upstream of centrifugal pump produces distorted suction flow. In this paper, numerical simulation is conducted to investigate interactions between impeller and inlet distortion, with emphasis on the consequent upstream disturbances. At the design point, velocity, pressure and swirling strength at the upstream section are extracted successively to describe the initial upstream disturbance, i.e., a spanwise vortex bubble (IVB1) on inner wall. Additionally, a detailed analysis allow identifications of flow separation and vortex: high incidence due to IVB1 generates two focus-type separations, then separations evolve into two concentrated separation vortices (CSV1 and 2) spanning from the suction surface to the upstream casing. Vortical flow field is further discussed to reveal CSV’s effect on the suction flow: casing-side end of CSV1 moves upstream to form a new vortex bubble (IVB2), which approaches to IVB1 and blocks impeller inlet; vortex-trail of CSV2 with an associated blockage induces another vortex bubble (IVB3) between IVB2 and CSV2. Therefore, new IVBs enhance upstream disturbances and exert a new pressure trace on inner wall, where a vortex bubble produces a rapid pressure drop followed by a sharp pressure rise due to a partial blockage. The resultant down-up waveform demonstrates enhanced disturbances are spike-type.

Suggested Citation

  • Cao, Puyu & Zhu, Rui & Yin, Gang, 2021. "Spike-type disturbances due to inlet distortion in a centrifugal pump," Renewable Energy, Elsevier, vol. 165(P1), pages 288-300.
    • Handle: RePEc:eee:renene:v:165:y:2021:i:p1:p:288-300
    DOI: 10.1016/j.renene.2020.11.060
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0960148120318036
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.renene.2020.11.060?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Zhang, Ning & Jiang, Junxian & Gao, Bo & Liu, Xiaokai, 2020. "DDES analysis of unsteady flow evolution and pressure pulsation at off-design condition of a centrifugal pump," Renewable Energy, Elsevier, vol. 153(C), pages 193-204.
    2. Zhang, Ning & Jiang, Junxian & Gao, Bo & Liu, Xiaokai & Ni, Dan, 2020. "Numerical analysis of the vortical structure and its unsteady evolution of a centrifugal pump," Renewable Energy, Elsevier, vol. 155(C), pages 748-760.
    3. Shi, Lijian & Zhang, Wenpeng & Jiao, Haifeng & Tang, Fangping & Wang, Li & Sun, Dandan & Shi, Wei, 2020. "Numerical simulation and experimental study on the comparison of the hydraulic characteristics of an axial-flow pump and a full tubular pump," Renewable Energy, Elsevier, vol. 153(C), pages 1455-1464.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Su, Wen-Tao & Binama, Maxime & Li, Yang & Zhao, Yue, 2020. "Study on the method of reducing the pressure fluctuation of hydraulic turbine by optimizing the draft tube pressure distribution," Renewable Energy, Elsevier, vol. 162(C), pages 550-560.
    2. Dehghan, Amir Arsalan & Shojaeefard, Mohammad Hassan & Roshanaei, Maryam, 2024. "Exploring a new criterion to determine the onset of cavitation in centrifugal pumps from energy-saving standpoint; experimental and numerical investigation," Energy, Elsevier, vol. 293(C).
    3. He, Y. & Tao, Y.B. & Zhao, C.Y. & Yu, X.K., 2022. "Structure parameter analysis and optimization of photovoltaic-phase change material-thermoelectric coupling system under space conditions," Renewable Energy, Elsevier, vol. 200(C), pages 320-333.
    4. Xu, Zhe & Zheng, Yuan & Kan, Kan & Chen, Huixiang, 2023. "Flow instability and energy performance of a coastal axial-flow pump as turbine under the influence of upstream waves," Energy, Elsevier, vol. 272(C).
    5. Weixuan Jiao & Di Zhang & Chuan Wang & Li Cheng & Tao Wang, 2020. "Unsteady Numerical Calculation of Oblique Submerged Jet," Energies, MDPI, vol. 13(18), pages 1-13, September.
    6. Chengshuo Wu & Jun Yang & Shuai Yang & Peng Wu & Bin Huang & Dazhuan Wu, 2023. "A Review of Fluid-Induced Excitations in Centrifugal Pumps," Mathematics, MDPI, vol. 11(4), pages 1-20, February.
    7. Zhenhua Zhou & Huacong Li & Jinbo Chen & Delin Li & Ning Zhang, 2023. "Numerical Simulation on Transient Pressure Pulsations and Complex Flow Structures of a Ultra-High-Speed Centrifugal Pump at Stalled Condition," Energies, MDPI, vol. 16(11), pages 1-17, June.
    8. Ni, Dan & Zhang, Ning & Gao, Bo & Li, Zhong & Yang, Minguan, 2020. "Dynamic measurements on unsteady pressure pulsations and flow distributions in a nuclear reactor coolant pump," Energy, Elsevier, vol. 198(C).
    9. Yangyang Wei & Yuhui Shi & Weidong Shi & Bo Pan, 2022. "Numerical Analysis and Experimental Study of Unsteady Flow Characteristics in an Ultra-Low Specific Speed Centrifugal Pump," Sustainability, MDPI, vol. 14(24), pages 1-15, December.
    10. Ning Zhang & Delin Li & Junxian Jiang & Bo Gao & Dan Ni & Anthony Akurugo Alubokin & Wenbin Zhang, 2023. "Experimental Investigation on Velocity Fluctuation in a Vaned Diffuser Centrifugal Pump Measured by Laser Doppler Anemometry," Energies, MDPI, vol. 16(7), pages 1-17, April.
    11. Kan, Kan & Xu, Zhe & Chen, Huixiang & Xu, Hui & Zheng, Yuan & Zhou, Daqing & Muhirwa, Alexis & Maxime, Binama, 2022. "Energy loss mechanisms of transition from pump mode to turbine mode of an axial-flow pump under bidirectional conditions," Energy, Elsevier, vol. 257(C).
    12. Hao Yu & Chuan Wang & Guohui Li & Hongliang Wang & Yang Yang & Shaohui Wu & Weidong Cao & Shanshan Li, 2023. "Steady and Unsteady Flow Characteristics inside Short Jet Self-Priming Pump," Sustainability, MDPI, vol. 15(18), pages 1-23, September.
    13. Wenpeng Zhang & Fangping Tang & Lijian Shi & Qiujin Hu & Ying Zhou, 2020. "Effects of an Inlet Vortex on the Performance of an Axial-Flow Pump," Energies, MDPI, vol. 13(11), pages 1-23, June.
    14. Shi, Lijian & Yuan, Yao & Jiao, Haifeng & Tang, Fangping & Cheng, Li & Yang, Fan & Jin, Yan & Zhu, Jun, 2021. "Numerical investigation and experiment on pressure pulsation characteristics in a full tubular pump," Renewable Energy, Elsevier, vol. 163(C), pages 987-1000.
    15. Hongliang Wang & Bing Long & Chuan Wang & Chen Han & Linjian Li, 2020. "Effects of the Impeller Blade with a Slot Structure on the Centrifugal Pump Performance," Energies, MDPI, vol. 13(7), pages 1-17, April.
    16. Mu, Tong & Zhang, Rui & Xu, Hui & Zheng, Yuan & Fei, Zhaodan & Li, Jinghong, 2020. "Study on improvement of hydraulic performance and internal flow pattern of the axial flow pump by groove flow control technology," Renewable Energy, Elsevier, vol. 160(C), pages 756-769.
    17. Jian-Cheng Cai & Hao-Jie Chen & Volodymyr Brazhenko & Yi-Hong Gu, 2021. "Study of the Hydrodynamic Unsteady Flow Inside a Centrifugal Fan and Its Downstream Pipe Using Detached Eddy Simulation," Sustainability, MDPI, vol. 13(9), pages 1-19, May.
    18. Zhang, Ning & Jiang, Junxian & Gao, Bo & Liu, Xiaokai & Ni, Dan, 2020. "Numerical analysis of the vortical structure and its unsteady evolution of a centrifugal pump," Renewable Energy, Elsevier, vol. 155(C), pages 748-760.
    19. Lijian Shi & Jun Zhu & Li Wang & Shiji Chu & Fangping Tang & Yan Jin, 2021. "Comparative Analysis of Strength and Modal Characteristics of a Full Tubular Pump and an Axial Flow Pump Impellers Based on Fluid-Structure Interaction," Energies, MDPI, vol. 14(19), pages 1-18, October.
    20. Ziyi Mei & Bo Gao & Ning Zhang & Yuanqing Lai & Guoping Li, 2022. "Numerical Study on the Unsteady Flow Field Characteristics of a Podded Propulsor Based on DDES Method," Energies, MDPI, vol. 15(23), pages 1-25, December.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:renene:v:165:y:2021:i:p1:p:288-300. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/renewable-energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.