IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v263y2023ipds0360544222025944.html
   My bibliography  Save this article

Evaluation of the effects of optimization of gas boiler burner control by means of an innovative method of Fuel Input Factor

Author

Listed:
  • Bartnicki, Grzegorz
  • Klimczak, Marcin
  • Ziembicki, Piotr

Abstract

In the course of the research, the authors diagnosed the necessity to constantly search for solutions increasing the efficiency of converting primary energy into useful energy, in particular in heat sources equipped with systems powered by gaseous fuel. This is especially important in the EU countries, where on average approx. 46% of heat is produced by means of natural gas. This problem is particularly important in the context of the growing requirements to reduce greenhouse gas emissions and the guidelines related to the decarbonization plan for all European Union countries. Therefore, the authors conducted operational tests of the existing heat sources based on low-temperature gas boilers, the purpose of which was to identify and analyze the possibility of their optimization, with particular emphasis on increasing the efficiency of primary energy conversion and reducing emissions of such pollutants as greenhouse gases. The work uses a method of practical optimization, which makes use of measurement data in order to identify the parameters of gas boilers which are susceptible to improvement, and then improves these parameters. The several-year-long research was carried out with various configurations of energy sources in various technological systems, while the final analysis covered operating data from two gas boiler houses collected over 200 full days, in which measurements were carried out continuously to ensure high quality of measurement data. The article presents an assessment of the efficiency of gas boiler houses conducted by means of a fuel input coefficient (FIF) developed by the authors. The influence of selected factors on the efficiency of heat generation processes was also analyzed, including: external temperature, the amount of domestic hot water consumption, and above all, methods of controlling heat source devices. The effects were assessed using the FIF. It has been shown that the method of comparing the operation of heat sources based on the fuel input coefficient (FIF) is an effective diagnostic tool to verify the correctness of boiler room operation, and that appropriate settings in boiler operation can significantly affect the energy efficiency of sources and reduce greenhouse gas emissions.

Suggested Citation

  • Bartnicki, Grzegorz & Klimczak, Marcin & Ziembicki, Piotr, 2023. "Evaluation of the effects of optimization of gas boiler burner control by means of an innovative method of Fuel Input Factor," Energy, Elsevier, vol. 263(PD).
    • Handle: RePEc:eee:energy:v:263:y:2023:i:pd:s0360544222025944
    DOI: 10.1016/j.energy.2022.125708
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544222025944
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2022.125708?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Lee, Jae Yong & Yim, Taesu, 2021. "Energy and flow demand analysis of domestic hot water in an apartment complex using a smart meter," Energy, Elsevier, vol. 229(C).
    2. Li, Qingwei & Yao, Guihuan, 2017. "Improved coal combustion optimization model based on load balance and coal qualities," Energy, Elsevier, vol. 132(C), pages 204-212.
    3. Martinopoulos, Georgios & Papakostas, Konstantinos T. & Papadopoulos, Agis M., 2018. "A comparative review of heating systems in EU countries, based on efficiency and fuel cost," Renewable and Sustainable Energy Reviews, Elsevier, vol. 90(C), pages 687-699.
    4. Alexandre K. Magnan & Hans-Otto Pörtner & Virginie K. E. Duvat & Matthias Garschagen & Valeria A. Guinder & Zinta Zommers & Ove Hoegh-Guldberg & Jean-Pierre Gattuso, 2021. "Estimating the global risk of anthropogenic climate change," Nature Climate Change, Nature, vol. 11(10), pages 879-885, October.
    5. Gustafsson, Jonas & Delsing, Jerker & van Deventer, Jan, 2010. "Improved district heating substation efficiency with a new control strategy," Applied Energy, Elsevier, vol. 87(6), pages 1996-2004, June.
    6. Lisa Maria Dellmuth & Maria-Therese Gustafsson, 2021. "Global adaptation governance: how intergovernmental organizations mainstream climate change adaptation," Climate Policy, Taylor & Francis Journals, vol. 21(7), pages 868-883, August.
    7. Ommen, Torben & Markussen, Wiebke Brix & Elmegaard, Brian, 2016. "Lowering district heating temperatures – Impact to system performance in current and future Danish energy scenarios," Energy, Elsevier, vol. 94(C), pages 273-291.
    8. Lake, Andrew & Rezaie, Behanz & Beyerlein, Steven, 2017. "Review of district heating and cooling systems for a sustainable future," Renewable and Sustainable Energy Reviews, Elsevier, vol. 67(C), pages 417-425.
    9. ., 2021. "Global climate change," Chapters, in: The Global Rise of the Modern Plug-In Electric Vehicle, chapter 5, pages 143-181, Edward Elgar Publishing.
    10. Sayegh, M.A. & Danielewicz, J. & Nannou, T. & Miniewicz, M. & Jadwiszczak, P. & Piekarska, K. & Jouhara, H., 2017. "Trends of European research and development in district heating technologies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 68(P2), pages 1183-1192.
    11. Hast, Aira & Syri, Sanna & Lekavičius, Vidas & Galinis, Arvydas, 2018. "District heating in cities as a part of low-carbon energy system," Energy, Elsevier, vol. 152(C), pages 627-639.
    12. Yan Xu & Kun Yang & Jiahui Zhou & Guohao Zhao, 2020. "Coal-Biomass Co-Firing Power Generation Technology: Current Status, Challenges and Policy Implications," Sustainability, MDPI, vol. 12(9), pages 1-18, May.
    13. Mikulandrić, Robert & Lončar, Dražen & Cvetinović, Dejan & Spiridon, Gabriel, 2013. "Improvement of existing coal fired thermal power plants performance by control systems modifications," Energy, Elsevier, vol. 57(C), pages 55-65.
    14. Xu, Gang & Huang, Shengwei & Yang, Yongping & Wu, Ying & Zhang, Kai & Xu, Cheng, 2013. "Techno-economic analysis and optimization of the heat recovery of utility boiler flue gas," Applied Energy, Elsevier, vol. 112(C), pages 907-917.
    15. Höök, Mikael & Tang, Xu, 2013. "Depletion of fossil fuels and anthropogenic climate change—A review," Energy Policy, Elsevier, vol. 52(C), pages 797-809.
    16. Leoni, Paolo & Geyer, Roman & Schmidt, Ralf-Roman, 2020. "Developing innovative business models for reducing return temperatures in district heating systems: Approach and first results," Energy, Elsevier, vol. 195(C).
    17. Diana Ivanova & Milena Büchs, 2020. "Household Sharing for Carbon and Energy Reductions: The Case of EU Countries," Energies, MDPI, vol. 13(8), pages 1-28, April.
    18. Piotr Ziembicki & Joachim Kozioł & Jan Bernasiński & Ireneusz Nowogoński, 2019. "Innovative System for Heat Recovery and Combustion Gas Cleaning," Energies, MDPI, vol. 12(22), pages 1-13, November.
    19. Shi, Yan & Zhong, Wenqi & Chen, Xi & Yu, A.B. & Li, Jie, 2019. "Combustion optimization of ultra supercritical boiler based on artificial intelligence," Energy, Elsevier, vol. 170(C), pages 804-817.
    20. Wang, Haichao & Yin, Wusong & Abdollahi, Elnaz & Lahdelma, Risto & Jiao, Wenling, 2015. "Modelling and optimization of CHP based district heating system with renewable energy production and energy storage," Applied Energy, Elsevier, vol. 159(C), pages 401-421.
    21. Pietrapertosa, Filomena & Khokhlov, Valeriy & Salvia, Monica & Cosmi, Carmelina, 2018. "Climate change adaptation policies and plans: A survey in 11 South East European countries," Renewable and Sustainable Energy Reviews, Elsevier, vol. 81(P2), pages 3041-3050.
    22. He, Zhaoyu & Guo, Weimin & Zhang, Peng, 2022. "Performance prediction, optimal design and operational control of thermal energy storage using artificial intelligence methods," Renewable and Sustainable Energy Reviews, Elsevier, vol. 156(C).
    23. Nis Bertelsen & Brian Vad Mathiesen, 2020. "EU-28 Residential Heat Supply and Consumption: Historical Development and Status," Energies, MDPI, vol. 13(8), pages 1-21, April.
    24. Joachim Kozioł & Joanna Czubala & Michał Kozioł & Piotr Ziembicki, 2020. "Generalized Energy and Ecological Characteristics of the Process of Co-Firing Coal with Biomass in a Steam Boiler," Energies, MDPI, vol. 13(10), pages 1-12, May.
    25. Gabriela Iacobuta & Navroz K. Dubash & Prabhat Upadhyaya & Mekdelawit Deribe & Niklas Höhne, 2018. "National climate change mitigation legislation, strategy and targets: a global update," Climate Policy, Taylor & Francis Journals, vol. 18(9), pages 1114-1132, October.
    26. Shamshirband, Shahaboddin & Petković, Dalibor & Enayatifar, Rasul & Hanan Abdullah, Abdul & Marković, Dušan & Lee, Malrey & Ahmad, Rodina, 2015. "Heat load prediction in district heating systems with adaptive neuro-fuzzy method," Renewable and Sustainable Energy Reviews, Elsevier, vol. 48(C), pages 760-767.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Sang-Mok Lee & So-Won Choi & Eul-Bum Lee, 2023. "Prediction Modeling of Flue Gas Control for Combustion Efficiency Optimization for Steel Mill Power Plant Boilers Based on Partial Least Squares Regression (PLSR)," Energies, MDPI, vol. 16(19), pages 1-33, September.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Golmohamadi, Hessam & Larsen, Kim Guldstrand & Jensen, Peter Gjøl & Hasrat, Imran Riaz, 2022. "Integration of flexibility potentials of district heating systems into electricity markets: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 159(C).
    2. Guelpa, Elisa & Verda, Vittorio, 2021. "Demand response and other demand side management techniques for district heating: A review," Energy, Elsevier, vol. 219(C).
    3. Antonino D’Amico & Domenico Panno & Giuseppina Ciulla & Antonio Messineo, 2020. "Multi-Energy School System for Seasonal Use in the Mediterranean Area," Sustainability, MDPI, vol. 12(20), pages 1-27, October.
    4. Beatriz María Paredes-Sánchez & José Pablo Paredes & Natalia Caparrini & Elena Rivo-López, 2021. "Analysis of District Heating and Cooling Energy Systems in Spain: Resources, Technology and Management," Sustainability, MDPI, vol. 13(10), pages 1-22, May.
    5. Mazhar, Abdur Rehman & Liu, Shuli & Shukla, Ashish, 2018. "A state of art review on the district heating systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 96(C), pages 420-439.
    6. Neumayer, Martin & Stecher, Dominik & Grimm, Sebastian & Maier, Andreas & Bücker, Dominikus & Schmidt, Jochen, 2023. "Fault and anomaly detection in district heating substations: A survey on methodology and data sets," Energy, Elsevier, vol. 276(C).
    7. Marcin Klimczak & Grzegorz Bartnicki & Piotr Ziembicki, 2022. "Energy Consumption by DHW System with a Circulation Loop as an Energy Efficiency Component, Based on an Example of a Residential Building," Energies, MDPI, vol. 15(11), pages 1-18, May.
    8. Ary José A. Souza-Jr., 2022. "Subjective well-being and climate change: Evidence for Portugal," Working Papers REM 2022/0213, ISEG - Lisbon School of Economics and Management, REM, Universidade de Lisboa.
    9. Badami, Marco & Fonti, Antonio & Carpignano, Andrea & Grosso, Daniele, 2018. "Design of district heating networks through an integrated thermo-fluid dynamics and reliability modelling approach," Energy, Elsevier, vol. 144(C), pages 826-838.
    10. Alessandro Guzzini & Marco Pellegrini & Edoardo Pelliconi & Cesare Saccani, 2020. "Low Temperature District Heating: An Expert Opinion Survey," Energies, MDPI, vol. 13(4), pages 1-34, February.
    11. Michael-Allan Millar & Neil M. Burnside & Zhibin Yu, 2019. "District Heating Challenges for the UK," Energies, MDPI, vol. 12(2), pages 1-21, January.
    12. Heng Chen & Zhen Qi & Qiao Chen & Yunyun Wu & Gang Xu & Yongping Yang, 2018. "Modified High Back-Pressure Heating System Integrated with Raw Coal Pre-Drying in Combined Heat and Power Unit," Energies, MDPI, vol. 11(9), pages 1-16, September.
    13. Averfalk, Helge & Ingvarsson, Paul & Persson, Urban & Gong, Mei & Werner, Sven, 2017. "Large heat pumps in Swedish district heating systems," Renewable and Sustainable Energy Reviews, Elsevier, vol. 79(C), pages 1275-1284.
    14. Levihn, Fabian, 2017. "CHP and heat pumps to balance renewable power production: Lessons from the district heating network in Stockholm," Energy, Elsevier, vol. 137(C), pages 670-678.
    15. Werner, Sven, 2017. "International review of district heating and cooling," Energy, Elsevier, vol. 137(C), pages 617-631.
    16. Ziemele, Jelena & Cilinskis, Einars & Blumberga, Dagnija, 2018. "Pathway and restriction in district heating systems development towards 4th generation district heating," Energy, Elsevier, vol. 152(C), pages 108-118.
    17. Zhao, Jing & Duan, Yaoqi & Liu, Xiaojuan, 2019. "Study on the policy of replacing coal-fired boilers with gas-fired boilers for central heating based on the 3E system and the TOPSIS method: A case in Tianjin, China," Energy, Elsevier, vol. 189(C).
    18. Turski, Michał & Nogaj, Kinga & Sekret, Robert, 2019. "The use of a PCM heat accumulator to improve the efficiency of the district heating substation," Energy, Elsevier, vol. 187(C).
    19. Østergaard, Poul Alberg & Andersen, Anders N. & Sorknæs, Peter, 2022. "The business-economic energy system modelling tool energyPRO," Energy, Elsevier, vol. 257(C).
    20. Ferrari, Simone & Zagarella, Federica & Caputo, Paola & D'Amico, Antonino, 2019. "Results of a literature review on methods for estimating buildings energy demand at district level," Energy, Elsevier, vol. 175(C), pages 1130-1137.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:263:y:2023:i:pd:s0360544222025944. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.