IDEAS home Printed from https://ideas.repec.org/a/eee/appene/v218y2018icp46-53.html
   My bibliography  Save this article

Ultra-fine particulate matters (PMs) formation during air and oxy-coal combustion: Kinetics study

Author

Listed:
  • Niu, Yanqing
  • Yan, Bokang
  • Liu, Siqi
  • Liang, Yang
  • Dong, Ning
  • Hui, Shi'en

Abstract

Although both air (21O2/N2) and oxy-coal (27O2/CO2) combustion are widely adopted in pulverized coal (PC) fired power plants, the formation mechanisms of ultra-fine PMs during PC char combustion under both atmospheres with various flue gas recirculation (FGR) ratios are still unclear. Moreover, conventional experimental measurement devices cannot provide detailed information on the formation and evolution of the size-number of ultra-fine PMs. Therefore, the formation of ultra-fine PMs during PC char combustion under both atmopspheres with and without FGR are studied by a self-developed Char Burning and Particulate Matters Kinetics model (CBPMK). The PC char shows similar burning temperature and thus ash vaporization rate under both atmospheres, whereas the vaporization amount under oxy-coal combustion atmosphere is lower than that under air combustion atmosphere due to the shortened burnout time caused by CO2 gasification reaction under the former. Consequently, during nucleation and condensation stages (before successive coalescence), both the particle size and number under air combustion atmosphere are higher than those under oxy-coal combustion atmosphere. However, after coalescence, the final particle shows fewer but larger size under oxy-coal combustion atmosphere due to the higher cohesion factor between the smaller sized nucleation particles, which improves particle collision and coalescence. Meanwhile, both mean size and number density of the nucleation particles decrease with increased FGR ratio under both air and oxy-coal combustion atmospheres, however, after coalescence the final PMs show increasing number density and decreasing size. As results, oxy-coal combustion advantages PMs removal through an ash collector, but elevated FGR ratio disadvantages PMs removal. Oxy-coal combustion with low FGR ratio should be recommended in PC thermal and power plants.

Suggested Citation

  • Niu, Yanqing & Yan, Bokang & Liu, Siqi & Liang, Yang & Dong, Ning & Hui, Shi'en, 2018. "Ultra-fine particulate matters (PMs) formation during air and oxy-coal combustion: Kinetics study," Applied Energy, Elsevier, vol. 218(C), pages 46-53.
    • Handle: RePEc:eee:appene:v:218:y:2018:i:c:p:46-53
    DOI: 10.1016/j.apenergy.2018.02.164
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0306261918302988
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.apenergy.2018.02.164?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Qi, Guojie & Wang, Shujuan, 2017. "Experimental study and rate-based modeling on combined CO2 and SO2 absorption using aqueous NH3 in packed column," Applied Energy, Elsevier, vol. 206(C), pages 1532-1543.
    2. Ortiz, C. & Valverde, J.M. & Chacartegui, R. & Benítez-Guerrero, M. & Perejón, A. & Romeo, L.M., 2017. "The Oxy-CaL process: A novel CO2 capture system by integrating partial oxy-combustion with the Calcium-Looping process," Applied Energy, Elsevier, vol. 196(C), pages 1-17.
    3. Meng, Jing & Liu, Junfeng & Guo, Shan & Huang, Ye & Tao, Shu, 2016. "The impact of domestic and foreign trade on energy-related PM emissions in Beijing," Applied Energy, Elsevier, vol. 184(C), pages 853-862.
    4. Tan, Houzhang & Niu, Yanqing & Wang, Xuebin & Xu, Tongmo & Hui, Shien, 2011. "Study of optimal pulverized coal concentration in a four-wall tangentially fired furnace," Applied Energy, Elsevier, vol. 88(4), pages 1164-1168, April.
    5. Xu, Yishu & Liu, Xiaowei & Zhou, Zijian & Sheng, Lei & Wang, Chao & Xu, Minghou, 2014. "The role of steam in silica vaporization and ultrafine particulate matter formation during wet oxy-coal combustion," Applied Energy, Elsevier, vol. 133(C), pages 144-151.
    6. Gimeno, Beatriz & Artal, Manuela & Velasco, Inmaculada & Blanco, Sofía T. & Fernández, Javier, 2017. "Influence of SO2 on CO2 storage for CCS technology: Evaluation of CO2/SO2 co-capture," Applied Energy, Elsevier, vol. 206(C), pages 172-180.
    7. Dong, Huijuan & Dai, Hancheng & Dong, Liang & Fujita, Tsuyoshi & Geng, Yong & Klimont, Zbigniew & Inoue, Tsuyoshi & Bunya, Shintaro & Fujii, Minoru & Masui, Toshihiko, 2015. "Pursuing air pollutant co-benefits of CO2 mitigation in China: A provincial leveled analysis," Applied Energy, Elsevier, vol. 144(C), pages 165-174.
    8. Art Fernandez & Sheldon B. Davis & Jost O. L. Wendt & Roberta Cenni & R. Scott Young & Mark L. Witten, 2001. "Particulate emission from biomass combustion," Nature, Nature, vol. 409(6823), pages 998-998, February.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Choi, Minsung & Hwang, Taegam & Park, Yeseul & Li, Xinzhuo & Kim, Junsung & Kim, Kibeom & Sung, Yonmo & Choi, Gyungmin, 2023. "Numerical evaluation of the effect of swirl configuration and fuel-rich environment on combustion and emission characteristics in a coal-fired boiler," Energy, Elsevier, vol. 268(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Zhao, Hongyan & Zhang, Qiang & Huo, Hong & Lin, Jintai & Liu, Zhu & Wang, Haikun & Guan, Dabo & He, Kebin, 2016. "Environment-economy tradeoff for Beijing–Tianjin–Hebei’s exports," Applied Energy, Elsevier, vol. 184(C), pages 926-935.
    2. Li, Wenjia & Hao, Yong & Wang, Hongsheng & Liu, Hao & Sui, Jun, 2017. "Efficient and low-carbon heat and power cogeneration with photovoltaics and thermochemical storage," Applied Energy, Elsevier, vol. 206(C), pages 1523-1531.
    3. Ke Zhang & Xingwei Wang, 2021. "Pollution Haven Hypothesis of Global CO 2 , SO 2 , NO x —Evidence from 43 Economies and 56 Sectors," IJERPH, MDPI, vol. 18(12), pages 1-27, June.
    4. Yang Yang & Ji-Qin Ni & Weiqing Bao & Lei Zhao & Guang Hui Xie, 2019. "Potential Reductions in Greenhouse Gas and Fine Particulate Matter Emissions Using Corn Stover for Ethanol Production in China," Energies, MDPI, vol. 12(19), pages 1-14, September.
    5. Xiao, Zhihua & Yuan, Xingzhong & Jiang, Longbo & Chen, Xiaohong & Li, Hui & Zeng, Guangming & Leng, Lijian & Wang, Hou & Huang, Huajun, 2015. "Energy recovery and secondary pollutant emission from the combustion of co-pelletized fuel from municipal sewage sludge and wood sawdust," Energy, Elsevier, vol. 91(C), pages 441-450.
    6. Wesseh, Presley K. & Lin, Boqiang, 2018. "Optimal carbon taxes for China and implications for power generation, welfare, and the environment," Energy Policy, Elsevier, vol. 118(C), pages 1-8.
    7. Xi Yang & Xiaoqian Xi & Shan Guo & Wanqi Lin & Xiangzhao Feng, 2018. "Carbon Mitigation Pathway Evaluation and Environmental Benefit Analysis of Mitigation Technologies in China’s Petrochemical and Chemical Industry," Energies, MDPI, vol. 11(12), pages 1-25, November.
    8. Yang, Jin & Song, Dan & Wu, Feng, 2017. "Regional variations of environmental co-benefits of wind power generation in China," Applied Energy, Elsevier, vol. 206(C), pages 1267-1281.
    9. Li, Wei & Jia, Zhijie, 2016. "The impact of emission trading scheme and the ratio of free quota: A dynamic recursive CGE model in China," Applied Energy, Elsevier, vol. 174(C), pages 1-14.
    10. Shichun Xu & Wenwen Zhang & Qinbin Li & Bin Zhao & Shuxiao Wang & Ruyin Long, 2017. "Decomposition Analysis of the Factors that Influence Energy Related Air Pollutant Emission Changes in China Using the SDA Method," Sustainability, MDPI, vol. 9(10), pages 1-18, September.
    11. Li, Yanmei & Cui, Yifei & Cai, Bofeng & Guo, Jingpeng & Cheng, Tianhai & Zheng, Fengjie, 2020. "Spatial characteristics of CO2 emissions and PM2.5 concentrations in China based on gridded data," Applied Energy, Elsevier, vol. 266(C).
    12. Li, Wei & Jia, Zhijie & Zhang, Hongzhi, 2017. "The impact of electric vehicles and CCS in the context of emission trading scheme in China: A CGE-based analysis," Energy, Elsevier, vol. 119(C), pages 800-816.
    13. Yongsheng Lin & Zhe Liu & Rui Liu & Xiaoman Yu & Liming Zhang, 2020. "Uncovering driving forces of co-benefits achieved by eco-industrial development strategies at the scale of industrial park," Energy & Environment, , vol. 31(2), pages 275-290, March.
    14. Wang, Qingxiang & Chen, Zhichao & Han, Hui & Zeng, Lingyan & Li, Zhengqi, 2019. "Experimental characterization of anthracite combustion and NOx emission for a 300-MWe down-fired boiler with a novel combustion system: Influence of primary and vent air distributions," Applied Energy, Elsevier, vol. 238(C), pages 1551-1562.
    15. Li, Jia Shuo & Zhou, H.W. & Meng, Jing & Yang, Q. & Chen, B. & Zhang, Y.Y., 2018. "Carbon emissions and their drivers for a typical urban economy from multiple perspectives: A case analysis for Beijing city," Applied Energy, Elsevier, vol. 226(C), pages 1076-1086.
    16. Liu, Chunlong & Li, Zhengqi & Zeng, Lingyan & Zhang, Qinghua & Hu, Richa & Zhang, Xusheng & Guo, Liang & Huang, Yong & Yang, Xianwei & Chen, Liheng, 2016. "Gas/particle two-phase flow characteristics of a down-fired 350 MWe supercritical utility boiler at different tertiary air ratios," Energy, Elsevier, vol. 102(C), pages 54-64.
    17. Martins, Nuno R. & Carrilho da Graça, Guilherme, 2017. "Impact of outdoor PM2.5 on natural ventilation usability in California’s nondomestic buildings," Applied Energy, Elsevier, vol. 189(C), pages 711-724.
    18. Sakamoto, Tomoyuki & Managi, Shunsuke, 2017. "New evidence of environmental efficiency on the export performance," Applied Energy, Elsevier, vol. 185(P1), pages 615-626.
    19. Zhao, Yuhuan & Shi, Qiaoling & li, Hao & Qian, Zhiling & Zheng, Lu & Wang, Song & He, Yizhang, 2022. "Simulating the economic and environmental effects of integrated policies in energy-carbon-water nexus of China," Energy, Elsevier, vol. 238(PA).
    20. Oreggioni, G.D. & Mahiques, O. & Monforti-Ferrario, F. & Schaaf, E. & Muntean, M. & Guizzardi, D. & Vignati, E. & Crippa, M., 2022. "The impacts of technological changes and regulatory frameworks on global air pollutant emissions from the energy industry and road transport," Energy Policy, Elsevier, vol. 168(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:appene:v:218:y:2018:i:c:p:46-53. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.elsevier.com/wps/find/journaldescription.cws_home/405891/description#description .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.