IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v14y2021i6p1640-d517456.html
   My bibliography  Save this article

Dairy Manure Digestate Age Increases Ultrasound Disintegration Efficiency at Low Specific Energies

Author

Listed:
  • Matthijs H. Somers

    (Department of Chemical Engineering, Process and Environmental Technology Lab, KU Leuven, Jan Pieter De Nayerlaan 5, B-2860 Sint-Katelijne-Waver, Belgium)

  • Samet Azman

    (Department of Chemical Engineering, Process and Environmental Technology Lab, KU Leuven, Jan Pieter De Nayerlaan 5, B-2860 Sint-Katelijne-Waver, Belgium)

  • Ruud Vanhecke

    (Department of Chemical Engineering, Process and Environmental Technology Lab, KU Leuven, Jan Pieter De Nayerlaan 5, B-2860 Sint-Katelijne-Waver, Belgium)

  • Lise Appels

    (Department of Chemical Engineering, Process and Environmental Technology Lab, KU Leuven, Jan Pieter De Nayerlaan 5, B-2860 Sint-Katelijne-Waver, Belgium)

Abstract

Substantial insight into the effect of ultrasound disintegration on the changes in biochemical parameters of manure digestate and digestate age is needed to understand the potential of digestate treatment. To address this knowledge gap, in this study, the effect of digestate age on the efficiency of ultrasound (US) disintegration was investigated. In this scope, dairy manure digestate samples were incubated in an oven at 37 °C for a predetermined amount of time to obtain simulated digestate ages of 15, 22, 29, 36 and 43 days. The results showed that US disintegration efficiency significantly affected the initial biochemical characteristics of digestate and that the digestate age had a significant effect on the US disintegration efficiency. This effect diminished when the applied specific energy (SE) was higher than 3000 kJ/kg total solids (TS). A numerical partial least squares (PLS) model was constructed to investigate the relative influences of the initial biochemical parameters on the soluble chemical oxygen demand (sCOD) and soluble carbohydrates (sCARB) solubilization. The results of the high-quality (R 2 = 0.8) model indicated that the most influential parameters for the efficiency of US disintegration were the SE, the initial sCARB 0 , the TS, the initial sCOD 0 and the volatile solids (VS).

Suggested Citation

  • Matthijs H. Somers & Samet Azman & Ruud Vanhecke & Lise Appels, 2021. "Dairy Manure Digestate Age Increases Ultrasound Disintegration Efficiency at Low Specific Energies," Energies, MDPI, vol. 14(6), pages 1-15, March.
    • Handle: RePEc:gam:jeners:v:14:y:2021:i:6:p:1640-:d:517456
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/14/6/1640/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/14/6/1640/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Appels, Lise & Lauwers, Joost & Degrève, Jan & Helsen, Lieve & Lievens, Bart & Willems, Kris & Van Impe, Jan & Dewil, Raf, 2011. "Anaerobic digestion in global bio-energy production: Potential and research challenges," Renewable and Sustainable Energy Reviews, Elsevier, vol. 15(9), pages 4295-4301.
    2. Monika Zubrowska-Sudol & Aleksandra Dzido & Agnieszka Garlicka & Piotr Krawczyk & Michał Stępień & Katarzyna Umiejewska & Justyna Walczak & Marcin Wołowicz & Katarzyna Sytek-Szmeichel, 2020. "Innovative Hydrodynamic Disintegrator Adjusted to Agricultural Substrates Pre-treatment Aimed at Methane Production Intensification—CFD Modelling and Batch Tests," Energies, MDPI, vol. 13(16), pages 1-19, August.
    3. Azman, Samet & Milh, Hannah & Somers, Matthijs H. & Zhang, Huili & Huybrechts, Ine & Meers, Erik & Meesschaert, Boudewijn & Dewil, Raf & Appels, Lise, 2020. "Ultrasound-assisted digestate treatment of manure digestate for increased biogas production in small pilot scale anaerobic digesters," Renewable Energy, Elsevier, vol. 152(C), pages 664-673.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Aleksandra Chuda & Konrad Jastrząbek & Krzysztof Ziemiński, 2022. "Changes in the Composition of Digestate Liquid Fraction after Ozone and Ultrasonic Post-Treatment," Energies, MDPI, vol. 15(23), pages 1-15, December.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Edwards, Joel & Othman, Maazuza & Burn, Stewart, 2015. "A review of policy drivers and barriers for the use of anaerobic digestion in Europe, the United States and Australia," Renewable and Sustainable Energy Reviews, Elsevier, vol. 52(C), pages 815-828.
    2. Gahyun Baek & Jaai Kim & Jinsu Kim & Changsoo Lee, 2018. "Role and Potential of Direct Interspecies Electron Transfer in Anaerobic Digestion," Energies, MDPI, vol. 11(1), pages 1-18, January.
    3. Safieddin Ardebili, Seyed Mohammad, 2020. "Green electricity generation potential from biogas produced by anaerobic digestion of farm animal waste and agriculture residues in Iran," Renewable Energy, Elsevier, vol. 154(C), pages 29-37.
    4. Awasthi, Mukesh Kumar & Ferreira, Jorge A. & Sirohi, Ranjna & Sarsaiya, Surendra & Khoshnevisan, Benyamin & Baladi, Samin & Sindhu, Raveendran & Binod, Parameswaran & Pandey, Ashok & Juneja, Ankita & , 2021. "A critical review on the development stage of biorefinery systems towards the management of apple processing-derived waste," Renewable and Sustainable Energy Reviews, Elsevier, vol. 143(C).
    5. Di Maria, Francesco & Sordi, Alessio & Cirulli, Giuseppe & Micale, Caterina, 2015. "Amount of energy recoverable from an existing sludge digester with the co-digestion with fruit and vegetable waste at reduced retention time," Applied Energy, Elsevier, vol. 150(C), pages 9-14.
    6. Hagos, Kiros & Zong, Jianpeng & Li, Dongxue & Liu, Chang & Lu, Xiaohua, 2017. "Anaerobic co-digestion process for biogas production: Progress, challenges and perspectives," Renewable and Sustainable Energy Reviews, Elsevier, vol. 76(C), pages 1485-1496.
    7. Ghasimi, Dara S.M. & de Kreuk, Merle & Maeng, Sung Kyu & Zandvoort, Marcel H. & van Lier, Jules B., 2016. "High-rate thermophilic bio-methanation of the fine sieved fraction from Dutch municipal raw sewage: Cost-effective potentials for on-site energy recovery," Applied Energy, Elsevier, vol. 165(C), pages 569-582.
    8. Masebinu, S.O. & Akinlabi, E.T. & Muzenda, E. & Aboyade, A.O., 2019. "A review of biochar properties and their roles in mitigating challenges with anaerobic digestion," Renewable and Sustainable Energy Reviews, Elsevier, vol. 103(C), pages 291-307.
    9. Cristiane Romio & Michael Vedel Wegener Kofoed & Henrik Bjarne Møller, 2021. "Digestate Post-Treatment Strategies for Additional Biogas Recovery: A Review," Sustainability, MDPI, vol. 13(16), pages 1-27, August.
    10. Alessio Siciliano & Maria Assuntina Stillitano & Carlo Limonti, 2016. "Energetic Valorization of Wet Olive Mill Wastes through a Suitable Integrated Treatment: H 2 O 2 with Lime and Anaerobic Digestion," Sustainability, MDPI, vol. 8(11), pages 1-15, November.
    11. Heerenklage, J. & Rechtenbach, D. & Atamaniuk, I. & Alassali, A. & Raga, R. & Koch, K. & Kuchta, K., 2019. "Development of a method to produce standardised and storable inocula for biomethane potential tests – Preliminary steps," Renewable Energy, Elsevier, vol. 143(C), pages 753-761.
    12. Pecchi, Matteo & Baratieri, Marco, 2019. "Coupling anaerobic digestion with gasification, pyrolysis or hydrothermal carbonization: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 105(C), pages 462-475.
    13. Van Meerbeek, Koenraad & Muys, Bart & Hermy, Martin, 2019. "Lignocellulosic biomass for bioenergy beyond intensive cropland and forests," Renewable and Sustainable Energy Reviews, Elsevier, vol. 102(C), pages 139-149.
    14. Kougias, P.G. & Kotsopoulos, T.A. & Martzopoulos, G.G., 2014. "Effect of feedstock composition and organic loading rate during the mesophilic co-digestion of olive mill wastewater and swine manure," Renewable Energy, Elsevier, vol. 69(C), pages 202-207.
    15. Ghanimeh, Sophia & Khalil, Charbel Abou & Stoecklein, Daniel & Kommasojula, Aditya & Ganapathysubramanian, Baskar, 2020. "Flow sculpting enabled anaerobic digester for energy recovery from low-solid content waste," Renewable Energy, Elsevier, vol. 154(C), pages 841-848.
    16. Tariq, Mohsin & Mehmood, Ayaz & Abbas, Yasir & Rukh, Shah & Shah, Fayyaz Ali & Hassan, Ahmed & Gurmani, Ali Raza & Ahmed, Zahoor & Yun, Sining, 2024. "Digestate quality and biogas enhancement with laterite mineral and biochar: Performance and mechanism in anaerobic digestion," Renewable Energy, Elsevier, vol. 220(C).
    17. Ahmad Dar, Rouf & Ahmad Dar, Eajaz & Kaur, Ajit & Gupta Phutela, Urmila, 2018. "Sweet sorghum-a promising alternative feedstock for biofuel production," Renewable and Sustainable Energy Reviews, Elsevier, vol. 82(P3), pages 4070-4090.
    18. Lamis Yousra Shahrazed Khelifa Zouaghi & Hayet Djelal & Zineb Salem, 2021. "Anaerobic co-digestion of three organic wastes under mesophilic conditions: lab-scale and pilot-scale studies," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 23(6), pages 9014-9028, June.
    19. Janina Piekutin & Monika Puchlik & Michał Haczykowski & Katarzyna Dyczewska, 2021. "The Efficiency of the Biogas Plant Operation Depending on the Substrate Used," Energies, MDPI, vol. 14(11), pages 1-12, May.
    20. Aleksandra Chuda & Konrad Jastrząbek & Krzysztof Ziemiński, 2022. "Changes in the Composition of Digestate Liquid Fraction after Ozone and Ultrasonic Post-Treatment," Energies, MDPI, vol. 15(23), pages 1-15, December.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:14:y:2021:i:6:p:1640-:d:517456. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.