IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i14p2818-d250567.html
   My bibliography  Save this article

Evaluation of Infrared Radiation Combined with Hot Air Convection for Energy-Efficient Drying of Biomass

Author

Listed:
  • Hany S. EL-Mesery

    (School of Energy and Power Engineering, Jiangsu University, Zhenjiang 212013, China
    Department of Crop Handling and Processing, Agricultural Engineering Research Institute, Agricultural Research Center, Dokki, Giza 12618, Egypt)

  • Abd El-Fatah Abomohra

    (New Energy Department, School of Energy and Power Engineering, Jiangsu University, Zhenjiang 212013, China
    Botany Department, Faculty of Science, Tanta University, Tanta 31527, Egypt)

  • Chan-Ung Kang

    (Department of Earth Resources and Environmental Engineering, Hanyang University, Seoul 04763, Korea)

  • Ji-Kwang Cheon

    (Department of Earth Resources and Environmental Engineering, Hanyang University, Seoul 04763, Korea)

  • Bikram Basak

    (Department of Earth Resources and Environmental Engineering, Hanyang University, Seoul 04763, Korea)

  • Byong-Hun Jeon

    (Department of Earth Resources and Environmental Engineering, Hanyang University, Seoul 04763, Korea)

Abstract

Cost-effective biomass drying is a key challenge for energy recovery from biomass by direct combustion, gasification, and pyrolysis. The aim of the present study was to optimize the process of biomass drying using hot air convection (HA), infrared (IR), and combined drying systems (IR-HA). The specific energy consumption (SEC) decreased significantly by increasing the drying temperature using convective drying, but higher air velocities increased the SEC. Similarly, increasing air velocity in the infrared dryer resulted in a significant increase in SEC. The lowest SEC was recorded at 7.8 MJ/kg at an air velocity of 0.5 m/s and an IR intensity of 0.30 W/cm 2 , while a maximum SEC (20.7 MJ/kg) was observed at 1.0 m/s and 0.15 W/cm 2 . However, a significant reduction in the SEC was noticed in the combined drying system. A minimum SEC of 3.8 MJ/kg was recorded using the combined infrared-hot air convection (IR-HA) drying system, which was 91.7% and 51.7% lower than convective and IR dryers, respectively. The present study suggested a combination of IR and hot air convection at 60 °C, 0.3 W/cm 2 and 0.5 m/s as optimum conditions for efficient drying of biomass with a high water content.

Suggested Citation

  • Hany S. EL-Mesery & Abd El-Fatah Abomohra & Chan-Ung Kang & Ji-Kwang Cheon & Bikram Basak & Byong-Hun Jeon, 2019. "Evaluation of Infrared Radiation Combined with Hot Air Convection for Energy-Efficient Drying of Biomass," Energies, MDPI, vol. 12(14), pages 1-15, July.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:14:p:2818-:d:250567
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/14/2818/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/14/2818/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Kumar, Ashwani & Kumar, Kapil & Kaushik, Naresh & Sharma, Satyawati & Mishra, Saroj, 2010. "Renewable energy in India: Current status and future potentials," Renewable and Sustainable Energy Reviews, Elsevier, vol. 14(8), pages 2434-2442, October.
    2. El-Sheekh, Mostafa & Abomohra, Abd El-Fatah & Eladel, Hamed & Battah, Mohamed & Mohammed, Soha, 2018. "Screening of different species of Scenedesmus isolated from Egyptian freshwater habitats for biodiesel production," Renewable Energy, Elsevier, vol. 129(PA), pages 114-120.
    3. Chen, Longjian & Xing, Li & Han, Lujia, 2009. "Renewable energy from agro-residues in China: Solid biofuels and biomass briquetting technology," Renewable and Sustainable Energy Reviews, Elsevier, vol. 13(9), pages 2689-2695, December.
    4. Lamidi, Rasaq. O. & Jiang, L. & Pathare, Pankaj B. & Wang, Y.D. & Roskilly, A.P., 2019. "Recent advances in sustainable drying of agricultural produce: A review," Applied Energy, Elsevier, vol. 233, pages 367-385.
    5. Dev, Subhabrata & Saha, Shouvik & Kurade, Mayur B. & Salama, El-Sayed & El-Dalatony, Marwa M. & Ha, Geon-Soo & Chang, Soon Woong & Jeon, Byong-Hun, 2019. "Perspective on anaerobic digestion for biomethanation in cold environments," Renewable and Sustainable Energy Reviews, Elsevier, vol. 103(C), pages 85-95.
    6. Rathore, N.S. & Panwar, N.L., 2010. "Experimental studies on hemi cylindrical walk-in type solar tunnel dryer for grape drying," Applied Energy, Elsevier, vol. 87(8), pages 2764-2767, August.
    7. Sharma, G.P. & Prasad, Suresh, 2006. "Specific energy consumption in microwave drying of garlic cloves," Energy, Elsevier, vol. 31(12), pages 1921-1926.
    8. Singh, Panna Lal, 2011. "Silk cocoon drying in forced convection type solar dryer," Applied Energy, Elsevier, vol. 88(5), pages 1720-1726, May.
    9. Anderson, Jan-Olof & Westerlund, Lars, 2014. "Improved energy efficiency in sawmill drying system," Applied Energy, Elsevier, vol. 113(C), pages 891-901.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Alberto Barragán-García & Miguel Fernández-Muñoz & Efrén Díez-Jiménez, 2020. "Lightweight Equipment Using Multiple Torches for Fast Speed Asphalt Roofing," Energies, MDPI, vol. 13(9), pages 1-21, May.
    2. EL-Mesery, Hany S. & EL-Seesy, Ahmed I. & Hu, Zicheng & Li, Yang, 2022. "Recent developments in solar drying technology of food and agricultural products: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 157(C).
    3. Iman Golpour & Mohammad Kaveh & Ana M. Blanco-Marigorta & José Daniel Marcos & Raquel P. F. Guiné & Reza Amiri Chayjan & Esmail Khalife & Hamed Karami, 2022. "Multi-Response Design Optimisation of a Combined Fluidised Bed-Infrared Dryer for Terebinth ( Pistacia atlantica L.) Fruit Drying Process Based on Energy and Exergy Assessments by Applying RSM-CCD Mod," Sustainability, MDPI, vol. 14(22), pages 1-27, November.
    4. Hasan Demir & Hande Demir & Biljana Lončar & Lato Pezo & Ivan Brandić & Neven Voća & Fatma Yilmaz, 2023. "Optimization of Caper Drying Using Response Surface Methodology and Artificial Neural Networks for Energy Efficiency Characteristics," Energies, MDPI, vol. 16(4), pages 1-14, February.
    5. Efrén Díez-Jiménez & Alberto Vidal-Sánchez & Alberto Barragán-García & Miguel Fernández-Muñoz & Ricardo Mallol-Poyato, 2019. "Lightweight Equipment for the Fast Installation of Asphalt Roofing Based on Infrared Heaters," Energies, MDPI, vol. 12(22), pages 1-20, November.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Lingayat, Abhay Bhanudas & Chandramohan, V.P. & Raju, V.R.K. & Meda, Venkatesh, 2020. "A review on indirect type solar dryers for agricultural crops – Dryer setup, its performance, energy storage and important highlights," Applied Energy, Elsevier, vol. 258(C).
    2. Lamidi, Rasaq. O. & Jiang, L. & Pathare, Pankaj B. & Wang, Y.D. & Roskilly, A.P., 2019. "Recent advances in sustainable drying of agricultural produce: A review," Applied Energy, Elsevier, vol. 233, pages 367-385.
    3. Angelo Del Giudice & Andrea Acampora & Enrico Santangelo & Luigi Pari & Simone Bergonzoli & Ettore Guerriero & Francesco Petracchini & Marco Torre & Valerio Paolini & Francesco Gallucci, 2019. "Wood Chip Drying through the Using of a Mobile Rotary Dryer," Energies, MDPI, vol. 12(9), pages 1-16, April.
    4. Shiva Gorjian & Behnam Hosseingholilou & Laxmikant D. Jathar & Haniyeh Samadi & Samiran Samanta & Atul A. Sagade & Karunesh Kant & Ravishankar Sathyamurthy, 2021. "Recent Advancements in Technical Design and Thermal Performance Enhancement of Solar Greenhouse Dryers," Sustainability, MDPI, vol. 13(13), pages 1-32, June.
    5. Hao, Wengang & Lu, Yifeng & Lai, Yanhua & Yu, Hongwen & Lyu, Mingxin, 2018. "Research on operation strategy and performance prediction of flat plate solar collector with dual-function for drying agricultural products," Renewable Energy, Elsevier, vol. 127(C), pages 685-696.
    6. Defraeye, Thijs, 2014. "Advanced computational modelling for drying processes – A review," Applied Energy, Elsevier, vol. 131(C), pages 323-344.
    7. Bazmi, Aqeel Ahmed & Zahedi, Gholamreza & Hashim, Haslenda, 2011. "Progress and challenges in utilization of palm oil biomass as fuel for decentralized electricity generation," Renewable and Sustainable Energy Reviews, Elsevier, vol. 15(1), pages 574-583, January.
    8. Mathew, Adarsh Abi & Thangavel, Venugopal, 2021. "A novel thermal energy storage integrated evacuated tube heat pipe solar dryer for agricultural products: Performance and economic evaluation," Renewable Energy, Elsevier, vol. 179(C), pages 1674-1693.
    9. Tiwari, Sumit & Tiwari, G.N., 2016. "Exergoeconomic analysis of photovoltaic-thermal (PVT) mixed mode greenhouse solar dryer," Energy, Elsevier, vol. 114(C), pages 155-164.
    10. Yin, Yonggao & Zheng, Baojun & Yang, Can & Zhang, Xiaosong, 2015. "A proposed compressed air drying method using pressurized liquid desiccant and experimental verification," Applied Energy, Elsevier, vol. 141(C), pages 80-89.
    11. Bazmi, Aqeel Ahmed & Zahedi, Gholamreza, 2011. "Sustainable energy systems: Role of optimization modeling techniques in power generation and supply—A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 15(8), pages 3480-3500.
    12. Leino, M. & Uusitalo, V. & Grönman, A. & Nerg, J. & Horttanainen, M. & Soukka, R. & Pyrhönen, J., 2016. "Economics and greenhouse gas balance of distributed electricity production at sawmills using hermetic turbogenerator," Renewable Energy, Elsevier, vol. 88(C), pages 102-111.
    13. Huang, Shih-Chieh & Lo, Shang-Lien & Lin, Yen-Ching, 2013. "Application of a fuzzy cognitive map based on a structural equation model for the identification of limitations to the development of wind power," Energy Policy, Elsevier, vol. 63(C), pages 851-861.
    14. Evan Eduard Susanto & Agus Saptoro & Perumal Kumar & Angnes Ngieng Tze Tiong & Aditya Putranto & Suherman Suherman, 2024. "7E + Q analysis: a new multi-dimensional assessment tool of solar dryer for food and agricultural products," Environment, Development and Sustainability: A Multidisciplinary Approach to the Theory and Practice of Sustainable Development, Springer, vol. 26(7), pages 16363-16385, July.
    15. S Ayyappan, 2018. "Performance and CO2 mitigation analysis of a solar greenhouse dryer for coconut drying," Energy & Environment, , vol. 29(8), pages 1482-1494, December.
    16. Singh, Pushpendra & Shrivastava, Vipin & Kumar, Anil, 2018. "Recent developments in greenhouse solar drying: A review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 82(P3), pages 3250-3262.
    17. M. A. Tawfik & Khaled M. Oweda & M. K. Abd El-Wahab & W. E. Abd Allah, 2023. "A New Mode of a Natural Convection Solar Greenhouse Dryer for Domestic Usage: Performance Assessment for Grape Drying," Agriculture, MDPI, vol. 13(5), pages 1-27, May.
    18. Toklu, E., 2013. "Overview of potential and utilization of renewable energy sources in Turkey," Renewable Energy, Elsevier, vol. 50(C), pages 456-463.
    19. Ferraz de Campos, Victor Arruda & Silva, Valter Bruno & Cardoso, João Sousa & Brito, Paulo S. & Tuna, Celso Eduardo & Silveira, José Luz, 2021. "A review of waste management in Brazil and Portugal: Waste-to-energy as pathway for sustainable development," Renewable Energy, Elsevier, vol. 178(C), pages 802-820.
    20. Jaime Jaimes-Estévez & German Zafra & Jaime Martí-Herrero & Guillermo Pelaz & Antonio Morán & Alejandra Puentes & Christian Gomez & Liliana del Pilar Castro & Humberto Escalante Hernández, 2020. "Psychrophilic Full Scale Tubular Digester Operating over Eight Years: Complete Performance Evaluation and Microbiological Population," Energies, MDPI, vol. 14(1), pages 1-17, December.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:14:p:2818-:d:250567. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.