IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v12y2019i11p2168-d237680.html
   My bibliography  Save this article

An Experimental and Numerical Study on Supported Ultra-Lean Methane Combustion

Author

Listed:
  • Ho-Chuan Lin

    (Department of Aeronautics and Astronautics, National Cheng Kung University, Tainan 701, Taiwan)

  • Guan-Bang Chen

    (Research Center for Energy Technology and Strategy, National Cheng Kung University, Tainan 701, Taiwan)

  • Fang-Hsien Wu

    (Research Center for Energy Technology and Strategy, National Cheng Kung University, Tainan 701, Taiwan)

  • Hong-Yeng Li

    (Department of Aeronautics and Astronautics, National Cheng Kung University, Tainan 701, Taiwan)

  • Yei-Chin Chao

    (Department of Aeronautics and Astronautics, National Cheng Kung University, Tainan 701, Taiwan)

Abstract

With a much larger global warming potential (GWP) and much shorter lifespan, the reduction of methane emissions offers an additional opportunity and a relatively quick way of mitigating climate change in the near future. However, the emissions from coal mining in the form of ventilation air methane (VAM), usually in ultra-lean concentration, pose the most significant technical challenge to the mitigation of methane emission. Therefore, a better understanding of ultra-lean methane combustion is essential. With three 5 mm × 50 mm rectangle cross-section slot jets, a novel sandwich-type triple-jet burner is proposed to provide stable combustion of an ultra-lean methane–air mixture with equivalence ratios from 0.3 to 0.88, and 0.22 in extreme conditions. The ultra-lean methane flame in the center of the triple-jet burner is supported by the two lean outer flames at an equivalence ratio φ = 0.88. The flow field and combustion chemical reactions are predicted by detailed numerical simulation with GRI-Mech 3.0 reaction mechanisms. Two-dimensional numerical results are validated with those obtained by experimental particle image velocimetry (PIV), as well as visual flame height and temperature measurements. An ultra-lean methane–air mixture has to burn with external support. In addition, the ultra-lean flame is non-propagating with a relatively low temperature. The ultra-lean center flame is seen to start from the outer flame and incline perfectly to the post-flame temperature and OH concentration profiles of the outer lean flame. The adjacent stronger flame provides heat and active radicals, such as OH and HO 2 , from the post-flame region and in the wall proximity of the gap between the adjacent flame and the central ultra-lean jet to initiate and maintain the combustion of the central ultra-lean flame. The outstanding wall-proximity radical of HO 2 is found to be the main contributor to the initiation and stabilization of the central ultra-lean flame by providing a low-temperature oxidation of fuel through the following reaction: HO 2 + CH 3 ⇔ OH + CH 3 O. The major chemical reaction paths contributing to fuel decomposition and oxidation of the supported ultra-lean center flame are also identified and delineated.

Suggested Citation

  • Ho-Chuan Lin & Guan-Bang Chen & Fang-Hsien Wu & Hong-Yeng Li & Yei-Chin Chao, 2019. "An Experimental and Numerical Study on Supported Ultra-Lean Methane Combustion," Energies, MDPI, vol. 12(11), pages 1-18, June.
    • Handle: RePEc:gam:jeners:v:12:y:2019:i:11:p:2168-:d:237680
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/12/11/2168/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/12/11/2168/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. S. A. Montzka & E. J. Dlugokencky & J. H. Butler, 2011. "Non-CO2 greenhouse gases and climate change," Nature, Nature, vol. 476(7358), pages 43-50, August.
    2. Su, Shi & Yu, Xinxiang, 2015. "A 25 kWe low concentration methane catalytic combustion gas turbine prototype unit," Energy, Elsevier, vol. 79(C), pages 428-438.
    3. Lombardi, Lidia & Carnevale, Ennio & Corti, Andrea, 2006. "Greenhouse effect reduction and energy recovery from waste landfill," Energy, Elsevier, vol. 31(15), pages 3208-3219.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Torgrim Log & Wegar Bjerkeli Pedersen, 2019. "A Common Risk Classification Concept for Safety Related Gas Leaks and Fugitive Emissions?," Energies, MDPI, vol. 12(21), pages 1-17, October.
    2. Bo Lan & Peng-Fei Gao & You-Rong Li & Jia-Jia Yu & Peng-Cheng Li, 2022. "Numerical Simulation and Theoretical Analysis of Flow Resistance Characteristics in the Honeycomb Ceramic Conduit," Energies, MDPI, vol. 15(19), pages 1-14, October.

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Theodora Karanisa & Alexandre Amato & Renee Richer & Sara Abdul Majid & Cynthia Skelhorn & Sami Sayadi, 2021. "Agricultural Production in Qatar’s Hot Arid Climate," Sustainability, MDPI, vol. 13(7), pages 1-25, April.
    2. Xiong Yang & Yingshu Liu & Ziyi Li & Chuanzhao Zhang & Yi Xing, 2018. "Vacuum Exhaust Process in Pilot-Scale Vacuum Pressure Swing Adsorption for Coal Mine Ventilation Air Methane Enrichment," Energies, MDPI, vol. 11(5), pages 1-13, April.
    3. Schaeffer, Michiel & Gohar, Laila & Kriegler, Elmar & Lowe, Jason & Riahi, Keywan & van Vuuren, Detlef, 2015. "Mid- and long-term climate projections for fragmented and delayed-action scenarios," Technological Forecasting and Social Change, Elsevier, vol. 90(PA), pages 257-268.
    4. Kiani, Mehrdad & Houshfar, Ehsan & Ashjaee, Mehdi, 2019. "Experimental investigations on the flame structure and temperature field of landfill gas in impinging slot burners," Energy, Elsevier, vol. 170(C), pages 507-520.
    5. Amornchai Challcharoenwattana & Chanathip Pharino, 2015. "Co-Benefits of Household Waste Recycling for Local Community’s Sustainable Waste Management in Thailand," Sustainability, MDPI, vol. 7(6), pages 1-21, June.
    6. Hao, Xiaoli & Yang, Hongxing & Zhang, Guoqiang, 2008. "Trigeneration: A new way for landfill gas utilization and its feasibility in Hong Kong," Energy Policy, Elsevier, vol. 36(10), pages 3662-3673, October.
    7. Marek Borowski & Piotr Życzkowski & Jianwei Cheng & Rafał Łuczak & Klaudia Zwolińska, 2020. "The Combustion of Methane from Hard Coal Seams in Gas Engines as a Technology Leading to Reducing Greenhouse Gas Emissions—Electricity Prediction Using ANN," Energies, MDPI, vol. 13(17), pages 1-18, August.
    8. Zappini, Giovanni & Cocca, Paola & Rossi, Diana, 2010. "Performance analysis of energy recovery in an Italian municipal solid waste landfill," Energy, Elsevier, vol. 35(12), pages 5063-5069.
    9. Otterbring, Tobias & Folwarczny, Michał, 2024. "Social validation, reciprocation, and sustainable orientation: Cultivating “clean†codes of conduct through social influence," Journal of Retailing and Consumer Services, Elsevier, vol. 76(C).
    10. Francisco Estrada & Luis Filipe Martins & Pierre Perron, 2017. "Characterizing and attributing the warming trend in sea and land surface temperatures," Boston University - Department of Economics - Working Papers Series WP2017-009, Boston University - Department of Economics.
    11. Qiu, Xin & Jin, Jianjun & He, Rui & Mao, Jiansu, 2022. "The deviation between the willingness and behavior of farmers to adopt electricity-saving tricycles and its influencing factors in Dazu District of China," Energy Policy, Elsevier, vol. 167(C).
    12. Yang Ou & Christopher Roney & Jameel Alsalam & Katherine Calvin & Jared Creason & Jae Edmonds & Allen A. Fawcett & Page Kyle & Kanishka Narayan & Patrick O’Rourke & Pralit Patel & Shaun Ragnauth & Ste, 2021. "Deep mitigation of CO2 and non-CO2 greenhouse gases toward 1.5 °C and 2 °C futures," Nature Communications, Nature, vol. 12(1), pages 1-9, December.
    13. Tomas Ekvall & Martin Hirschnitz-Garbers & Fabio Eboli & Aleksander Śniegocki, 2016. "A Systemic and Systematic Approach to the Development of a Policy Mix for Material Resource Efficiency," Sustainability, MDPI, vol. 8(4), pages 1-26, April.
    14. Sovacool, Benjamin K. & Griffiths, Steve & Kim, Jinsoo & Bazilian, Morgan, 2021. "Climate change and industrial F-gases: A critical and systematic review of developments, sociotechnical systems and policy options for reducing synthetic greenhouse gas emissions," Renewable and Sustainable Energy Reviews, Elsevier, vol. 141(C).
    15. Spiritus, Kevin & Lehmann, Etienne & Renes, Sander & Zoutman, Floris T., 0. "Optimal taxation with multiple incomes and types," Theoretical Economics, Econometric Society.
    16. Zheng, Shizhuo & Zhang, Xin & Wang, Tao & Liu, Jie, 2015. "An experimental study on premixed laminar and turbulent combustion of synthesized coalbed methane," Energy, Elsevier, vol. 92(P3), pages 355-364.
    17. Zhang, Xiaogang & Ranjith, P.G. & Ranathunga, A.S., 2019. "Sub- and super-critical carbon dioxide flow variations in large high-rank coal specimen: An experimental study," Energy, Elsevier, vol. 181(C), pages 148-161.
    18. Athanasios Balafoutis & Bert Beck & Spyros Fountas & Jurgen Vangeyte & Tamme Van der Wal & Iria Soto & Manuel Gómez-Barbero & Andrew Barnes & Vera Eory, 2017. "Precision Agriculture Technologies Positively Contributing to GHG Emissions Mitigation, Farm Productivity and Economics," Sustainability, MDPI, vol. 9(8), pages 1-28, July.
    19. Tsipis, E.V. & Agarkov, D.A. & Borisov, Yu.A. & Kiseleva, S.V. & Tarasenko, A.B. & Bredikhin, S.I. & Kharton, V.V., 2023. "Waste gas utilization potential for solid oxide fuel cells: A brief review," Renewable and Sustainable Energy Reviews, Elsevier, vol. 188(C).
    20. Kazemi-Beydokhti, Amin & Zeinali Heris, Saeed, 2012. "Thermal optimization of combined heat and power (CHP) systems using nanofluids," Energy, Elsevier, vol. 44(1), pages 241-247.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:12:y:2019:i:11:p:2168-:d:237680. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.