IDEAS home Printed from https://ideas.repec.org/a/eee/energy/v201y2020ics0360544220307258.html
   My bibliography  Save this article

Comparison of aqueous and non-aqueous alkanolamines solutions for carbon dioxide desorption in a microreactor

Author

Listed:
  • Aghel, Babak
  • Sahraie, Sasan
  • Heidaryan, Ehsan

Abstract

An experimental study of CO2 desorption from aqueous and non-aqueous saturated alkanolamine solutions carried out in a tubular microreactor, consisting of a stainless steel microtube with an internal diameter of 800 μm and a total length of 35 cm. We tested a total of six solvent mixtures of water or methanol with monoethanolamine, diethanolamine, or activated methyl diethanolamine in a broad range of operational conditions, including temperature (50–100 °C), rich solvent flow rate (0.5–4.5 ml/min), and amine concentration in the solvent (10 and 50% w/w). CO2 desorption was thoroughly characterized with respect to the mass transfer rate and energy consumption, and both were expected to improve with the use of a microreactor due to short diffusion distances and a larger surface-to-area ratio. An increase in the operating temperature or concentration of the amine resulted in a higher percentage of desorption and enhanced mass transfer rates, as shown by the local mass transfer coefficient based on the liquid phase values herein disclosed. Increasing the rich solvent flow rate also increased the local mass transfer coefficient values (80%–95%); however, the overall percentage of CO2 desorption reduced (25%–35%) due to shorter residence times in the microreactor. Similarly, the energetic desorption efficiency improved for all the solutions with increasing temperature (65–75% reduction) and concentration of amine in the solvent (20–35% reduction), yet again decreasing with an increasing flow rate of rich solvent (5–15%). Compared to the literature values for the packed columns and microreactors, our data showed the overall energy consumption up to an 88% reduction in specific CO2 desorption, demonstrating great potential for the intensification of solvent-mediated, energetically demanding CO2 desorption. In addition, the results showed that the energy consumption for CO2 desorption was reduced by 73% by choosing a non-aqueous in preference to an aqueous alkanolamine solvent.

Suggested Citation

  • Aghel, Babak & Sahraie, Sasan & Heidaryan, Ehsan, 2020. "Comparison of aqueous and non-aqueous alkanolamines solutions for carbon dioxide desorption in a microreactor," Energy, Elsevier, vol. 201(C).
    • Handle: RePEc:eee:energy:v:201:y:2020:i:c:s0360544220307258
    DOI: 10.1016/j.energy.2020.117618
    as

    Download full text from publisher

    File URL: http://www.sciencedirect.com/science/article/pii/S0360544220307258
    Download Restriction: Full text for ScienceDirect subscribers only
    File URL: https://libkey.io/10.1016/j.energy.2020.117618?utm_source=ideas
    LibKey link: if access is restricted and if your library uses this service, LibKey will redirect you to where you can use your library subscription to access this item
    ---><---

    As the access to this document is restricted, you may want to search for a different version of it.

    References listed on IDEAS

    as
    1. Zhang, Minkai & Guo, Yincheng, 2013. "Rate based modeling of absorption and regeneration for CO2 capture by aqueous ammonia solution," Applied Energy, Elsevier, vol. 111(C), pages 142-152.
    2. Rashidi, Hamed & Valeh-e-Sheyda, Peyvand & Sahraie, Sasan, 2020. "A multiobjective experimental based optimization to the CO2 capture process using hybrid solvents of MEA-MeOH and MEA-water," Energy, Elsevier, vol. 190(C).
    3. Cheung, Ocean & Bacsik, Zoltán & Liu, Qingling & Mace, Amber & Hedin, Niklas, 2013. "Adsorption kinetics for CO2 on highly selective zeolites NaKA and nano-NaKA," Applied Energy, Elsevier, vol. 112(C), pages 1326-1336.
    4. Ganapathy, H. & Shooshtari, A. & Dessiatoun, S. & Alshehhi, M. & Ohadi, M., 2014. "Fluid flow and mass transfer characteristics of enhanced CO2 capture in a minichannel reactor," Applied Energy, Elsevier, vol. 119(C), pages 43-56.
    Full references (including those not matched with items on IDEAS)

    Citations

    Citations are extracted by the CitEc Project, subscribe to its RSS feed for this item.
    as


    Cited by:

    1. Dehbani, Maryam & Rashidi, Hamed, 2023. "Simultaneous use of microfluidics, ultrasound and alcoholic solvents for improving CO2 desorption process," Energy, Elsevier, vol. 276(C).

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Ganapathy, Harish & Steinmayer, Sascha & Shooshtari, Amir & Dessiatoun, Serguei & Ohadi, Michael M. & Alshehhi, Mohamed, 2016. "Process intensification characteristics of a microreactor absorber for enhanced CO2 capture," Applied Energy, Elsevier, vol. 162(C), pages 416-427.
    2. Chao, Cong & Deng, Yimin & Dewil, Raf & Baeyens, Jan & Fan, Xianfeng, 2021. "Post-combustion carbon capture," Renewable and Sustainable Energy Reviews, Elsevier, vol. 138(C).
    3. Sreenivasulu, B. & Gayatri, D.V. & Sreedhar, I. & Raghavan, K.V., 2015. "A journey into the process and engineering aspects of carbon capture technologies," Renewable and Sustainable Energy Reviews, Elsevier, vol. 41(C), pages 1324-1350.
    4. Zhao, Zhijun & Xing, Xiao & Tang, Zhigang & Zheng, Yong & Fei, Weiyang & Liang, Xiangfeng & Ataeivarjovi, E. & Guo, Dong, 2018. "Experiment and simulation study of CO2 solubility in dimethyl carbonate, 1-octyl-3-methylimidazolium tetrafluoroborate and their mixtures," Energy, Elsevier, vol. 143(C), pages 35-42.
    5. Moioli, Stefania & Giuffrida, Antonio & Romano, Matteo C. & Pellegrini, Laura A. & Lozza, Giovanni, 2016. "Assessment of MDEA absorption process for sequential H2S removal and CO2 capture in air-blown IGCC plants," Applied Energy, Elsevier, vol. 183(C), pages 1452-1470.
    6. Wang, Fu & Zhao, Jun & Zhang, Houcheng & Miao, He & Zhao, Jiapei & Wang, Jiatang & Yuan, Jinliang & Yan, Jinyue, 2018. "Efficiency evaluation of a coal-fired power plant integrated with chilled ammonia process using an absorption refrigerator," Applied Energy, Elsevier, vol. 230(C), pages 267-276.
    7. Chu, Fengming & Yang, Lijun & Du, Xiaoze & Yang, Yongping, 2017. "Mass transfer and energy consumption for CO2 absorption by ammonia solution in bubble column," Applied Energy, Elsevier, vol. 190(C), pages 1068-1080.
    8. Guo, Hang & Liu, Xuan & Zhao, Jian Fu & Ye, Fang & Ma, Chong Fang, 2014. "Experimental study of two-phase flow in a proton exchange membrane fuel cell in short-term microgravity condition," Applied Energy, Elsevier, vol. 136(C), pages 509-518.
    9. Lin, Yi-Feng & Ko, Chia-Chieh & Chen, Chien-Hua & Tung, Kuo-Lun & Chang, Kai-Shiun & Chung, Tsair-Wang, 2014. "Sol–gel preparation of polymethylsilsesquioxane aerogel membranes for CO2 absorption fluxes in membrane contactors," Applied Energy, Elsevier, vol. 129(C), pages 25-31.
    10. Yi, Qun & Wu, Guo-sheng & Gong, Min-hui & Huang, Yi & Feng, Jie & Hao, Yan-hong & Li, Wen-ying, 2017. "A feasibility study for CO2 recycle assistance with coke oven gas to synthetic natural gas," Applied Energy, Elsevier, vol. 193(C), pages 149-161.
    11. Li, Bao-Hong & Zhang, Nan & Smith, Robin, 2016. "Simulation and analysis of CO2 capture process with aqueous monoethanolamine solution," Applied Energy, Elsevier, vol. 161(C), pages 707-717.
    12. Choi, Munkyoung & Cho, Minki & Lee, J.W., 2016. "Empirical formula for the mass flux in chemical absorption of CO2 with ammonia droplets," Applied Energy, Elsevier, vol. 164(C), pages 1-9.
    13. Rashidi, Hamed & Valeh-e-Sheyda, Peyvand & Sahraie, Sasan, 2020. "A multiobjective experimental based optimization to the CO2 capture process using hybrid solvents of MEA-MeOH and MEA-water," Energy, Elsevier, vol. 190(C).
    14. Ganapathy, H. & Shooshtari, A. & Dessiatoun, S. & Alshehhi, M. & Ohadi, M., 2014. "Fluid flow and mass transfer characteristics of enhanced CO2 capture in a minichannel reactor," Applied Energy, Elsevier, vol. 119(C), pages 43-56.
    15. Rashidi, Hamed & Mamivand, Sajad, 2022. "Experimental and numerical mass transfer study of carbon dioxide absorption using Al2O3/water nanofluid in wetted wall column," Energy, Elsevier, vol. 238(PA).
    16. Shakerian, Farid & Kim, Ki-Hyun & Szulejko, Jan E. & Park, Jae-Woo, 2015. "A comparative review between amines and ammonia as sorptive media for post-combustion CO2 capture," Applied Energy, Elsevier, vol. 148(C), pages 10-22.
    17. Lin, Yi-Feng & Chang, Jun-Min & Ye, Qian & Tung, Kuo-Lun, 2015. "Hydrophobic fluorocarbon-modified silica aerogel tubular membranes with excellent CO2 recovery ability in membrane contactors," Applied Energy, Elsevier, vol. 154(C), pages 21-25.
    18. Chen, S.J. & Zhu, M. & Fu, Y. & Huang, Y.X. & Tao, Z.C. & Li, W.L., 2017. "Using 13X, LiX, and LiPdAgX zeolites for CO2 capture from post-combustion flue gas," Applied Energy, Elsevier, vol. 191(C), pages 87-98.
    19. Tsay, Calvin & Pattison, Richard C. & Zhang, Yue & Rochelle, Gary T. & Baldea, Michael, 2019. "Rate-based modeling and economic optimization of next-generation amine-based carbon capture plants," Applied Energy, Elsevier, vol. 252(C), pages 1-1.
    20. Dehbani, Maryam & Rashidi, Hamed, 2023. "Simultaneous use of microfluidics, ultrasound and alcoholic solvents for improving CO2 desorption process," Energy, Elsevier, vol. 276(C).

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:eee:energy:v:201:y:2020:i:c:s0360544220307258. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: Catherine Liu (email available below). General contact details of provider: http://www.journals.elsevier.com/energy .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.