IDEAS home Printed from https://ideas.repec.org/a/gam/jeners/v16y2023i18p6505-d1236527.html
   My bibliography  Save this article

Impact Analysis of Metallization Design and Recombination Losses on Performance of Crystalline Silicon Solar Cells

Author

Listed:
  • Nowshad Amin

    (Institute of Sustainable Energy (ISE), Universiti Tenaga Nasional (@UNITEN, The National Energy University), Kajang 43000, Selangor, Malaysia)

  • Sathiswary Santhiran

    (Institute of Sustainable Energy (ISE), Universiti Tenaga Nasional (@UNITEN, The National Energy University), Kajang 43000, Selangor, Malaysia)

  • Nabilah Mat Kassim

    (Institute of Sustainable Energy (ISE), Universiti Tenaga Nasional (@UNITEN, The National Energy University), Kajang 43000, Selangor, Malaysia)

  • Ammar Ahmed Alkahtani

    (Institute of Sustainable Energy (ISE), Universiti Tenaga Nasional (@UNITEN, The National Energy University), Kajang 43000, Selangor, Malaysia)

  • Mohammad Aminul Islam

    (Department of Electrical Engineering, Faculty of Engineering, Universiti Malaya, Jalan University, Kuala Lumpur 50603, Selangor, Malaysia)

  • Mohd Yusrizal Mohd Yusof

    (TNB Renewables Sdn. Bhd. (TRe), 16A Persiaran Barat, Petaling Jaya 46050, Selangor, Malaysia)

Abstract

Using Griddler software, this study aims to select the optimal metallization design by analyzing the impact of the number and sizes of busbars and fingers on a solar cell’s performance. There is interest in the PV industry to reduce the finger size toward 25 μm in upcoming years. It is shown that an increase in the number and size of busbars and fingers causes an increase in the fill factor; however, with regards to the cell’s efficiency, the shading factor should be considered in addition to the size and number of metal contacts. The results of this study indicate that solar cells’ efficiency could be increased by 0.33–0.84% when using five busbars and a finger width of 35 μm. Moreover, this increase is achieved by reducing the emitter resistance to less than 60 ohm/sq and considering a recombination rate of about 165 fA/cm 2 .

Suggested Citation

  • Nowshad Amin & Sathiswary Santhiran & Nabilah Mat Kassim & Ammar Ahmed Alkahtani & Mohammad Aminul Islam & Mohd Yusrizal Mohd Yusof, 2023. "Impact Analysis of Metallization Design and Recombination Losses on Performance of Crystalline Silicon Solar Cells," Energies, MDPI, vol. 16(18), pages 1-10, September.
    • Handle: RePEc:gam:jeners:v:16:y:2023:i:18:p:6505-:d:1236527
    as

    Download full text from publisher

    File URL: https://www.mdpi.com/1996-1073/16/18/6505/pdf
    Download Restriction: no
    File URL: https://www.mdpi.com/1996-1073/16/18/6505/
    Download Restriction: no
    ---><---

    References listed on IDEAS

    as
    1. Abdulwahab A. Q. Hasan & Ammar Ahmed Alkahtani & Seyed Ahmad Shahahmadi & Mohammad Nur E. Alam & Mohammad Aminul Islam & Nowshad Amin, 2021. "Delamination-and Electromigration-Related Failures in Solar Panels—A Review," Sustainability, MDPI, vol. 13(12), pages 1-23, June.
    Full references (including those not matched with items on IDEAS)

    Most related items

    These are the items that most often cite the same works as this one and are cited by the same works as this one.
    1. Meena, Roopmati & Pareek, Arti & Gupta, Rajesh, 2024. "A comprehensive Review on interfacial delamination in photovoltaic modules," Renewable and Sustainable Energy Reviews, Elsevier, vol. 189(PA).
    2. Tuhibur Rahman & Ahmed Al Mansur & Molla Shahadat Hossain Lipu & Md. Siddikur Rahman & Ratil H. Ashique & Mohamad Abou Houran & Rajvikram Madurai Elavarasan & Eklas Hossain, 2023. "Investigation of Degradation of Solar Photovoltaics: A Review of Aging Factors, Impacts, and Future Directions toward Sustainable Energy Management," Energies, MDPI, vol. 16(9), pages 1-30, April.
    3. Gabriella-Stefánia Szabó & Róbert Szabó & Loránd Szabó, 2022. "A Review of the Mitigating Methods against the Energy Conversion Decrease in Solar Panels," Energies, MDPI, vol. 15(18), pages 1-21, September.
    4. Joshuva Arockia Dhanraj & Ali Mostafaeipour & Karthikeyan Velmurugan & Kuaanan Techato & Prem Kumar Chaurasiya & Jenoris Muthiya Solomon & Anitha Gopalan & Khamphe Phoungthong, 2021. "An Effective Evaluation on Fault Detection in Solar Panels," Energies, MDPI, vol. 14(22), pages 1-14, November.

    Corrections

    All material on this site has been provided by the respective publishers and authors. You can help correct errors and omissions. When requesting a correction, please mention this item's handle: RePEc:gam:jeners:v:16:y:2023:i:18:p:6505-:d:1236527. See general information about how to correct material in RePEc.

    If you have authored this item and are not yet registered with RePEc, we encourage you to do it here. This allows to link your profile to this item. It also allows you to accept potential citations to this item that we are uncertain about.

    If CitEc recognized a bibliographic reference but did not link an item in RePEc to it, you can help with this form .

    If you know of missing items citing this one, you can help us creating those links by adding the relevant references in the same way as above, for each refering item. If you are a registered author of this item, you may also want to check the "citations" tab in your RePEc Author Service profile, as there may be some citations waiting for confirmation.

    For technical questions regarding this item, or to correct its authors, title, abstract, bibliographic or download information, contact: MDPI Indexing Manager (email available below). General contact details of provider: https://www.mdpi.com .

    Please note that corrections may take a couple of weeks to filter through the various RePEc services.

    IDEAS is a RePEc service. RePEc uses bibliographic data supplied by the respective publishers.